2008.5 Peugeot 1007 Dag gearbox
[x] Cancel search: gearboxPage 114 of 194
7
1 0 7
CRUISE CONTROL
This cruise control, of the new genera-
tion, is linked with the speed limiter. It
has a display on the instrument panel
to indicate the memorised reference
speed.
It enables the vehicle to maintain a
steady speed programmed by the
driver.
The cruise control is switched on
manually: it requires a minimum ve-
h i c l e s p e e d o f 2 5 m p h ( 4 0 k m / h ) a n d
fourth gear must be engaged on the
manual gearbox.
The cruise control is switched off
by means of a manual action or by
pressing the brake or clutch pedal or
in the event of activation of the ESP.
By pressing the accelerator pedal, it is
possible to exceed the programmed
speed temporarily.
To return to the programmed speed,
simply release the accelerator pedal.
Switching off the ignition or turning
the dial cancels any programmed
speed value. Instrument panel display
The programmed information is
grouped together on the instrument
panel display.
5. Cruise control on/off indication
6. Cruise control mode selection in-
dication
7. Programmed speed value
Steering wheel controls
This system's controls are grouped
together on lever
A .
1. Cruise control mode selection dial
2. Value decrease button
3. Value increase button
4. Cruise control on/off button
Page 122 of 194
8
116
CHECKS
Handbrake Where the handbrake travel
is too great or there is a re-
duction in the performance
of the system, the hand-
brake should be adjusted,
even between services.
H a v e t h e s y s t e m c h e c k e d b y a P E U G E O T
dealer.
Air filter and passenger compartment filter
Particle emission filter (Diesel)
It is imperative that maintenance of
t h e p a r t i c l e e m i s s i o n fi l t e r i s c a r r i e d
out by a PEUGEOT dealer in accord-
ance with the manufacturer's servicing
schedule.
Brake pads
Brake pad wear depends
on the style of driving, in
particular for vehicles which
are used in town, over short
distances.
Brake disc/drum wear status
For any information relating to the
wear of the surfaces of the discs and
drums, contact a PEUGEOT dealer. Oil filter
C h a n g e t h e fi l t e r r e g u l a r l y , i n
accordance with the servic-
ing schedule.
It may be necessary to
check the thickness of the
pads, even between services.
Unless there is a leak in the c i r c u i t , a d r o p i n t h e b r a k e fl u i d l e v e l
indicates that the brake pads are
worn.
At the start of winter, have
your battery checked by a
PEUGEOT dealer.
Refer to the servicing book-
let for information on the
replacement interval for
these components.
Depending on the environ-
ment (dusty atmosphere...) and the
use of the vehicle (urban driving...),
change them twice as often, if ne
cessary (refer to the "Engines" para-
graph).
A clogged passenger compartment
fi l t e r m a y h a v e a n a d v e r s e e f f e c t o n
the performance of the air condition-
ing system and produce unpleasant
odours.
Following prolonged opera-
tion of the vehicle at very
low speed or at idle, you
may, in exceptional circum-
stances, notice steam coming from
the exhaust during acceleration. This
has no effect on the performance of
the vehicle or on the environment.
Battery
Manual gearboxThis does not require an
o i l c h a n g e . H a v e t h e l e v e l
checked in accordance with
the manufacturer's servicing
schedule.
Only use products recom-
mended by PEUGEOT or
products of equivalent qual-
ity and characteristics.
To ensure best performance from
components as important as the
braking system, PEUGEOT selects
a n d o f f e r s q u i t e s p e c i fi c p r o d u c t s .
To prevent damage to the electri-
cal units, high pressure washing of
the engine compartment is strictly
prohibited .
To check the main levels
and certain components,
in accordance with the
manufacturer's servicing
schedule, refer to the pages of the
servicing booklet which correspond
to your vehicle's engine.
Page 123 of 194
9
117
Parking the vehicle
- If possible, park the vehicle on level, stable and non-slippery
ground.
- It is imperative that you ensure that the occupants get out of the vehi-
cle and wait in a safe location.
- Apply the handbrake, switch off t h e i g n i t i o n a n d e n g a g e fi r s t o r
reverse gear (position R for the
"2 Tronic" gearbox).
CHANGING A WHEEL
1. Jack with integrated handle.
2. Chock.
3. Wheelbrace.
4. Extension.
5. "Bolt cover" tool.
6. Removable towing eye. Access to the spare wheel and
the jack
The wheel is located outside the ve-
h i c l e , u n d e r t h e r e a r fl o o r , s u p p o r t e d
by a metal carrier.
- Unclip the cover to gain access
to the spare wheel carrier retain-
ing bolt, located on the inside
near the closing system.
- Using the wheelbrace 3 and the
extension 4 , slacken the spare
wheel carrier retaining bolt.
- Lift the carrier to release the hook rearwards, then lower it.
- Remove the spare wheel and the box.
- Remove the jack 1 from the box.
Tools provided
The jack is stored in a box in the cen-
tre of the spare wheel. The chock is
fi x e d o n t h e s i d e o f t h e b o x .
The other tools are stored in a case
in the left boot trim.
Note: i f y o u r v e h i c l e i s fi t t e d w i t h a
towbar, the case is stored in the left
s t o r a g e t r a y ( l o c a t e d i n t h e fl o o r o f
the rear footwell).
Page 132 of 194
9
125
Engine compartment fuse box
Unclip the cover to gain access to
the fuses.
Once the work has been carried
out, close the cover very carefully.
Fuse N°RatingFunctions
MF1**50 AFan assembly.
MF2**30 AABS/ESP control unit.
MF3**30 AABS/ESP control unit.
MF4**60 ABuilt-in Systems Interface supply.
MF5**60 ABuilt-in Systems Interface supply.
MF6**30 A"2 Tronic" gearbox control unit.
MF7**80 APassenger compartment fuse box - "Sesame" doors control unit.
MF8**80 AElectric power steering.
Your vehicle's electrical sys-tem is designed to operate with standard or optional equipment.
** The maxi fuses provide addi-tional protection for the electrical systems. All work must be car-ried out by a PEUGEOT dealer.
Before installing other electrical equipment or accessories on your vehicle, contact a PEUGEOT dealer.
Some electrical accessories or the w a y i n w h i c h t h e y a r e fi t t e d m a y h a v e damaging effects on the operation of your vehicle (audio, control and elec-trical load circuits).
PEUGEOT will not accept responsi-bility for the cost incurred in repairing your vehicle or for rectifying malfunc-tions resulting from the installation of auxiliary accessories not supplied and not recommended by PEUGEOT and not installed in accordance with its instructions, in particular where the equipment in question consumes more than 10 milliamperes.
Page 135 of 194
9
128
BATTERY
The batteries contain harmful
substances such as sulphuric
acid and lead. They must be
disposed of in accordance
with regulations and must never be
discarded with household waste.
Take used remote control and vehi-
cle batteries to a special collection
point.
To start the vehicle from
another battery:
-
Connect the red cable to the positive
(+) terminals of the two batteries,
- Connect the green or black ca- ble to the negative (-) terminals
of the two batteries,
- Operate the starter, let the en- gine run,
- Wait for the engine to return to idle, then disconnect the cables.
Before disconnecting the
battery, you must wait for
2 minutes after switching off
the ignition.
Never disconnect a terminal when
the engine is running.
N e v e r c h a r g e a b a t t e r y w i t h o u t fi r s t
disconnecting the terminals.
Close the windows, the sunroof and
the doors before disconnecting the
battery. If they do not operate nor-
mally following reconnection of the
battery, they must be reinitialised
(see sections "Sesame doors" and
"Sunroof"). After every reconnection of the bat-
tery:
- switch on the ignition and wait
1 minute before starting to al-
low the electronic systems to be
i n i t i a l i s e d . I f s l i g h t d i f fi c u l t i e s a r e
experienced after this, please
contact a PEUGEOT dealer.
-
reinitialise the "2 Tronic" gearbox
(refer to the corresponding section).
A. Flat battery
B. Slave battery
It is advisable to disconnect
the battery if the vehicle is
not to be used for a period
of more than one month.
To charge the battery using a
battery charger:
- Disconnect the battery,
- Follow the instructions for use
given by the battery charger
manufacturer,
- Reconnect starting with the nega- tive (-) terminal,
- Check that the terminals and connectors are clean. If they are
covered with sulphate (white or
greenish deposit), disconnect
them and clean them.
Page 136 of 194
9
129
TOWING YOUR VEHICLE
From the rear:
Unclip the side of the cover using
t h e fl a t p a r t o f t h e t o w i n g e y e ,
Screw in the towing eye until it
locks. When towing with the en-
gine switched off, there is no
braking assistance.
Special features of
the "2 Tronic" gearbox
When towing with four wheels on the
ground, the following rules must be
obeyed:
- gear lever in position
N ,
- tow the vehicle at less than 30 mph (50 km/h) over a maxi-
mum distance of 30 miles (50 km).
- do not add oil to the gearbox.
From the front:
Unclip the bottom of the cover,
u s i n g t h e fl a t p a r t o f t h e t o w i n g
eye.
Screw in the towing eye until it
locks. Lifting
(2 wheels only on the road)
It is preferable to raise the vehicle by
the wheels.
Never use the radiator crossmember.
Without lifting
(4 wheels on the road)
You should always use a towbar.
The removable towing eye is stored
in the tool case, located in the left
boot trim.
Vehicles fitted with a manual
gearbox (diesel version)
I n t h e c a s e o f v e h i c l e s fi t t e d w i t h a
manual gearbox, the gear lever must
be in the neutral position.
Failure to observe this special condi-
tion may result in damage to certain
braking components and the absence
of braking assistance the next time
the engine is started.
Page 139 of 194
1010
132
* D r a i n i n g b y g r a v i t y w i t h o i l fi l l e r c a p o p e n .
MODELS:
ENGINES AND GEARBOXES
Model codes:
KM...
KFVC NFUC NFUC/P
PETROL ENGINES
1.4 litre
(75 bhp)
1.6 litre 16V
(110 bhp)
C u b i c c a p a c i t y ( c m 3
) 1 360 1 587
B o r e x s t r o k e ( m m ) 7 5 x 7 7 7 8 . 5 x 8 2
E U s t a n d a r d m a x i m u m p o w e r ( k W ) 54 80
M a x i m u m p o w e r e n g i n e s p e e d ( r p m ) 5 400 5 800
E U s t a n d a r d m a x i m u m t o r q u e ( N m ) 118 147
M a x i m u m t o r q u e e n g i n e s p e e d ( r p m ) 3 400 4 000
F u e l U n l e a d e d U n l e a d e d
C a t a l y t i c c o n v e r t e r Y e s Y e s
Gearboxes Manual
( 5 - s p e e d ) Manual
( 5 - s p e e d ) " 2 T r o n i c "
( 5 - s p e e d )
Oil capacities (in litres)
E n g i n e ( w i t h c a r t r i d g e r e p l a c e m e n t ) 3 . 1 5 * 3 . 3 5 * 3 . 3 5 *
G e a r b o x - F i n a l d r i v e 2 2 -
Page 140 of 194
1010
133
MODELS:
ENGINES AND GEARBOXES
Model codes:
KM...
8HZC 9HZC
DIESEL ENGINES
1.4 litre Turbo HDI
(70 bhp)
1.6 litre Turbo HDI 16V
(110 bhp)
C u b i c c a p a c i t y ( c m 3
) 1 398 1 560
B o r e x s t r o k e ( m m ) 7 3 . 7 x 8 2 7 5 x 8 8 . 3
E U s t a n d a r d m a x i m u m p o w e r ( k W ) 50 80
M a x i m u m p o w e r e n g i n e s p e e d ( r p m ) 4 000 4 000
E U s t a n d a r d m a x i m u m t o r q u e ( N m ) 160 240
M a x i m u m t o r q u e e n g i n e s p e e d ( r p m ) 2 000 1 750
F u e l D i e s e l D i e s e l
C a t a l y t i c c o n v e r t e r Y e s Y e s
P a r t i c l e e m i s s i o n fi l t e r N o Y e s
Gearboxes Manual
( 5 - s p e e d ) Manual
( 5 - s p e e d )
Oil capacities (in litres)
E n g i n e ( w i t h c a r t r i d g e r e p l a c e m e n t ) 3 . 8 3 . 7 5
G e a r b o x - F i n a l d r i v e 1 . 9 1 . 9