2007 MERCEDES-BENZ CLK63AMG wheel bolts

443 Practical hints
Flat tire
Jack up the vehicle until the wheel is a
maximum of 1.2 in (3 cm) from the
ground. Never start engine while
vehicle is raised.Removing the wheel
1Alignment bolt
Unscrew upper-most wheel bolt and
remove.
Replace this wheel bolt with alignment
bolt1 supplied in the tool kit.
Remove the remaining bolts.
Remove the wheel.
Warning!G
The jack is intended only for lifting the vehi-
cle briefly for wheel changes. It is not suited
for performing maintenance work under the
vehicle.

Never start the engine when the vehicle
is raised.

Never lie down under the raised vehicle.
!Do not place wheel bolts in sand or dirt. This
could result in damage to the bolt and wheel hub
threads.

444 Practical hints
Flat tire
Mounting the spare wheel
1Wheel bolt for light alloy rims
2Wheel bolt for Minispare wheel
(located in trunk with Minispare wheel)Clean contact surfaces of wheel and
wheel hub.
1Alignment bolt
Guide the spare wheel onto the align-
ment bolt and push it on.
Insert wheel bolts and tighten them
slightly.!Wheel bolts2 must be used when mount-
ing the Minispare wheel. The use of any wheel
bolts other than wheel bolts2 for the Minispare
wheel will physically damage the vehicle’s
brakes.
!To avoid paint damage, place wheel flat
against hub and hold it there while installing first
wheel bolt.
Warning!G
Always replace wheel bolts that are dam-
aged or rusted.
Never apply oil or grease to wheel bolts.
Damaged wheel hub threads should be re-
paired immediately. Do not continue to drive
under these circumstances! Contact an au-
thorized Mercedes-Benz Center or call
Roadside Assistance.
Incorrect wheel bolts or improperly tight-
ened wheel bolts can cause the wheel to
come off. This could cause an accident.
Make sure to use the correct wheel bolts.

445 Practical hints
Flat tire
Unscrew the alignment bolt, install last
wheel bolt and tighten slightly.Lowering the vehicle
Lower vehicle by turning crank coun-
terclockwise until the full weight of the
vehicle is resting on the ground.
Remove the jack.
1 - 5 Wheel bolts
Tighten the five wheel bolts evenly,
following the diagonal sequence
illustrated (1 to 5), until all bolts are
tight. Observe a tightening torque
of 80 lb-ft (110 Nm).Before storing the jack, it should be fully
collapsed, with handle folded in (storage
position) (
page 406).
Store the jack and the other vehicle
tools in the trunk.
Warning!G
Only use Genuine equipment
Mercedes-Benz wheel bolts. Other wheel
bolts may come loose.
Do not tighten the wheel bolts when the ve-
hicle is raised. Otherwise the vehicle could
fall off the jack.
Warning!G
Have the tightening torque checked after
changing a wheel. The wheels could come
loose if they are not tightened to a torque of
80 lb-ft (110 Nm).

482 Index
Automatic locking when driving 117
Automatic shift program 176
Automatic transmission
Accelerator position 174
Automatic shift program 176
Emergency operation
(limp-home mode) 183
Gear ranges 175
Gear selector lever 50, 170
Gear selector lever control
one-touch gearshifting 177
Gear selector lever positions 172
Gear shifting malfunctions 183
Kickdown 174
Kickdown, manual shift program 183
Manual shift program
CLK 63 AMG 181
Program mode selector switch 176
Shifting procedure 171
Starting engine 50
Steering wheel gearshift control
one-touch gearshifting* 179
Transmission fluid level 319
Automatic Transmission Fluid see ATFB
Backrest
Seat, Multicontour* 121
Seat, Power 40
Backup lamps
Messages in display 399
Replacing bulbs 427, 428
Bar 347
BAS 90
Batteries, SmartKey
Changing 426
Checking battery condition 107
Batteries, SmartKey with KEYLESS-GO*
Checking battery condition 107
Battery, Vehicle 321, 447
Charging 449
Connecting 449
Disconnecting 448
Installing 449
Jump starting 450
Messages in display 388
Removing 448
Bead 347
Beverage holder see Cup holder
Block heater (Canada only) 352
Bolts, Spare wheel 409Brake fluid 475
Checking 314
Messages in display 389
Brake lamp
Cleaning lenses 361
High mounted 428
Replacing bulbs 428
Brake pads
Messages in display 389
Brakes 302
High-performance brake system
(CLK 63 AMG only) 303
Warning lamp 368
Break-in period 300
Bulbs, replacing see Replacing bulbs

496 Index
Service, Parts 460
Settings
Control system menus 142
Control system submenus 143
Date 159, 160
Factory, KEYLESS-GO* 104
Factory, SmartKey 100
Global, KEYLESS-GO* 104
Global, SmartKey 100
Individual vehicle 153
Memory function 124
Menus and submenus 141
Resetting all, Control system 153
Selective, KEYLESS-GO* 105
Selective, SmartKey 100
Time 158
Shelf below rear window, Cleaning 363
Shift program mode,
Automatic transmission 176
Shifting
Gear selector lever 50
Shifting,
Automatic transmission 53, 170Side marker lamps
Cleaning lenses 361
Messages in display 399
Replacing bulbs 428
Side windows see Power windows
Sidewall 348
Ski sack* (Canada only) 271
Removing 274
Ski sack roller blind 271, 274
Unfolding and loading 271
Unloading and folding 273
SmartKey see Key, SmartKey 98
SmartKey with KEYLESS-GO* see
KEYLESS-GO*
Snow chains 352
Snow tires 351
Soft top 255
Cleaning 359
Emergency operations 415–423
Locking after raising/lowering 258
Luggage cover 260
Messages in display 402
Opening/closing 255
Opening/closing,
SmartKey 259Opening/closing,
Soft top switch 256, 257
Wind screen 261
Soft top switch 254, 256
Sound system* 211, 215
Spare fuses 404, 456
Spare parts service see Parts service
Spare wheel 407
Bolts 404, 409
Mounting 441
Sizes 469
Speedometer 27, 156
SRS 65, 77
Indicator lamp 27, 65, 375
Standard display, Selecting display 157
Standing lamps 126
Replacing bulbs 428, 431, 432
Standing water, Driving through 309
Starter switch 25, 36
Positions 36
Starting difficulties, Engine 52
Starting, Engine 50
Status line, Selecting display 157
Steering column 43
Steering gear oil
Message in display 402

498 Index
Telephone* 28, 167, 284
Answering/ending a call 168
Changing mobile phone cradle 286
Compartment 278
Hands-free microphone 31
Inserting in cradle 285
Installing a different
mobile phone cradle 286
Messages in display 403
Operation 167, 234
Phone book* 168
Redialing 169
Removing from cradle 286
TEL menu* 167
Temperature
Interior temperature 192, 202
Tightening torque, Wheel bolts 445
Time 158
Time, Setting 158
TIN 349
Tire and Loading Information
Placard 327
Terminology 347
Tire inflation pressure 438
Checking 331Tire inflation pressure see
the placard on the fuel filler flap
TIREFIT (CLK 63 AMG only) 404
TIREFIT*
Instructions for use 436
Tires 323, 466
Air pressure 347
Care and maintenance 324
Chains 352
Cleaning 325
Direction of rotation, Spinning 326
Driving instructions 305
Important notes,
Tire inflation pressure 332
Inflation pressure 314, 331, 333
Inflation pressure,
Information placard 331
Inspection 324
Load rating 349
MOExtended system* 446
MOExtended* 336, 466
Ply composition
and material used 349
Problems under-/overinflated 336
Retreads 323
Rims and tires 466Rotation 350
Run Flat Indicator 334
Service life 324
Sizes 467
Snow 351
Spare wheel 407, 441, 469
Speed rating 307, 339, 349
Storing 325
Temperature 346
Terminology 347
Tire Identification Number see TIN
TIREFIT (CLK 63 AMG only) 404
Traction 306, 349
Tread 349
Tread depth 325, 351
Treadwear indicators 349
Wear pattern 350
Winter 351
Tools 404
Top tether
Children in the vehicle 85
Towing eye bolt 454
CLK 550, CLK 63 AMG 455
Towing the vehicle 452
Tow-start 450, 452
Traction 92, 306, 349

500 Index
Vehicle loading
Instructions 275, 326
Load limit 326
Terminology 347
Vehicle maximum load on the tire 349
Vehicle recovery services,
Stolen (Tele Aid) 293
Vehicle status message memory 152
Vehicle status messages 378
Vehicle system settings,
Control system 139
Vehicle tool kit 404
Vehicle washing 358
VIN 462W
Warning indicators
Parktronic system*
(CLK 63 AMG (USA),
Canada all vehicles) 269
Warning sounds
Driver’s or passenger’s seat belt 78
Parking brake 53
Parktronic system*
(CLK 63 AMG (USA),
Canada all vehicles) 269, 270
Seat belt telltale 374
Warranty coverage 10, 461
Washer fluid see Windshield washer fluid
Washer reservoir level 473
Washing the vehicle 358
Wear pattern, Tires 350
Weights, Vehicle 471
Wheel
Bolts 409
Change 441
Collapsible wheel chock 407
Removing 443
Spare 407
Tightening torque 445TIREFIT (CLK 63 AMG only) 404
Wrench 442
Wheels, Sizes 467
Wheels, Tires and 323
Wind screen 261
Windows see Power windows
Windshield
Cleaning 56, 362
Defogging 194, 204
Windshield washer fluid 322, 479
Message in display 403
Mixing ratio 479
Refilling 322
Reservoir level 473
Wiping 56
Windshield washer system 473, 479
Windshield wipers 55
Cleaning wiper blades 362
Replacing wiper blades 434
Winter driving 351
Block heater (Canada only) 352
Snow chains 352
Tires 351
Winter driving instructions 308
Winter tires 351
Wood trims, cleaning 364