2007 Seat Cordoba battery

Checking and refilling levels
186•
If the vehicle is left standing in cold conditions for a long period, protect
the battery from frost. If it “freezes” it will be damaged.
Checking the electrolyte level
The electrolyte level should be checked regularly in high-
mileage vehicles, in hot countries and in older batteries.– Open the bonnet and open the battery cover at the front ⇒ in
“Safety instructions on working in the engine compartment” on
page 172 ⇒ in “Warnings on handling the battery” on
page 185.
– Check the colour display in the "magic eye" on the top of the battery.
– If there are air bubbles in the window, tap the window gently until they disperse.The position of the battery is shown in the corresponding engine compart-
ment diagram ⇒page 230.
The round window (“magic eye”) on the top of the battery changes colour,
depending on the charge level and electrolyte level of the battery.
If the colour in the window is colourless or bright yellow, the electrolyte level
of the battery is too low. Have the battery checked by a qualified workshop.
The colours green and black are used by the workshops for diagnostic
purposes.
Charging and changing the vehicle battery
The battery is maintenance-free and is checked during the
inspection service. All work on the vehicle battery requires
specialist knowledge.If you often drive short distances or if the vehicle is not driven for long
periods, the battery should be checked by a qualified workshop between the
scheduled services.
If the battery has discharged and you have problems starting the vehicle, the
battery might be damaged. If this happens, we recommend you have the
vehicle battery checked by an Authorised Service Centre where it will be re-
charged or replaced.
Charging the battery
The vehicle battery should be charged by a qualified workshop only, as
batteries using special technology have been installed and they must be
charged in a controlled environment.
Replacing a vehicle battery
The battery has been developed to suit the conditions of its location and has
special safety features.
Genuine SEAT batteries fulfil the maintenance, performance and safety spec-
ifications of your vehicle.
WARNING
•
We recommend you use only maintenance-free or cycle free leak-proof
batteries that comply with the standards T 825 06 and VW 7 50 73. This
standard applies as of 2001.
•
Before starting any work on the batteries, you must read and observe
the warnings ⇒ in “Warnings on handling the battery” on page 185.
cordoba_ingles_0706 Seite 186 Montag, 28. August 2006 1:18 13

If and when207
Safety First
Operating instructions
Tips and Maintenance
Te c h n i c a l D a t a
Fuses in engine compartment above battery
Metal fuses
7)
Non-metal fuses
Fig. 139 Fuse box above
battery
7)These fuses may only be changed at an authorised Service Centre
Number Electrical equipment Amperes
1 Alternator/Starter motor 175
2 Power supply voltage distributor inside vehicle 110
3 Power assisted steering pump 50
4 Spark plug preheating (diesel) 50
5 Electric heater fan/ air conditioning fan 40
6 A BS u nit 40
Number Electrical equipment Amperes
7A BS u nit 25
8 Electric heater fan/ air conditioning fan 30
9A BS u nit 10
cordoba_ingles_0706 Seite 207 Montag, 28. August 2006 1:18 13

If and when
218
– Replace the bulb.
– Insert the light on the connector side, first underneath then push at the top until it clicks into place.Luggage compartment lighting*The luggage compartment lighting is located in the upper section,
on the back of the stowage tray.
– Insert screwdriver in the opening on the left-hand side ⇒fig. 157.
– Replace the bulb.
– Refit the light on the connector side, next press upwards, until it clicks into place.
Jump-startingJump leads
The jump lead must have a sufficient wire cross section.If the engine fails to start because of a discharged battery, the battery can be
connected to the battery of anot her vehicle to start the engine.
Jump leads
Jump leads must comply with the standard DIN 72553 (see manufacturer’s
documentation). The wire cross section must be at least 25 mm
2 for petrol
engines and at least 35 mm
2 for diesel engines.
Note
•
The vehicles must not touch each other, otherwise electricity could flow as
soon as the positive terminals are connected.
•
The discharged battery must be properly connected to the vehicles elec-
trical system.
Fig. 157 Luggage
compartment lighting
cordoba_ingles_0706 Seite 218 Montag, 28. August 2006 1:18 13

If and when219
Safety First
Operating instructions
Tips and Maintenance
Te c h n i c a l D a t a
Jump-starting: descriptionIn ⇒ fig. 158, the flat battery is and the charged battery .
Jump lead terminal connections
– Switch off the ignition on both vehicles ⇒.
1. Connect one end of the red jump lead to the positive ⇒fig. 158
terminal of the vehicle with the flat battery ⇒.
2. Connect the other end of the red jump lead to the positive terminal in the vehicle providing assistance.
3. Connect one end of the black jump lead to the negative terminal on the battery of the vehicle providing assistance. 4. Connect the other end of the black jump lead to a solid metal
component which is bolted on to the engine block, or onto the
engine block itself of the vehicle with the flat battery. Do not
connect it to a point near the battery ⇒.
5. Position the leads in such a way that they cannot come into contact with any moving parts in the engine compartment.
Starting
6. Start the engine of the vehicle with the boosting battery and let
it run at idling speed.
7. Start the engine of the car with the flat battery and wait one or two minutes until the engine is “running”.
Removing the jump leads
8. Before you remove the jump leads, switch off the headlights (if they are switched on).
9. Turn on the heater blower and rear window heater in the vehicle with the flat battery. This helps minimise voltage peaks that are
generated when the leads are disconnected.
10. When the engine is running, disconnect the leads in reverse order to the details given above.
Connect the battery clamps so they ha ve good metal-to-metal contact with
the battery terminals.
If the engine fails to start, switch off the starter after about 10 seconds and
try again after about half a minute.
Fig. 158 How to connect
the jump leads
AA
AB
A+
A+
A-
AX
cordoba_ingles_0706 Seite 219 Montag, 28. August 2006 1:18 13

If and when
220
WARNING
•
Please note the safety warnings referring to working in the engine
compartment ⇒page 172, “Working in the engine compartment”.
•
The battery providing assistance must have the same voltage as the flat
battery (12V) and approximately the same capacity (see imprint on
battery). Failure to comply could result in an explosion.
•
Never use jump leads when one of the batteries is frozen. Danger of
explosion! Even after the battery has thawed, battery acid could leak and
cause chemical burns. If a battery freezes, it should be replaced.
•
Keep sparks, flames and lighted cigarettes away from batteries, danger
of explosion. Failure to comply could result in an explosion.
•
Observe the instructions provided by the manufacturer of the jump
leads.
•
Do not connect the negative cable from the other vehicle directly to the
negative terminal of the flat battery. The gas emitted from the battery could
be ignited by sparks. Danger of explosion.
•
Do not attach the negative cable from the other vehicle to parts of the
fuel system or to the brake line.
•
The non-insulated parts of the battery clamps must not be allowed to
touch. The jump lead atta ched to the positive battery terminal must not
touch metal parts of the vehicle, this can cause a short circuit.
•
Position the leads in such a way that they cannot come into contact
with any moving parts in the engine compartment.
•
Do not bend over the batteries. This could result in chemical burns.Note
The vehicles must not touch each other, otherwise electricity could flow as
soon as the positive terminals are connected.
cordoba_ingles_0706 Seite 220 Montag, 28. August 2006 1:18 13

Technical Data
230Te c h n i c a l D a t aChecking fluid levelsFrom time to time, the levels of the different fluids in the
vehicle must be checked. Never fi ll with incorrect fluids, to do
so may cause serious damage to the engine.
Radiator expansion tank
Engine oil dipstick.
Engine oil filler cap
Brake fluid reservoir
Battery
Windscreen washer fluid container
The checking and replenishment of the service fluids are carried out on the
components mentioned above. These operations are described in the
⇒ page 172. Overview
Further explanations, instructions and restrictions on the technical data are
contained as of
⇒page 225.
Note
The layout of parts may vary according to engine.
Fig. 161 Diagram for the
location of the various
elements
A1A2A3A4A5A6
cordoba_ingles_0706 Seite 230 Montag, 28. August 2006 1:18 13

Index245
Index
AABS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 142
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 62
Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . 165
Acoustic signal . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Acoustic warning . . . . . . . . . . . . . . . . . . . . . . . . 127
Adjustable service interval display . . . . . . . . . . 56
Adjusting simp le headlights
driving on the left . . . . . . . . . . . . . . . . . . . . 148
driving on the right . . . . . . . . . . . . . . . . . . . 148
Air conditioning system Climatronic . . . . . . . . . . . . . . . . . . . . . . . . . . 120
General notes . . . . . . . . . . . . . . . . . . . . . . . . 123
Air conditioning* . . . . . . . . . . . . . . . . . . . . . . . . 117
Air outlets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 116
Air recirculation Semi-automatic air conditi oning . . . . . . . . 119
Air recirculation mode Climatronic . . . . . . . . . . . . . . . . . . . . . . . . . . 122
Airbag covers . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Airbag system . . . . . . . . . . . . . . . . . . . . . . . . . . . 26 Curtain airbags . . . . . . . . . . . . . . . . . . . . . . . 36
Front airbags . . . . . . . . . . . . . . . . . . . . . . . . . 29
Side airbags . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 27 Airbags
Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Alarm system Switching off . . . . . . . . . . . . . . . . . . . . . . . . . 79
Alterations to the vehicle . . . . . . . . . . . . . . . . . 165
Alternator Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 60
Ambient temperature display . . . . . . . . . . . . 53, 55
Anti-freeze . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 179
Anti-lock brake system . . . . . . . . . . . . . . . . . . . 142 Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 62
Anti-theft alarm system . . . . . . . . . . . . . . . . . . . . 78 Switching off . . . . . . . . . . . . . . . . . . . . . . . . . 79
Anti-theft wheel bolts . . . . . . . . . . . . . . . . . . . . 197
Apple iPod connector . . . . . . . . . . . . . . . . . . . . 111
Aquaplaning . . . . . . . . . . . . . . . . . . . . . . . . . . . 189
Atermic windscreen* . . . . . . . . . . . . . . . . . . . . . . 96
Automatic anti-dazzle interior mirror* Activating the anti-dazzle function . . . . . . . 97
Deactivating anti-dazzle function . . . . . . . . . 97
Automatic car washes . . . . . . . . . . . . . . . . . . . . 157
Automatic gearbox . . . . . . . . . . . . . . . . . . . . . . 132 Instructions for driving . . . . . . . . . . . . . . . . 134
Kick-down feature . . . . . . . . . . . . . . . . . . . . 134
Selector lever positions . . . . . . . . . . . . . . . . 133
Auxiliary audio connection: AUX-IN . . . . . . . . . 110
BBall coupling . . . . . . . . . . . . . . . . . . . . . . . . . . . 153
BAS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 141
Battery Changing . . . . . . . . . . . . . . . . . . . . . . . . . . . 186
Charging . . . . . . . . . . . . . . . . . . . . . . . . . . . . 186
Winter conditions . . . . . . . . . . . . . . . . . . . . 185
Belt tension device Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 27
Belt tension devices . . . . . . . . . . . . . . . . . . . . . . 25
Biodiesel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 171
Bonnet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 174
Brake assist system . . . . . . . . . . . . . . . . . . . . . 141
Brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 183 Changing . . . . . . . . . . . . . . . . . . . . . . . . . . . 184
Brake pads . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 145
Brake servo . . . . . . . . . . . . . . . . . . . . . . . 141, 145
Brake system . . . . . . . . . . . . . . . . . . . . . . . . . . . 183 Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . 63
Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 145
Braking distance . . . . . . . . . . . . . . . . . . . . . . . . 145
Bulb changes general notes . . . . . . . . . . . . . . . . . . . . . . . . 208
Buzzer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91, 127
cordoba_ingles_0706 Seite 245 Montag, 28. August 2006 1:18 13

Index
246CCar care
Exterior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 157
Car care products . . . . . . . . . . . . . . . . . . . . . . . 156
Car phone . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 166
Car washes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 157
Catalytic converter . . . . . . . . . . . . . . . . . . . . . . 146
Central locking . . . . . . . . . . . . . . . . . . . . . . . . . . 68 Automatic speed dependent locking and un-locking system* . . . . . . . . . . . . . . . . . . . . . 70
Emergency unlocking system . . . . . . . . . . . . 71
Locking system for invo luntary unlocking . . 70
Selective unlocking system* . . . . . . . . . . . . 70
Unlocking system* . . . . . . . . . . . . . . . . . . . . 70
Central locking button Central locking . . . . . . . . . . . . . . . . . . . . . . . 71
unlocking . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Cetane number . . . . . . . . . . . . . . . . . . . . . . . . . 171
Change lamps dipped headlight lamp . . . . . . . . . . . . . . . . 210
Changing gear See Manual gearbox . . . . . . . . . . . . . . . . . . 131
Changing lamps interior light and reading light . . . . . . . . . . 217
changing lamps rear lights on frame . . . . . . . . . . . . . . . . . . . 216
rearlights on tailgate . . . . . . . . . . . . . . . . . 215
Changing the lamps glove box light* . . . . . . . . . . . . . . . . . . . . . . 217
indicator lights . . . . . . . . . . . . . . . . . . . . . . 213 main beam lights . . . . . . . . . . . . . . . . . . . . 211
Main headlight lamps . . . . . . . . . . . . . . . . . 209
number plate light . . . . . . . . . . . . . . . . . . . 217
side beam lights . . . . . . . . . . . . . . . . . . . . . 212
Side indicator lights . . . .
. . . . . . . . . . . . . . 215
Changing windscreen wiper blades . . . . . . . . . 182
Chassis number . . . . . . . . . . . . . . . . . . . . . . . . 226
Checking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 186
Checking battery electrolyte level . . . . . . . . . . 186
Checking engine oil level . . . . . . . . . . . . . . . . . 176
Child safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41
Child seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42 Categorisation in groups . . . . . . . . . . . . . . . 42
Group 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Group 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
Group 3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
Groups 0 and 0+ . . . . . . . . . . . . . . . . . . . . . . 43
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . . . 41
Securing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
Child seats ISOFIX and Toptether system . . . . . . . . . . . . 46
on the front passenger seat . . . . . . . . . . . . . 27
Cigarette lighter . . . . . . . . . . . . . . . . . . . . . . . . 109
Cleaning alloy wheels . . . . . . . . . . . . . . . . . . . . 161
Cleaning and caring for your vehicle . . . . . . . . 156
Cleaning chrome . . . . . . . . . . . . . . . . . . . . . . . . 160
Cleaning cloth seat covers . . . . . . . . . . . . . . . . 163
Cleaning dash panel . . . . . . . . . . . . . . . . . . . . . 162
Cleaning engine compartment . . . . . . . . . . . . . 162
Cleaning fabric trim . . . . . . . . . . . . . . . . . . . . . . 163 Cleaning leather . . . . . . . . . . . . . . . . . . . . . . . . 163
Cleaning plastic parts . . . . . . . . . . . . . . . . . . . . 162
Cleaning seat belts . . . . . . . . . . . . . . . . . . . . . . 164
Cleaning steel wheels . . . . . . . . . . . . . . . . . . . . 160
Cleaning windows . . . . . . . . . . . . . . . . . . . . . . . 159
Cleaning wooden trim . . . . . . . . . . . . . . . . . . . . 163
Climatronic
automatic mode . . . . . . . . . . . . . . . . . . . . . 121
controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . 120
General notes . . . . . . . . . . . . . . . . . . . . . . . 123
manual mode . . . . . . . . . . . . . . . . . . . . . . . 122
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
Cockpit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
Control Light switches . . . . . . . . . . . . . . . . . . . . . . . . 87
wing mirrors . . . . . . . . . . . . . . . . . . . . . . . . . 98
Control lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Control lighting . . . . . . . . . . . . . . . . . . . . . . . . . . 49
Controls electric windows . . . . . . . . . . . . . . . . . . . . . . 82
Convenience closing Sliding/tilting roof . . . . . . . . . . . . . . . . . . . . 86
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Convenience opening Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . 179, 180
Coolant Level . . . . . . . . . . . . . . . . . . . . . . . . . . . 180
Coolant level warning light . . . . . . . . . . . . . . . . . . . . . . . . . 61
Coolant Loss . . . . . . . . . . . . . . . . . . . . . . . . . . . 180
cordoba_ingles_0706 Seite 246 Montag, 28. August 2006 1:18 13