2007 Ram 2500 (Diesel) steering

WARNING!
Fluid level should be checked on a level surface and
with the engine off to prevent injury from moving
parts and to insure accurate fluid level reading. Do
not overfill. Use only manufacturers recommended
power steering fluid.
If necessary, add fluid to restore to the proper indicated
level. With a clean cloth, wipe any spilled fluid from all
surfaces. Refer to Fluids, Lubricants, and Genuine Parts
for correct fluid type.
Front Suspension Ball Joints
The ball joints originally supplied with the vehicle are
permanently lubricated at the factory and do not require
service. The ball joints and seals should be inspected
whenever the vehicle is serviced for other reasons.
Steering Linkage — Inspection
Whenever the vehicle is hoisted, all steering linkage
joints should be inspected for evidence of damage. If
seals are damaged, parts should be replaced to prevent
leakage or contamination of the grease.
440 MAINTAINING YOUR VEHICLE

Cavity Cartridge
FuseMini
FuseDescription
20 10 Amp
RedOccupant Restraints
Controller (ORC) 2
21 10 Amp
RedOccupant Restraints/
Pass Disable Switch
22 2 Amp
GrayIGN Switch Feed
23 10 Amp
RedHVAC
24 20 Amp
BlueAISIN Relay Feed — If
Equipped
25 10 Amp
RedPower Mirror/T-Case
Brake
26 20 Amp
YellowBrake Switch/Center
High Mount Stop
Lamp (CHMSL)/
Aftermarket CHMSLCavity Cartridge
FuseMini
FuseDescription
27 40 Amp
GreenPower Seats
28 10 Amp
RedPower Run/Start-
PCM/Steering Angle
Sensor
29 10 Amp
Red4X4 Switch/Pass Dr
Switch/EC Mirror
30 15 Amp
BluePower Run/Start-ABS/
RWAL/Smart Bar/
YAW Sensor/Uego
Sensor Controller
31 10 Amp
RedPCM (Gas)/TCM (Die-
sel 58RFE)
32 10 Amp
RedPower Ignition Run —
Adjustable Pedals LED
33 10 Amp
RedPower-IGN Run —
HVAC
470 MAINTAINING YOUR VEHICLE

Chassis
Component Fluids, Lubricants and Genuine Parts.
Automatic Transmission MoparATF+4, Automatic Transmission Fluid.
Transfer Case MoparATF+4, Automatic Transmission Fluid.
Manual Transmission Fluid G-56 MoparATF+4, Automatic Transmission Fluid.
Clutch Linkage Multipurpose Grease, NLGI Grade 2 E.P. or equivalent.
Front and Rear Axle Fluid 2500/3500
ModelsGL-5 SAE 75W-90 Synthetic or equivalent. 2500/3500 axlesdo not require
limited slip additive.
Brake Master Cylinder MoparDOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom-
mended brake fluids.
Power Steering Reservoir MoparATF+4, Automatic Transmission Fluid.
MAINTAINING YOUR VEHICLE 491
7

Shifting ..........................291,297
Special Additives...................... 458
Autostick............................. 201
AxleFluid ..........................454,491
Axle Lubrication (Axle Fluid)............... 454
BallJoints ............................. 440
Battery............................... 437
Blanket..........................285,438
Emergency Starting..................... 399
Keyless Transmitter Replacement (RKE)....... 24
Saving Feature (Protection)............... 130
Bearings.............................. 458
Belts,Drive ............................ 422
Belts, Seat.............................. 34
Body Mechanism Lubrication............... 441
B-Pillar Location........................ 330
Brake Fluid............................ 491
Brake System........................321,451Anti-Lock (ABS)....................... 322
Disc Brakes.......................... 451
Fluid Check.......................... 452
Hoses.............................. 453
Master Cylinder....................... 452
Parking............................. 320
Warning Light........................ 203
Bulb Replacement....................... 474
Bulbs,Light ............................ 473
Cab Top Clearance Lights.................. 482
Calibration, Compass..................147,158
Camper............................... 188
Capacities, Antifreeze (Engine Coolant)........ 487
Capacities, Fluid........................ 487
Caps, Filler
Oil (Engine).......................... 418
Power Steering........................ 439
Radiator (Coolant Pressure)............... 447
INDEX 535
10

Drain, Flush, and Refill.................. 446
Inspection........................... 448
Points to Remember.................... 449
Pressure Cap......................... 447
Radiator Cap......................... 447
Selection of Coolant (Antifreeze).........446,488
Temperature Gauge..................... 200
Cruise Control (Speed Control).............. 139
CupHolder ............................ 172
Customer Assistance..................... 524
Customer Programmable Features............ 153
Data Recorder, Event...................... 58
Daytime Running Lights................... 131
Dealer Service.......................... 411
Defroster, Rear Window................. 88,181
Defroster, Windshield................ 77,258,261
Delay (Intermittent) Wipers................. 135
Diesel Exhaust Brake..................... 290Diesel Fuel............................ 348
Diesel Fuel Requirements.................. 348
Differential, Limited-Slip.................. 317
Dipsticks .............................. 414
Power Steering........................ 439
Disc Brakes............................ 451
Disposal.............................. 421
Engine Oil........................... 421
Used Coolant (Antifreeze)................ 448
Door Locks............................. 25
Door Locks, Automatic.................... 153
Door Opener, Garage..................... 160
Draining Fuel/Water Separator Filter.......427,430
DriveBelts ............................ 422
Dual Rear Wheels.....................347,396
DVD Player (Video Entertainment System)...... 249
Electric Rear Window Defrost............. 88,181
Electrical Power Outlets................... 169
INDEX 537
10

Filters
Engine Oil.....................414,419,488
Flashers
Turn Signal.......................... 133
Flat Tire Stowage.....................388,398
Fluid, Brake........................... 491
Fluid Capacities......................... 487
Fluid Level Checks
Brake............................... 452
Manual Transmission................... 455
Power Steering........................ 439
Transfer Case......................... 455
Fluids, Lubricants and Genuine Parts.......... 488
Fog Lights.......................132,202,477
Fold Flat Load Floor..................... 183
Four Wheel Drive....................... 306
Four-Way Hazard Flasher.................. 386
Freeing A Stuck Vehicle................... 402
Front Axle (Differential)................441,454Fuel..............................348,352
Adding............................. 352
Diesel......................348,350,352,488
Gauge.............................. 206
Light ............................... 206
Requirements......................348,350
Specifications......................349,351
Tank Capacity........................ 487
Fuses................................ 468
Garage Door Opener (HomeLink) ........... 160
Gauges............................... 198
Coolant Temperature.................... 200
Fuel................................ 206
Oil Pressure.......................... 200
Speedometer......................... 199
Tachometer.......................... 199
Voltmeter.........................198,282
Gear Ranges......................291,297,304
INDEX 539
10

Fog ..........................132,202,477
Four-Wheel Drive Indicator............... 309
Hazard Warning Flasher................. 386
Headlights........................... 130
High Beam........................134,199
High Beam Indicator.................... 199
High Beam/Low Beam Select............. 134
Illuminated Entry....................... 19
Instrument Cluster..................... 198
Intensity Control....................... 129
Interior..........................129,142
Lights On Reminder.................... 132
Passing............................. 134
Reading............................. 150
Seat Belt Reminder..................... 199
Service...........................473,474
Side Marker.......................... 486
Transfer Case......................... 309
Transmission Warning................... 205Turn Signal..................133,199,474,478
Warning (Instrument Cluster Description)..... 198
Limited-Slip Differential................317,454
Loading Vehicle......................... 355
Tires ............................... 330
Locks................................. 25
Child Protection........................ 29
Door................................ 25
Keys................................ 12
Power Door........................... 26
Steering Wheel......................... 15
Lower Anchors and Tether for CHildren (LATCH) . 65
Lubrication, Body....................... 441
LugNuts ............................. 394
Lumbar Support........................ 118
Maintenance........................... 411
Maintenance Procedures................... 414
Maintenance Schedule..................494,511
542 INDEX

Filter .........................414,419,488
Identification Logo..................... 418
Materials Added to..................... 419
Pressure Gauge....................... 200
Recommendation...................416,418
Synthetic............................ 419
Viscosity..........................417,418
Oil Filter, Change........................ 419
Onboard Diagnostic System................ 410
Opener, Garage Door (HomeLink) ........... 160
Operating Precautions.................... 410
Out of Park Sense Alarm................296,302
Outside Rearview Mirrors.................. 86
Overdrive..........................293,300
Overdrive OFF Switch.................293,300
Overhead Console.................142,143,150
Overhead Travel Information Center.......... 143
Owner’s Manual (Operator Manual).......... 528Panic Alarm............................ 23
Parking Brake.......................... 320
Passenger Airbag On/Off Switch............. 52
Passing Light........................... 134
Pedals, Adjustable....................... 138
Perform Service Indicator, Reset............. 513
Personal Settings........................ 153
Phone, Cellular.......................... 89
Phone, Hands-Free (UConnect™)............. 89
Pickup Box............................ 186
Placard, Tire and Loading Information......... 330
Power
Distribution Center (Fuses)............... 468
Door Locks........................... 26
Mirrors .............................. 87
Outlet (Auxiliary Electrical Outlet).......... 169
Seats............................... 118
Sliding Rear Window................. 32,182
Steering..........................324,439
544 INDEX