2007 SATURN RELAY climate control

Uniform Tire Quality Grading
Quality grades can be found where applicable on
the tire sidewall between tread shoulder and
maximum section width. For example:
Treadwear 200 Traction AA Temperature A
The following information relates to the system
developed by the United States National Highway
Traffic Safety Administration (NHTSA), which
grades tires by treadwear, traction, and
temperature performance. This applies only to
vehicles sold in the United States. The grades are
molded on the sidewalls of most passenger car
tires. The Uniform Tire Quality Grading (UTQG)
system does not apply to deep tread, winter-type
snow tires, space-saver, or temporary use
spare tires, tires with nominal rim diameters of
10 to 12 inches (25 to 30 cm), or to some
limited-production tires.
While the tires available on General Motors
passenger cars and light trucks may vary with
respect to these grades, they must also conform
to federal safety requirements and additional
General Motors Tire Performance Criteria (TPC)
standards.
Treadwear
The treadwear grade is a comparative rating
based on the wear rate of the tire when tested
under controlled conditions on a specied
government test course. For example, a tire
graded 150 would wear one and a half (1.5) times
as well on the government course as a tire
graded 100. The relative performance of tires
depends upon the actual conditions of their use,
however, and may depart signicantly from
the norm due to variations in driving habits, service
practices, and differences in road characteristics
and climate.
Traction – AA, A, B, C
The traction grades, from highest to lowest, are AA,
A, B, and C. Those grades represent the tire’s
ability to stop on wet pavement as measured under
controlled conditions on specied government test
surfaces of asphalt and concrete. A tire marked C
may have poor traction performance.
Warning:The traction grade assigned to this
tire is based on straight-ahead braking traction
tests, and does not include acceleration, cornering,
hydroplaning, or peak traction characteristics.
477
ProCarManuals.com

Fuses Usage
BLANK Not Used
4 Left High-Beam
BLANK Not Used
BLANK Not Used
BLANK Not Used
5 Not Used
6 Air Conditioning Clutch
7 Horn
8 Left Low-Beam
9Powertrain Control Module,
Electronic Throttle Control
10 Not Used
11 Transmission Solenoid
12 Right Low-Beam
13 Anti-lock Brake System
14 Powertrain Control Module IgnitionFuses Usage
15 Electronic Ignition
16 Fuel Injector
17Climate Control, RPA,
Cruise Control
18 Electronic Throttle Control
19 Engine Sensor, Evaporator
20 Airbag
21 Not Used
22 Not Used
23 Auxiliary Power
24 Front Windshield Washer
25 AC/DC Inverter
26 Rear Blower
27 Front Blower
28 Front Windshield Wiper
516
ProCarManuals.com

Capacities and Specications
The following approximate capacities are given in English and metric measurements. SeeRecommended
Fluids and Lubricants on page 530for more information.
Capacities and Specications
ApplicationCapacities
English Metric
Air Conditioning Refrigerant R134aFor the air conditioning system refrigerant charge
amount, see the refrigerant caution label located under
the hood. See your dealer for more information.
Automatic Transaxle — Pan Removal and Replacement 7.4 qt 7.0 L
Cooling System
3.9L Engine Front Climate Controls Only 10.77 qt 10.2 L
3.9L Engine with Rear Climate Controls 12.11 qt 11.55 L
Engine Oil with Filter 4.0 qt 3.8 L
Fuel Capacity 25.1 gal 95.0 L
Wheel Nut Torque 100 ft lb
140Y
All capacities are approximate. When adding, be sure to ll to the approximate level, as recommended in this manual.
Recheck uid level after lling.
Engine Specications
Engine VIN Code Transaxle Spark Plug Gap
3.9L V6 1 Automatic 0.040 in (1.1 mm)
518
ProCarManuals.com

Climate Control System............................... 205
Air Filter, Passenger Compartment........... 217
Dual......................................................... 209
Outlet Adjustment..................................... 212
Rear...............................................212, 215
Collision Damage Repair............................. 548
Comfort Guides, Rear Safety Belt................. 52
Compact Spare Tire.................................... 500
Compass..................................................... 240
Content Theft-Deterrent............................... 133
Control of a Vehicle..................................... 362
Convenience Net......................................... 173
Coolant
Engine Temperature Gage........................ 228
Heater, Engine......................................... 141
Cooling System........................................... 438
Cruise Control............................................. 188
Cruise Control Light.................................... 233
Cupholder(s)................................................ 167
Customer Assistance Information
Customer Assistance for Text
Telephone (TTY) Users......................... 542
Customer Assistance Offices.................... 542
Customer Satisfaction Procedure.............. 538
GM Mobility Reimbursement Program...... 543
Reporting Safety Defects to Saturn.......... 552Customer Assistance Information (cont.)
Reporting Safety Defects to the
Canadian Government.......................... 552
Reporting Safety Defects to the
United States Government.................... 552
Roadside Assistance Program.................. 543
Service Publications Ordering
Information........................................... 553
D
Daytime Running Lamps/Automatic
Headlamp System.................................... 193
Defensive Driving........................................ 358
Delayed Lighting.......................................... 196
Delayed Locking.......................................... 116
DIC Compass.............................................. 240
Disc, MP3................................................... 287
Doing Your Own Service Work.................... 413
Dome Lamp................................................ 196
Door
Automatic Door Lock................................ 117
Delayed Locking...................................... 116
Dual Sliding Doors................................... 118
Locks....................................................... 114
558
ProCarManuals.com

Door (cont.)
Power Door Locks................................... 116
Power Sliding Door.................................. 121
Programmable Automatic Door Unlock..... 118
Driver
Position, Safety Belt................................... 38
Driver Information Center (DIC)................... 234
DIC Operation and Displays..................... 235
DIC Vehicle Personalization..................... 261
DIC Warnings and Messages................... 241
Driving
At Night................................................... 375
City.......................................................... 380
Defensive................................................. 358
Drunken................................................... 359
Freeway................................................... 381
Hill and Mountain Roads.......................... 384
In Rain and on Wet Roads...................... 376
Rocking Your Vehicle to Get it Out.......... 391
Winter...................................................... 386
Dual Climate Control System....................... 209
DVD
Rear Seat Entertainment System.....294, 309E
Electric Power Management........................ 198
Electrical System
Add-On Equipment................................... 511
Fuses and Circuit Breakers...................... 512
Headlamp Wiring..................................... 511
Instrument Panel Fuse Block................... 512
Power Windows and Other Power
Options................................................. 511
Underhood Fuse Block............................. 514
Windshield Wiper Fuses........................... 511
Engine
Air Cleaner/Filter...................................... 428
Battery..................................................... 449
Check and Service Engine Soon Light..... 229
Coolant.................................................... 432
Coolant Heater......................................... 141
Coolant Temperature Gage...................... 228
Drive Belt Routing.................................... 533
Engine Compartment Overview ................ 422
Exhaust................................................... 151
Oil ........................................................... 423
559
ProCarManuals.com

P
Paint, Damage............................................ 508
Park Aid...................................................... 200
Park (P)
Shifting Into............................................. 148
Shifting Out of......................................... 149
Parking
Assist....................................................... 200
Brake....................................................... 147
Over Things That Burn............................ 150
Passenger Airbag Status Indicator............... 224
Passenger Compartment Air Filter............... 217
Passenger Sensing System........................... 93
Passing....................................................... 372
PASS-Key
®III ............................................. 135
PASS-Key®III Operation............................. 136
Power
Accessory Outlet(s).................................. 203
Door Locks.............................................. 116
Electrical System..................................... 511
Outlet 115 Volt Alternating Current........... 204
Rear Quarter Windows............................. 132
Retained Accessory (RAP)....................... 139
Seat.......................................................... 10Power (cont.)
Sliding Door............................................. 121
Steering Fluid.......................................... 443
Windows.................................................. 131
Pretensioners, Safety Belt............................. 55
Programmable Automatic Door Unlock......... 118
Q
Questions and Answers About Safety Belts ... 37
R
Radiator Pressure Cap................................ 435
Radios........................................................ 270
Care of Your CD and DVD Player............ 355
Care of Your CDs and DVDs................... 355
Navigation/Radio System, see
Navigation Manual................................ 294
Radio with CD......................................... 272
Rear Seat Audio.............................325, 328
Setting the Time...................................... 272
Theft-Deterrent......................................... 352
Understanding Reception......................... 354
Rear Climate Control System.............212, 215
565
ProCarManuals.com