2007 GMC SIERRA CLASSIC check transmission fluid

3. Check both sides of the dipstick, and read the
lower level. The uid level must be in the
COLD area, below the cross-hatched area, for
a cold check or in the HOT or cross-hatched
area for a hot check. Be sure to keep the
dipstick pointed down to get an accurate
reading.
4. If the uid level is in the acceptable range,
push the dipstick back in all the way; then
ip the handle down to lock the dipstick
in place.
How to Add Automatic Transmission
Fluid
Refer to the Maintenance Schedule to determine
what kind of transmission uid to use. See
Recommended Fluids and Lubricants on page 629.
Add uid only after checking the transmission uid
while it is hot. A cold check is used only as a
reference. If the uid level is low, add only enough
of the proper uid to bring the level up to the HOT
area for a hot check. It does not take much uid,
generally less than one pint (0.5 L). Do not overll.
Notice:Use of the incorrect automatic
transmission uid may damage your vehicle,
and the damages may not be covered by
your warranty. Always use the automatic
transmission uid listed inRecommended
Fluids and Lubricants on page 629.
After adding uid, recheck the uid level as
described under “How to Check Automatic
Transmission Fluid,” earlier in this section.
When the correct uid level is obtained, push
the dipstick back in all the way; then ip the
handle down to lock the dipstick in place.
499

Manual Transmission Fluid
When to Check Manual Transmission
Fluid
A good time to have your manual transmission
uid checked is when the engine oil is changed.
SeeAdditional Required Services (Gasoline
Engine) on page 621to nd out when to change
your transmission uid.
How to Check Manual Transmission
Fluid
Because this operation can be a little difficult, you
may choose to have this done at the dealership
service department.
If you do it yourself, be sure to follow all the
instructions here, or you could get a false reading.
Notice:Too much or too little uid can
damage your transmission. Too much can
mean that some of the uid could come out
and fall on hot engine parts or exhaust system
parts, starting a re. Too little uid could
cause the transmission to overheat. Be sure to
get an accurate reading if you check your
transmission uid.Check the uid level only when your engine is off,
the vehicle is parked on a level place, and the
transmission is cool enough for you to rest your
ngers on the transmission case.
Then, follow these steps:
1. Remove the ller plug.
2. Check that the lubricant level is up to the
bottom of the ller plug hole.
3. If the uid level is good, install the plug and be
sure it is fully seated. If the uid level is low,
add more uid as described in the next steps.
5-speed for VORTEC™ 4300 V6 and 4800 V8 engines
shown, other manual transmissions similar
500

How to Add Manual Transmission Fluid
Here is how to add uid. Refer to the Maintenance
Schedule to determine what kind of uid to
use. SeeRecommended Fluids and Lubricants on
page 629.
1. Remove the ller plug.
2. Add uid at the ller plug hole. Add only
enough uid to bring the uid level up to
the bottom of the ller plug hole.
3. Install the ller plug. Be sure the plug is fully
seated.
Hydraulic Clutch
The hydraulic clutch linkage in your vehicle is
self-adjusting. The clutch master cylinder reservoir
is lled with hydraulic clutch uid.
It is not necessary to regularly check clutch uid
unless you suspect there is a leak in the system.
Adding uid will not correct a leak.
A uid loss in this system could indicate a
problem. Have the system inspected and repaired.
When to Check and What to Use
The clutch master
cylinder reservoir is
located in the rear of the
engine compartment on
the driver’s side of the
vehicle. SeeEngine
Compartment Overview
on page 480for more
information on location.
Refer to the Maintenance Schedule to determine
how often you should check the uid level in
your clutch master cylinder reservoir and for the
proper uid. SeeOwner Checks and Services
on page 625andRecommended Fluids and
Lubricants on page 629.
501

ApplicationCapacities
English Metric
Transfer Case Fluid 2.0 qt 1.9 L
Wheel Nut Torque 140 ft lb
190Y
After rell, the level must be rechecked. Add enough engine coolant so that the uid is within the proper operating
range.
Engine Specications
Engine VIN Code Transmission Spark Plug Gap
VORTEC™ 4.3L V6 XAutomatic
Manual0.060 inches (1.52 mm)
VORTEC™ 4.8L V8 VAutomatic
Manual0.040 inches (1.01 mm)
VORTEC™ 5.3L V8 Flex Fuel Z Automatic 0.040 inches (1.01 mm)
VORTEC™ 5.3L V8 T Automatic 0.040 inches (1.01 mm)
VORTEC™ 5.3L V8 B Automatic 0.040 inches (1.01 mm)
VORTEC™ 6.0L V8 UAutomatic
Manual0.040 inches (1.01 mm)
VORTEC™ 6.0L V8 NAutomatic
Manual0.040 inches (1.01 mm)
VORTEC™ 8.1L V8 GAutomatic
Manual0.060 inches (1.52 mm)
611

(k)Inspect system. Check all fuel and vapor lines
and hoses for proper hook-up, routing, and
condition. Check that the purge valve, if the vehicle
has one, works properly.
(m)Change automatic transmission uid and
external transmission lter if the vehicle is mainly
driven under one or more of these conditions:
In heavy city traffic where the outside
temperature regularly reaches 90°F (32°C) or
higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
Uses such as found in taxi, police, or delivery
service.
(n)Vehicles with diesel engine or with GVWR
above 10,000 lbs (4 536 kg) only: Inspect shields
for damage or looseness. Adjust or replace as
required. This is a Noise Emission Control Service.
Applicable to vehicles sold in the United States
and recommended for vehicles sold in Canada.
(p)If you drive regularly under dusty conditions,
inspect the lter or change indicator (if equipped)
at each engine oil change.(q)Visually inspect belt for fraying, excessive
cracks, or obvious damage. Replace belt if
necessary.
Owner Checks and Services
These owner checks and services should be
performed at the intervals specied to help
ensure the safety, dependability, and emission
control performance of your vehicle. Your
GM Goodwrench
®dealer can assist you with
these checks and services.
Be sure any necessary repairs are completed at
once. Whenever any uids or lubricants are added
to your vehicle, make sure they are the proper
ones, as shown inRecommended Fluids and
Lubricants on page 629.
At the First 100, 1,000 and 6,000
Miles (160, 1 600 and 10 000 km)
Check dual wheel nut torque. For proper torque,
seeCapacities and Specications on page 609.
625

Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular
brake, set the parking brake.
To check the parking brake’s holding ability:
With the engine running and transmission in
NEUTRAL (N), slowly remove foot pressure
from the regular brake pedal. Do this until the
vehicle is held by the parking brake only.
To check the PARK (P) mechanism’s holding
ability: With the engine running, shift to
PARK (P). Then release the parking brake
followed by the regular brake.
Contact your GM Goodwrench
®dealer if service is
required.
Underbody Flushing Service
At least every spring, use plain water to ush any
corrosive materials from the underbody. Take
care to clean thoroughly any areas where mud and
other debris can collect.
Recommended Fluids and
Lubricants
This maintenance section applies to vehicles with
a gasoline engine. If your vehicle has a diesel
engine, see the maintenance schedule section in
the DURAMAX
®Diesel Engine Supplement.
Fluids and lubricants identied below by name,
part number, or specication may be obtained from
your dealer.
Usage Fluid/Lubricant
Engine OilEngine oil which meets
GM Standard GM6094M and
displays the American Petroleum
Institute Certied for Gasoline
Engines starburst symbol.
GM Goodwrench
®oil meets all the
requirements for your vehicle. To
determine the proper viscosity for
your vehicle’s engine, seeEngine
Oil (Gasoline Engine) on page 486.
Engine Coolant50/50 mixture of clean, drinkable
water and use only DEX-COOL
®
coolant. SeeEngine Coolant on
page 502.
629

Engine (cont.)
Check and Service Engine Soon Light..... 258
Coolant.................................................... 502
Coolant Heater......................................... 139
Coolant Temperature Gage...................... 256
Drive Belt Routing.................................... 633
Engine Compartment Overview................ 480
Exhaust................................................... 174
Fan Noise................................................ 514
Oil ........................................................... 486
Oil Life System........................................ 489
Overheated Protection Operating Mode.... 508
Overheating............................................. 505
Starting.................................................... 137
Entry Lighting.............................................. 227
Event Data Recorders (EDR)...................... 650
Exit Lighting................................................ 227
Extender, Safety Belt..................................... 43
F
Filter
Engine Air Cleaner................................... 491
Finish Damage............................................ 596
Fixed Mast Antenna.................................... 353
Flashers, Hazard Warning........................... 212Flash-to-Pass.............................................. 216
Flat Tire...................................................... 563
Flat Tire, Changing...................................... 564
Flat Tire, Storing......................................... 584
Fluid
Automatic Transmission...................494, 497
Manual Transmission................................ 500
Power Steering........................................ 515
Windshield Washer.................................. 516
Fog Lamps.................................................. 225
Four-Wheel Drive...............................153, 528
Four-Wheel-Drive Light................................ 263
Front Axle................................................... 529
Front Reading Lamps.................................. 227
Front Storage Area...................................... 202
Fuel............................................................ 470
Additives.................................................. 472
California Fuel.......................................... 471
E85 (85% Ethanol)................................... 473
Filling a Portable Fuel Container.............. 477
Filling Your Tank...................................... 474
Fuels in Foreign Countries....................... 474
Gage....................................................... 264
Gasoline Octane...................................... 470
Gasoline Specications............................ 471
Low Warning Light................................... 265
664

Light (cont.)
Passenger Airbag Status Indicator............ 250
Safety Belt Reminder............................... 247
Security................................................... 263
Tow/Haul Mode........................................ 264
Traction Off.............................................. 256
Up-Shift................................................... 254
Lighting
Entry........................................................ 227
Exit.......................................................... 227
Loading Your Vehicle................................... 409
Locking Rear Axle....................................... 366
Lockout Protection....................................... 126
Locks
Delayed Locking...................................... 122
Door........................................................ 120
Lockout Protection................................... 126
Power Door............................................. 121
Programmable Automatic Door Locks....... 123
Rear Door Security Locks........................ 126
Loss of Control........................................... 371
Low Fuel Warning Light............................... 265
Lumbar
Power Controls.......................................... 11M
Maintenance Schedule
Additional Required Services.................... 621
At Each Fuel Fill...................................... 626
At Least Once a Month............................ 626
At Least Once a Year .............................. 627
At the First 100, 1,000 and 6,000 Miles
(160, 1 600 and 10 000km).................. 625
Introduction.............................................. 614
Maintenance Footnotes............................ 623
Maintenance Record................................ 634
Maintenance Requirements...................... 614
Normal Maintenance Replacement
Parts.................................................... 632
Owner Checks and Services.................... 625
Recommended Fluids and Lubricants....... 629
Scheduled Maintenance........................... 617
Using....................................................... 615
Your Vehicle and the Environment............ 615
Malfunction Indicator Light........................... 258
Manual Seats.................................................. 9
Manual Selectable Ride............................... 365
Manual Transmission
Fluid........................................................ 500
Operation................................................. 149
667