2007 Lancia Musa engine

298
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
1 Engine oil - 2 Battery -
3 Brake fluid - 4 Windscreen/
rear window - 5 Engine coolant
L0D0325m1.9 Multijet versions
L0D0207m1.3 Multijet versions
1 Engine oil - 2 Battery -
3 Brake fluid - 4 Windscreen/
rear window - 5 Engine coolant

ENGINE OIL
Checking engine oil
Check the oil level a few minutes (about 5) after the engine has
stopped, with the car parked on level ground.
Check that the level is within the MIN and MAX marks on the
dipstick. The interval between the MIN and MAX marks corresponds
to about one litre of oil.
Topping up engine oil
If the oil level is near or even below the MIN mark, add oil through
the filler neck, until reaching the MAX mark. Oil level shall never
exceed the MAX mark.
IMPORTANT If a routine check reveals that the oil level is above the
MAX mark, contact Lancia Dealership to have the correct level
restored.
IMPORTANT After adding or changing the oil, let the engine turn
over for a few seconds and wait a few minutes after turning it off
before you check the level.
299
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
L0D0208m
L0D0209mL0D0326m
1.416Vversions
1.3 Multijet versions 1.9 Multijet versions
L0D0258m1.48Vversions
(where provided)

Engine oil consumption
Max engine oil consumption is usually 400 grams
every 1000 km.
When the car is new, the engine needs to run in,
therefore the engine oil consumption can only be
considered stabilised after the first 5000 - 6000 km.IMPORTANT The oil consumption depends on
driving style and the conditions under which the car
is used.
IMPORTANT Do not add oil with specifications
other than that already in the engine.
300
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
Used engine oil and filter contain harmful substances for the environment.
Contact Lancia Dealership to have the oil and filter changed.
When the engine is hot, take care when working inside the engine compartment to
avoid burns. Remember that when the engine is hot, the fan may cut in: danger of
injury. Scarves, ties and other loose clothing might be pulled by moving parts.
WARNING

ENGINE COOLANT FLUID
The coolant level shall be checked with cold engine and shall be
included between the MIN and MAX mark on the reservoir.
If the level is low, pour slowly a mixture of 50% distilled water and
50% FL Selenia PARAFLU UP through the filler neck.
A 50-50 mixture of PARAFLU UP and distilled water gives freeze
protection to –35°C.
IMPORTANT Do not remove the reservoir cap when the engine is hot:
you risk scalding yourself.
301
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
L0D0210m
L0D0211m
1.48V(where provided)-
1.416Vversions
1.3 and 1.9 Multijet versions
DUAL FUNCTION SYSTEM GEARBOX HYDRAULIC
SYSTEM OIL
To have the oil level checked contact Lancia Dealership only.
WARNING
The cooling system uses PARAFLU UP antifreeze. Do not add fluid having
different specifications from that already existing. PARAFLU UP cannot be mixed
with other types of fluids. Should other fluids be added, do not start the engine
and contact Lancia Dealership as soon as possible.
The cooling system is pressurised. If necessary, replace the cap only with another
genuine one, otherwise system efficiency could be compromised.
WARNING

WINDSCREEN/REAR WINDOW/HEADLIGHT WASHER FLUID
To top up, remove the cap (A) and then pour a mixture of water and
TUTELA PROFESSIONAL SC 35, in the following concentrations:
❒30% TUTELA PROFESSIONAL SC 35 and 70% water in
summer;
❒50% TUTELA PROFESSIONAL SC 35 and 50% water in winter.
In case of temperatures below –20°C, use undiluted TUTELA
PROFESSIONAL SC 35.
Check level through the reservoir.
302
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
L0D0212m
WARNINGDo not travel with the windscreen washer reservoir empty: the windscreen washer
is fundamental for improving visibility.
WARNINGCertain commercial additives for windscreen washers are inflammable. The
engine compartment contains hot components which may set it on fire.

DIESEL FUEL FILTER
(“green filter”)
DRAINING THE CONDENSE (Multijet versions)
IMPORTANT The presence of water in the fuel
circuit may cause serious damage to the entire
injection system and cause irregular engine
operation. If the warning light
cturns on (or oncertain versions, a dedicated message is shown on
the multifunction display) contact a Lancia
Dealership as soon as possible to have the bleeding
operation carried out.
304
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
WARNING
The presence of water in the fuel circuit may cause serious damage to the entire
injection system and cause irregular engine operation. If the warning light
c
turns on (or on certain versions, a dedicated message is shown on the
reconfigurable multifunction display) contact a Lancia Dealership as soon as
possible to have the bleeding operation carried out. Should the above indications
take place after refuelling, water has probably been poured into the tank: turn the
engine off immediately and contact a Lancia Dealership.

USEFUL ADVICE FOR
LENGTHENING THE LIFE OF YOUR BATTERY
To avoid draining your battery and lengthen its life,
observe the following indications:
❒when you park the car, ensure the doors, tailgate
and bonnet are closed properly;
❒the ceiling lights must be off. The car is however
provided with an automatic system for switching
off internal lights;
❒do not keep accessories (e.g.: sound system,
hazard lights, etc.) switched on for a long time
when the engine is not running;
❒before performing any operation on the electrical
system, disconnect the battery negative cable;
❒battery terminals shall always be perfectly
tightened.IMPORTANT A battery which is kept at a charge of
less than 50% (optical indicator with dark colour
without green area in the middle) for any length of
time will be damaged by sulphation leading to a
reduction in cranking power. Moreover, this might
lead to a higher risk of the battery electrolyte
freezing (this may even occur at -10°C).
If the car is left inactive for a long period of time,
refer to “Car inactivity”, in section “Correct use of
the car”.
If after buying the car, you want to install electric
accessories which require permanent electric supply
(alarm, free-hands set, etc.) contact Lancia
Dealership whose qualified personnel, in addition to
suggesting the most suitable devices of the
Lineaccessori Lancia, will evaluate the overall
electric absorption, checking whether the car’s
electric system is capable of withstanding the load
required, or whether it should be integrated with a
more powerful battery.
307
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE

316
WARNING
LIGHTS AND
MESSAGES
TECHNICALSPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT
USE OF
THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
Windows
Use specific window cleaner products. Use also
clean cloths to avoid scratching the glass or
damaging the transparency.
IMPORTANT The inside of the rearscreen should be
wiped gently with a cloth in the direction of the
filaments to avoid damaging the heating device.
Front headlights
IMPORTANT Never use aromatic substances (e.g.:
petrol) or ketones (e.g.: acetone) for cleaning front
headlight plastic lens.Engine compartment
At the end of the winter the engine compartment
should be carefully washed, without directing the jet
against electronic control units. Contact a
specialised workshop to have this done.
IMPORTANT Washing should be carried out with
the engine cold and the ignition key at STOP. After
washing make sure that the various protections
(e.g.: rubber caps and various covers) have not been
damaged or removed.
Never use flammable products like oil ether or rectified petrol for cleaning car
interiors. Electrostatic discharges generated by rubbing during cleaning
operations could cause fire.
WARNING