2007 MERCEDES-BENZ ML320CDI Keyless go

513 Practical hints
Battery
Step 8 (Removing)
cBattery
Tilt the batteryc with the negative
terminal side upwards.

Take out the battery maintaining its
tilted position in the direction of the
arrow.Step 9 (Reinstalling)

Carry out step 8 in reverse order
(page 513).
Battery, shown removed for illustration9Battery ventilation hose
dVent plug

Carry out step 10 to reconnect the
battery (
page 513).

Follow steps 5 to 1 in reverse order to
completely reinstall the battery
(page 512) to (
page 509).
Step 10 (Reconnecting)

If the battery has been removed, first
carry out step 8 in reverse order
(page 513).

Open the driver’s door.

Make sure all electrical consumers are
turned off.

Make sure the SmartKey is removed
from the starter switch.
Vehicles with KEYLESS-GO*:
Make sure the vehicle’s on-board
electronics have status0 (Open the
driver’s door. With the driver’s door
open, the vehicle’s on-board elec-
tronics have status0, same as with
the SmartKey removed from the
starter switch (
page 39)).
!
The battery, the battery ventilation hose9
and the lateral plugd (
page 513) must
always be securely installed when the vehicle is
in operation.


518 Practical hintsTowing the vehicleMercedes-Benz recommends that the
vehicle be transported with all wheels off
the ground using flatbed or appropriate
wheel lift/dolly equipment. This method is
preferable to other types of towing.When circumstances do not permit the
recommended towing methods, the
vehicle may be towed with all wheels on
the ground only so far as necessary to have
the vehicle moved to a safe location where
the recommended towing methods can be
employed.!
Use flatbed or wheel lift/dolly equipment,
with the SmartKey in starter switch turned to
position0.
Do not tow with sling-type equipment. Towing
with sling-type equipment over bumpy roads will
damage radiator and supports.
To prevent damage during transport, do not tie
down vehicle by its chassis or suspension parts.
Use the towing eyes.
Switch off the ESP
® (page 99) and the auto-
matic central locking (page 126).
!
Do not tow-start the vehicle.
!
Do not tow with one axle raised. Doing so
could damage the transfer case, which is not
covered by the Mercedes-Benz Limited
Warranty.
All wheels must be on or off the ground. Observe
instructions for towing the vehicle with all
wheels on the ground.
!
When towing the vehicle with all wheels on
the ground, the automatic transmission must be
in positionN and the starter switch must be in
position2 (
page 40).
When towing the vehicle with all wheels on the
ground, the vehicle may be towed only for
distances up to 30 miles (50 km) and at a speed
not to exceed 30 mph (50 km/h).
Keep in mind that it is important for the
SmartKey to be in the respective starter switch
positions as described above. As soon as the
SmartKey is removed from the starter switch or
the SmartKey with KEYLESS-GO* is removed
from the vehicle, the automatic transmission will
shift to park positionP see “Starter switch posi-
tions” (
page 39).

522 Practical hintsFusesThe electrical fuses in your vehicle serve to
switch off malfunctioning power circuits.
If a fuse is blown, the components and sys-
tems secured by that fuse will stop operat-
ing.If a newly inserted fuse blows again, have
the cause determined and rectified by an
authorized Mercedes-Benz Light Truck
Center.
The following aids are available to help you
replace fuses. They are included with the
vehicle tool kit (
page 469):


Fuse chart
The fuse chart explains the fuse alloca-
tion and fuse amperages.


Spare fuses


Fuse extractor
The electrical fuses are located in different
fuse boxes:


Fuse box in engine compartment
(page 523)


Fuse box in cargo compartment
(page 523)


Fuse box in passenger compartment
(page 524)Before replacing fuses:

Apply parking brake (
page 65).

Make sure the automatic transmission
is set toP (
page 187).
The gear position indicator in the multi-
function display should be on
P.

Turn off all electrical consumers.

Turn off the engine (
page 40).

Remove the SmartKey from the starter
switch.
Vehicles with KEYLESS-GO*:
Open the driver’s door (this puts
the starter switch in position0,
same as with the SmartKey re-
moved from the starter switch). The
driver’s door then can be closed
again.
Warning!
G
Only use fuses approved by Mercedes-Benz
with the specified amperage for the system
in question and do not attempt to repair or
bridge a blown fuse. Using other than ap-
proved fuses or using repaired or bridged
fuses may cause an overload leading to a
fire, and/or cause damage to electrical
components and/or systems. Have the
cause determined and remedied by an au-
thorized Mercedes-Benz Light Truck Center.i
A blown fuse must be replaced by an appro-
priate spare fuse (recognizable by its color or the
fuse rating given on the fuse) of the amperage
recommended in the fuse chart. Any
Mercedes-Light Truck Center will be glad to
advise you on this subject.

557 Index
Cup holders 298
Cleaning 299
Front center console 299
Front center console,
Removing/Installing 299
Rear armrest 299
Curb weight 395
Current transmission program
mode (AMG vehicles only) 147
D
Date display, Setting 169, 170
Daytime running lamp mode 138
Setting 171
Deep water see Standing water
Defogging windshield 213, 227
Defrosting, Front 213, 227
Defrosting, Rear 205
Delayed shut-off
Exterior lamps 172
Interior lighting 173
Department of Transportation see DOT
Diesel engine
Preglow indicator lamp 29Difficulties
While driving 63
While starting 57
Digital clock see Clock
Digital speedometer 147, 155
Dimensions, Vehicle 541
Direction of rotation (tires) 368
Displays
Digital speedometer 147, 155
Distronic* 253
Maintenance service indicator 401
Messages in the
multifunction display 428
Multifunction display 147
Outside temperature 147, 155
Selecting 168
Symbol messages 446
Text messages 430
Vehicle status message 163, 428
Vehicle system settings,
Control system 151, 153, 164
Distance to empty (range), Trip
Computer 180Distronic* 250
Activating 256
Cleaning system sensor 408
Control system 255
Deactivating 259
Distance warning function* 179, 263
Driving hints 261
Messages in the
multifunction display 432
Sensor cover 408
Warning and indicator lamps 253
Door
Entry lamps 144
Locking, In an emergency 476
Locking/unlocking,
KEYLESS-GO* 39, 68
Locking/unlocking, SmartKey 38, 68
Messages in the
multifunction display 455
Opening from inside/outside 109,
118
Remote door unlock (Tele Aid*) 315
Unlocking, Mechanical key 475

559 Index
Emergency operations
Remote door unlock, Tele Aid* 315
Unlocking/opening the tailgate 476
Emergency Tensioning Device see ETD
Emergency, In case of
Battery, Jump starting 515
Engine shut-down 525
First aid kit 469
Flat tire 497
Fuses 522
Hazard warning flasher 142
Instrument cluster, Indicator
lamps 414, 415, 416, 417, 418,
419, 420, 421, 422, 423, 424
Roadside Assistance 12, 312
Towing the vehicle 518
Emission control 350
Information label 531
System warranties 10
Vacuum line routing diagram
label 531Engine
Belt layout (ML 320 CDI) 532
Belt layout (ML 350) 532
Belt layout (ML 500) 532
Belt layout (ML 63 AMG) 533
Block heater (Canada only) 400
Break-in recommendations 358
Cleaning 406
Compartment 356
Emergency engine shut-down 525
Malfunction indicator lamp 29, 449
Maximum engine speed 146, 534,
535
Messages in the
multifunction display 449
Number 531
Starting 54
Starting with KEYLESS-GO* 55
Starting with the SmartKey 55
Tachometer 29, 146
Technical data 534
Turning off with KEYLESS-GO* 67
Turning off with the SmartKey 67Engine coolant see Coolant
Engine oil 358, 546
Adding 361, 546
Additives 546
Changing 361, 546
Checking level 358
Checking level with the
control system (ML 500 only) 358
Checking with the oil dipstick
(except ML 500) 360
Consumption 358
Filler neck (ML 350, ML 320 CDI) 361
Filler neck (ML 500, ML 63 AMG) 361
Messages in display 359, 453
Messages in the
multifunction display 453
Recommended engine oils
and oil filters 546
Engine oil level 358
ESP
®
27, 98
Four wheel electronic traction system
with ESP
®
98
Messages in the
multifunction display 436, 437
Off-road-ESP®
101
Warning lamp 27, 419, 420

563 Index
Interior lighting 142
Delayed shut-off 173
Interior rear view mirror 49
Antiglare positions 200
Auto-dimming mirrors* 201
Interior storage spaces see
Storage compartments
Intermittent wiping
Windshield wipers 61
J
Jack 471
Lifting the vehicle 498
Jump starting 515
K
Key, Mechanical 475
Key, SmartKey 108
Batteries 111, 480
Battery check lamp 108
Checking battery condition 111
Closing the power windows
(Convenience closing feature) 239
Closing the tilt/sliding sunroof*
(Convenience closing feature) 239
Closing, Power tailgate* 123
Factory setting 109Locking/unlocking 38, 68, 108
Locking/unlocking, Global
setting 109
Loss of 111
Messages in the
multifunction display 457
Opening the power windows
(Summer opening feature) 239
Opening the tilt/sliding sunroof*
(Summer opening feature) 239
Remote control 108
Replacing batteries 480
Selective setting 110
Starter switch positions 40
Starting the engine 54
Turning off the engine 67
Unlocking and opening,
Power tailgate* 111
Key, SmartKey with KEYLESS-GO*
Batteries 116, 480
Battery check lamp 112
Checking battery condition 116
Closing the power windows
(Convenience closing feature) 239
Closing the tilt/sliding sunroof*
(Convenience closing feature) 239Closing, Power tailgate* 124
Closing/locking, Power
tailgate* 125
Factory setting 115
Important notes 113
Locking/unlocking 39, 68, 112
Locking/unlocking, Global
setting 115
Loss of 117
Messages in the
multifunction display 456, 457
Opening the power windows
(Summer opening feature) 239
Opening the tilt/sliding sunroof*
(Summer opening feature) 239
Remote control 112
Replacing batteries 480
Selective setting 115
Start/stop button 41
Starter switch positions 40, 41
Starting the engine 55
Turning off the engine 67
Unlocking and opening,
Power tailgate* 117

564 IndexKickdown 191
Kilopascal 395
L
Labels 530
Certification 530
Emission control information 531
Engine number 531
Paintwork code 530
Vacuum line routing diagram 531
Vehicle Identification Number
(VIN) 530
Lamp sensor see Light sensor
Lamps, exterior 483
Front 483
Light sensor, Messages in the
multifunction display 460
Messages in display 458
Messages in the multifunction
display 458, 460, 462
Rear 483
Switch 136Lamps, indicator and warning
ABS 27, 414
Adaptive Damping System
(ADS)* 269
Alarm system 104
Battery (SmartKey with
KEYLESS-GO*) 115
Battery (SmartKey) 110
Brakes 27, 415, 416
Center console 31, 426
CHECK ENGINE 29, 417, 418
Distance warning lamp* 254
Downhill Speed Regulation 265
Engine diagnostics 29, 417, 418
ESP
®
27, 419, 420
Fog lamps, Front/rear 136
Front passenger front air bag off 31,
75, 426, 427
Fuel reserve 29, 420
High beam headlamps 29
Instrument cluster 26, 28, 414, 415,
416, 417, 418, 419, 420, 421, 422,
423, 424
Off-road driving program 268
Parktronic* 276Preglow indicator, Diesel engine 29
Seat belt telltale 29, 79, 421
Seat belts 422
Seat heating* 131
Seat ventilation* 132
SRS 29, 70, 80, 423
Turn signals 27
Vehicle level control* 271
Language, Setting 167
LATCH-type child seat anchors see
Children in the vehicle
Layout of poly-V-belt drive
(ML 320 CDI) 532
Layout of poly-V-belt drive (ML 350) 532
Layout of poly-V-belt drive (ML 500) 532
Layout of poly-V-belt drive
(ML 63 AMG) 533
Leather upholstery*, Cleaning and
care of 412
Lever for cruise control 245
License plate lamps 492
Messages in the
multifunction display 460
Replacing bulbs 483, 492
Light alloy wheels, Cleaning 410

565 Index
Light sensor
Messages in the
multifunction display 460
Lighter see Cigarette lighter*
Lighting, Exterior and interior 136
Limp-Home Mode 198, 417, 418
Loading see Vehicle loading
Locator lighting 139, 172
Lock buttons, KEYLESS-GO*
Outside door handle 68
Locking the vehicle see Key
Loss of keys, Mechanical key 111
Loss of keys, SmartKey 111
Loss of keys, SmartKey with
KEYLESS-GO* 117
Loss of Service and Warranty Information
Booklet 529
Low beam headlamps
Messages in the
multifunction display 460
Replacing bulbs 483
Switching on 59, 136
Lubricants 543
Lumbar support 130M
Main dimensions 541
Maintenance 12, 401
Calling up service indicator
display 403
Clearing service indicator
message 402
FSS PLUS (Canada vehicles) 402
Maintenance System
(U.S. vehicles) 401
Resetting service indicator 403
Service indicator message 401
Service term exceeded 402
Vehicle Maintenance System
(U.S. vehicles) 401
Manual headlamp mode see Headlamps
Manual shift progam
(ML 63 AMG only) 196
Manual shift program (ML 63 AMG)
Activating 196
Deactivating 198
Maximum cooling, MAX COOL* see
Automatic climate control
(3-zone)* 228Maximum load rating, Tires 396
Maximum loaded vehicle weight,
Tires 396
MB Tex upholstery, Cleaning and
care of 412
Mechanical key 475
Memory function* see Seats
Menus see Control system menus
Messages in display see
Multifunction display messages
Microphone, Hands-free 33
Minispare wheel see Spare wheel
Mirrors
Adjusting 49
Auto-dimming rear view
mirrors* 201
Exterior rear view mirror 49
Interior rear view mirror 49, 200