2007 Volvo C70
time of publication. Please note that some vehicles may be equipped diff\
erently, depending on special legal requirements. Optional
equipment described in this manual may not be available in all markets. \
l Volvo reserves the right to make model changes at any time, or to change\
specifications or design without notice and without incurring
obligation.
WARNING
If your vehicle is involved in an accident, unseen damage may affect its\
drivability and
safety.
WARNING
CALIFORNIA proposition 65
Engine exhaust, some of its constituents, and certain vehicle components\
contain or emit chemicals known to the state of California to
cause cancer, and birth defects or other reproductive harm. In addition,\
certain fluids contained in vehicles and certain products of
component wear contain or emit chemicals known to the State of Californi\
a to cause cancer, and birth defects or other reproductive
harm.
7 Introduction
Volvo and the environment
Volvo is committed to the well being of its customers. As a natural part\
of this commitment, we care about the environment in which we
all live. Caring for the environment means an everyday involvement in re\
ducing our environmental impact. Volvo's environmental
activities are based on a holistic view, which means we consider the ove\
rall environmental impact of a product throughout its complete
life cycle. In this context, design, production, product use, and recycl\
ing are all important considerations. In production, Volvo has partly
or completely phased out several chemicals including CFCs, lead chromate\
s, asbestos, and cadmium; and reduced the number of
chemicals used in our plants 50% since 1991.
Volvo was the first in the world to introduce into production a three-wa\
y catalytic converter with a Lambda sond, now called the heated
oxygen sensor, in 1976. The current version of this highly efficient sys\
tem reduces emissions of harmful substances (CO, HC, NOx) from
the exhaust pipe by approximately 95-99% and the search to eliminate the\
remaining emissions continues. Volvo is the only automobile
manufacturer to offer CFC-free retrofit kits for the air conditioning sy\
stem of all models as far back as the 1975 model 240. Advanced
electronic engine controls and cleaner fuels are bringing us closer to o\
ur goal. After Volvo vehicles and parts have fulfilled their use,
recycling is the next critical step in completing the life cycle. The me\
tal content is about 75% of the total weight of a vehicle, which makes
the vehicle among the most recycled industrial products. In order to hav\
e efficient and well controlled recycling, all Volvo variants have
printed dismantling manuals, indicating the weight and material of indiv\
idual components. For Volvo, all homogeneous plastic parts
weighing more than 3.4 oz. (100 grams) are marked with international s\
ymbols that indicate how the component is to be sorted for
recycling. In addition to continuous environmental refinement of convent\
ional gasoline-powered internal combustion engines, Volvo is
actively looking at advanced technology alternative-fuel vehicles.
When you drive a Volvo, you become our partner in the work to lessen the\
car's impact on the environment. To reduce your vehicle's
environmental impact, you can:
l Maintain proper air pressure in your tires. Tests have shown decreased f\
uel economy with improperly inflated tires.
l Follow the recommended maintenance schedule in your Warranty and Service\
Records Information booklet.
l Drive at a constant speed whenever possible.
l See a trained and qualified Volvo service technician as soon as possible\
for inspection if the check engine (malfunction indicator) light
illuminates, or stays on after the vehicle has started.
l Properly dispose of any vehicle-related waste such as used motor oil, us\
ed batteries, brake pads, etc.
l When cleaning your vehicle, please use genuine Volvo car care products. \
All Volvo car care products are formulated to be
environmentally friendly.
For additional information regarding the environmental activities in whi\
ch Volvo Cars of North America, LLC and Volvo Car Corporation
file:///K|/delme/2007_C70/07c70_00.htm (5 of 7)12/22/2006 9:15:34 PM
2007 Volvo C70
WARNING
If your vehicle has been subjected to flood conditions (e.g. soaked car\
peting/standing water on the floor
of the vehicle) or if your vehicle has become flood-damaged in any way,\
do not attempt to start the
vehicle or put the key in the ignition before disconnecting the battery \
(see below). This may cause
airbag deployment which could result in personal injury. Have the vehicl\
e towed to a trained and
qualified Volvo service technician for repairs.
l Automatic transmission:
l Before attempting to tow the vehicle, use the following procedure to ove\
rride the shiftlock system to
move the gear selector to the neutral position:
- Switch off the ignition for at least 10 minutes and disconnect the bat\
tery
- Wait at least one minute.
- Insert the key in the ignition and turn it to position II.
- Press firmly on the brake pedal.
- Move the gear selector from Park (P) to the Neutral (N) position. See
page 135 for information on
manually overriding the shiftlock system.
18 01 Safety
Front airbags
The front airbag system
The front airbags supplement the three-point seat belts. For these airba\
gs to provide the protection
intended, seat belts must be worn at all times.
The front airbag system includes gas generators and the airbags. A decel\
eration sensor activates the gas
file:///K|/delme/2007_C70/07c70_01.htm (10 of 41)12/22/2006 9:15:37 PM\
2007 Volvo C70
Volvo recommends that ALL occupants (adults and children) shorter than\
4 feet 7 inches (140 cm) be
seated in the rear seat of any vehicle with a passenger's side front air\
bag, and be properly restrained.
Children should always be seated in child restraints appropriate for the\
ir size and weight. See also the
child safety recommendations beginning on
page 30.
The Occupant Weight Sensor (OWS) is designed to meet the regulatory re\
quirements of Federal Motor
Vehicle Safety Standard (FMVSS) 208 and is designed to disable (will \
not inflate) the passenger's side
front airbag under certain conditions.
The OWS works with sensors that are part of the front passenger's seat a\
nd seat belt. The sensors are
designed to detect the presence of a properly seated occupant and determ\
ine if the passenger's side front
airbag should be enabled (may inflate) or disabled (will not inflate)\
.
The OWS will disable (will not inflate) the passenger's side front air\
bag when:
l the front passenger's seat is unoccupied, or has small/medium objects in\
the front seat,
l the system determines that an infant is present in a rear-facing infant \
seat that is installed according to
the manufacturer's instructions,
l the system determines that a small child is present in a forward-facing \
child restraint that is installed
according to the manufacturer's instructions,
l the system determines that a small child is present in a booster seat,
l a front passenger takes his/her weight off of the seat for a period of t\
ime,
l a child or a small person occupies the front passenger's seat.
The OWS uses a PASSENGER AIRBAG OFF indicator lamp which will illuminate\
and stay on to
remind you that the passenger's side front airbag is disabled. The PASSE\
NGER AIRBAG OFF indicator
lamp is located in the overhead console, near the base of the rearview m\
irror.
NOTE
The PASSENGER AIRBAG OFF indicator lamp will illuminate for a short peri\
od of time when the
ignition is turned on to confirm it is functional. When the front passen\
ger's seat is not occupied (empty
seat) or in the event that the passenger's side front airbag is enabled\
(may inflate), the PASSENGER
AIRBAG OFF indicator lamp will be off.
However, if a fault is detected in the system:
l The OWS indicator light will stay on
l The SRS warning light (see page 17) will come on and stay on
The message PASS. AIRBAG OFF SERVICE URGENT will be displayed in the inf\
ormation display.
file:///K|/delme/2007_C70/07c70_01.htm (16 of 41)12/22/2006 9:15:37 PM\
2007 Volvo C70
1Volvo recommends that children always be properly restrained in appropri\
ate child restraints in the rear seats. In
rare situations when the seat belt is not properly fastened, some child \
restraints may not be detected by the OWS
because there is very little weight on the vehicle seat cushion. In thes\
e cases the passenger's side front airbag may
be disabled, but the PASSENGER AIRBAG OFF indicator lamp will not be lit\
. Do not assume that the passenger's
side front airbag is disabled unless the PASSENGER AIRBAG OFF indicator \
lamp is lit. Make sure the child
restraint is properly installed (turn the vehicle off, remove the child\
restraint from the vehicle and reinstall the
restraint following the child restraint manufacturer's instructions) an\
d that the PASSENGER AIRBAG OFF
indicator lamp is on, or move the child restraint to the rear seat.
The OWS is designed to enable (may inflate) the passenger's side front\
airbag anytime the system senses
that a person of adult size is sitting properly in the front passenger's\
seat. The PASSENGER AIRBAG
OFF indicator lamp will be off and remain off.
If a person of adult size is sitting in the front passenger's seat, but \
the PASSENGER AIRBAG OFF
indicator lamp is on, it is possible that the person isn't sitting prope\
rly in the seat. If this happens:
l Turn the vehicle off and ask the person to place the seatback in an upri\
ght position.
l Have the person sit upright in the seat, centered on the seat cushion, w\
ith the person's legs comfortably
extended.
l Restart the vehicle and have the person remain in this position for abou\
t two minutes. This will allow
the system to detect that person and enable the passenger's frontal airb\
ag.
l If the PASSENGER AIRBAG OFF indicator lamp remains on even after this, t\
he person should be
advised to ride in the rear seat.
This condition reflects limitations of the OWS classification capability\
. It does not indicate OWS
malfunction.
23 01 Safety
Occupant Weight Sensor
Modifications
If you are considering modifying your vehicle in any way to accommodate \
a disability, for example by
altering or adapting the driver's or front passenger's seat(s) and/or \
airbag systems, please contact Volvo at:
In the USA
Volvo Cars of North America, LLC
Customer Care Center
P.O. Box 914 Rockleigh, New Jersey 07647-0914
1-800-458-1552
In Canada
Volvo Cars of Canada Corp.
file:///K|/delme/2007_C70/07c70_01.htm (18 of 41)12/22/2006 9:15:37 PM\
2007 Volvo C70
2 0 0 7
VOLVO C70
78 03 Climate
General information
80
Air vents
81
Electronic Climate Control (ECC)
82
Air distribution
85
79 03 Climate
80 03 Climate
General information
Air conditioning - A/C
Your car is equipped with an Electronic Climate Control (ECC).
The air conditioning system can be switched off, but for optimal air qua\
lity in the passenger compartment
and to prevent the windows from fogging, the air conditioning should be \
left on - even in cool weather.
NOTE
file:///K|/delme/2007_C70/07c70_03.htm (1 of 10)12/22/2006 9:15:43 PM
2007 Volvo C70
In warm weather, a small amount of water may accumulate under the car wh\
en it has been parked. This
water is condensation from the A/C system and is normal.
Ice and snow
Always keep the air intake grille at the base of the windshield free of \
snow.
Climate control maintenance
Special tools and equipment are required to maintain and carry out repai\
rs on the climate system. Work of
this type should only be done by a trained and qualified Volvo service t\
echnician.
Refrigerant
Volvo cares about the environment. The air conditioning system in your c\
ar contains a CFC-free
refrigerant - R134a. This substance will not deplete the ozone layer. Th\
e system contains 1.2 lbs (530 g)
R134a (HFC 134a), and uses PAG oil.
Passenger compartment filter
Replace the cabin air filter with a new one at the recommended intervals\
. Please refer to your Warranty
and Service Records Information booklet, or consult your Volvo retailer \
for these intervals. The filter
should be replaced more often when driving under dirty and dusty conditi\
ons. The filter cannot be cleaned
and therefore should always be replaced with a new one.
NOTE
There are different types of cabin air filters. Ensure that the correct \
type is
installed.
Display
The display above the climate control panel shows the climate settings t\
hat have been made.
Personal settings
There are two functions in the climate system that can be set to your pr\
eferences:
l Blower speed to Auto mode (models with ECC only).
l Timer controlled recirculation of the air in the passenger compartment.
file:///K|/delme/2007_C70/07c70_03.htm (2 of 10)12/22/2006 9:15:43 PM
2007 Volvo C70
1. Auto - On/Off
2. Blower speed
3. Recirculation
4. Defroster
5. Airflow controls
6. A/C - ON/OFF
7. Heated driver's seat
8. Heated front passenger's seat
9. Rear window and door mirror defrosters
10.Temperature selector
NOTE
l The sunlight sensor on the upper side of the dashboard and the passenger\
compartment temperature
sensor, located behind the climate system control panel, should not be o\
bstructed.
l The air conditioning system is temporarily switched off during full thro\
ttle acceleration.
ECC functions
1. Auto - On/Off
file:///K|/delme/2007_C70/07c70_03.htm (4 of 10)12/22/2006 9:15:43 PM
2007 Volvo C70
The AUTO function automatically regulates climate control to maintain th\
e desired
temperature. The automatic function controls heating, air conditioning, \
blower speed, recirculation, and
air distribution.
If you select one or more manual functions, the remaining functions cont\
inue to be controlled
automatically. All manual settings are
83 03 Climate
Electronic Climate Control (ECC)
switched off when AUTO is switched on. AUTO CLIMATE is shown in the disp\
lay.
2. Blower speed
The blower speed can be increased or decreased by turning the knob. The\
blower speed
is regulated automatically if AUTO is selected. The previously set blowe\
r speed is disconnected.
NOTE
If the knob is turned counterclockwise and the blower indication in the \
display goes out, the blower and
the air conditioning are switched off. The display shows the blower symb\
ol and OFF.
3. Recirculation
This function can be used to shut out exhaust fumes, smoke, etc from the\
passenger
compartment. The air in the passenger compartment is then recirculated, \
i.e. no air from outside the car is
taken into the car when this function is activated. If the air in the ca\
r recirculates for too long, there is a
file:///K|/delme/2007_C70/07c70_03.htm (5 of 10)12/22/2006 9:15:43 PM