2007 FORD FREESTAR power steering fluid

Vehicle Symbol Glossary
Power Windows
Front/Rear
Power Window Lockout
Child Safety Door
Lock/UnlockInterior Luggage
Compartment Release
Symbol
Panic AlarmEngine Oil
Engine CoolantEngine Coolant
Temperature
Do Not Open When HotBattery
Avoid Smoking, Flames,
or SparksBattery Acid
Explosive GasFan Warning
Power Steering FluidMaintain Correct Fluid
LevelMAX
MIN
Emission SystemEngine Air Filter
Passenger Compartment
Air FilterJack
Check Fuel CapLow Tire Pressure
Warning
2007 Freestar(win)
Owners Guide (post-2002-fmt)
USA(fus)
Introduction
9

•A slight deceleration of the vehicle
•The AdvanceTrac
indicator light will illuminate
•If your foot is on the brake pedal, you will feel a vibration in the
pedal.
•If the driving condition is severe and your foot is not on the brake, the
brake pedal will move to apply higher brake forces. You may also hear
a whoosh of air from under the instrument panel during this severe
condition.
All these conditions are normal during AdvanceTrac
operation.
If the AdvaceTrac system is activated for an extended period of time, the
brake portion of the system will shut down to allow the brakes to cool
down. A limited AdvanceTrac
function using only engine power
reduction will still help control the wheels from over-spinning. When the
brakes have cooled down, the system will again function normally.
Anti-lock braking is not affected by this condition and will function
normally during the cool-down period.
Do not alter or modify your vehicle’s suspension or steering; the
resulting changes to the vehicle’s handling can adversely affect
the AdvanceTrac
system. Also, do not install a stereo
loudspeaker near the front center console or under either front
seat. The speaker vibrations can adversely affect the
AdvanceTrac
sensors located in this area.
Aggressive driving in any road conditions can cause you to lose
control of your vehicle increasing the risk of severe personal
injury or property damage. The occurrence of an AdvanceTrac
event
is an indication that at least some of the tires have exceeded their
ability to grip the road; this may lead to an increased risk of loss of
vehicle control, vehicle rollover, personal injury and death. If you
experience a severe road event, SLOW DOWN.
STEERING
To help prevent damage to the power steering system:
•Never hold the steering wheel at its furthest turning points (until it
stops) for more than a few seconds when the engine is running.
•Do not operate the vehicle with a low power steering pump reservoir
fluid level (below the MIN mark on the reservoir).
•Some noise is normal during operation. If the noise is excessive, check
for low power steering pump fluid level before seeking service by your
authorized dealer.
2007 Freestar(win)
Owners Guide (post-2002-fmt)
USA(fus)
Driving
218

•Heavy or uneven steering efforts may be caused by low power steering
pump fluid level. Check for low power steering pump fluid level before
seeking service by your authorized dealer.
•Do not fill the power steering pump reservoir above the MAX mark on
the reservoir, as this may result in leaks from the reservoir.
If the power steering system breaks down (or if the engine is turned
off), you can steer the vehicle manually, but it takes more effort.
If the steering wanders or pulls, check for:
•an improperly inflated tire
•uneven tire wear
•loose or worn suspension components
•loose or worn steering components
•improper steering alignment
A high crown in the road or high crosswinds may also make the steering
seem to wander/pull.
AUTOMATIC TRANSAXLE OPERATION
Brake-shift interlock
This vehicle is equipped with a brake-shift interlock feature that prevents
the gearshift lever from being moved from P (Park) when the ignition is
in the 4 (ON) position unless the brake pedal is depressed.
If you cannot move the gearshift lever out of P (Park) with the ignition
in the 4 (ON) position and the brake pedal depressed:
1. Apply the parking brake.
2. Insert the key and turn it to the 3
(OFF) position.Apply the brake
pedal and shift to N (Neutral).
3
1
2
5
4
2007 Freestar(win)
Owners Guide (post-2002-fmt)
USA(fus)
Driving
219

IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT
3.9L/4.2L V6 engines
1. Brake fluid reservoir
2. Air filter assembly
3. Power distribution box
4. Battery
5. Automatic transmission fluid dipstick
6. Engine oil dipstick
7. Engine oil filler cap
8. Windshield washer fluid reservoir
9. Engine coolant reservoir
10. Power steering fluid reservoir
576894
10321
2007 Freestar(win)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
269

POWER STEERING FLUID
Check the power steering fluid.
Refer to the scheduled maintenance
guide for the service interval
schedules. If adding fluid is
necessary, use only MERCON
AT F.
1. Start the engine and let it run until it reaches normal operating
temperature (the engine coolant temperature gauge indicator will be
near the center of the normal area between H and C).
2. While the engine idles, turn the steering wheel left and right several
times.
3. Turn the engine off.
4. Check the fluid level in the reservoir. It should be between the MIN
and MAX lines. Do not add fluid if the level is within this range.
5. If the fluid is low, add fluid in small amounts, continuously checking
the level until it reaches the correct operating range. Be sure to put the
cap back on the reservoir.
BRAKE FLUID
The fluid level will drop slowly as
the brakes wear, and will rise when
the brake components are replaced.
Fluid levels between the “MIN” and
“MAX” lines are within the normal
operating range; there is no need to
add fluid. If the fluid levels are
outside of the normal operating
range the performance of your
brake system could be
compromised; seek service from
your authorized dealer immediately.
2007 Freestar(win)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
292

Item Capacity Ford part nameFord part number /
Ford specification
Lock cylinders —Motorcraft Penetrating
and Lock LubricantXL-1 /
None
Power steering fluidFill to line on
reservoirMotorcraft MERCON

AT FXT-2-QDX /
MERCON

Automatic transaxle
fluid13.3 quarts
(12.6L)Motorcraft MERCON
V
AT F
2
XT-5-QM /
MERCON
V
Windshield washer fluidFill to line on
reservoirMotorcraft Premium
Windshield Washer
ConcentrateZC-32-A /
WSB-M8B16-A2
Fuel tank26.0 gallons
(98.4L)——
1Use only brake fluids certified to meet Ford specifications. DOT 3 fluid is recommended. However,
if DOT 3 is not available, DOT 4 fluid can be used.2Ensure the correct automatic transmission fluid is used MERCON
and MERCON
V are not
interchangeable. DO NOT MIX MERCON
and MERCON
V. Refer toscheduled maintenance
informationto determine the correct service interval.3Add the coolant type originally equipped in your vehicle.4Use of synthetic or synthetic blend motor oil is not mandatory. Engine oil need only meet the
requirements of Ford specification WSS-M2C930-A and the API Certification mark.
2007 Freestar(win)
Owners Guide (post-2002-fmt)
USA(fus)
Maintenance and Specifications
301

wheels ......................................261
wiper blades ............................263
Clock ............................................66
Compass, electronic ....................58
calibration .................................60
set zone adjustment .................59
Console ........................................65
overhead ....................................58
Controls
power seat ...............................115
steering column ........................74
Coolant
checking and adding ..............276
refill capacities ................280, 300
specifications ..........................300
Cruise control
(see Speed control) ....................71
Cupholder(s) .............................118
Customer Assistance ................225
Ford Extended Service
Plan ..........................................257
Getting assistance outside
the U.S. and Canada ..............258
Getting roadside assistance ...225
Getting the service you
need .........................................253
Ordering additional
owner’s literature ...................258
Utilizing the Mediation/
Arbitration Program ...............256
D
Daytime running lamps
(see Lamps) ................................46
Dipstick
automatic transmission
fluid ..........................................293
engine oil .................................271Doors ...........................................60
power sliding ............................62
Driving under special
conditions ..................................222
through water .........................224
DVD system .................................34
E
Emergencies, roadside
jump-starting ..........................245
Emission control system ..........289
Engine ........................................302
cleaning ...................................262
coolant .....................................276
idle speed control ...................274
lubrication specifications .......300
refill capacities ........................300
service points ..................269–270
starting after a collision .........227
Engine block heater .................214
Engine oil ..................................271
change oil soon warning,
message center .......................271
checking and adding ..............271
dipstick ....................................271
filter, specifications ........273, 299
recommendations ...................273
refill capacities ........................300
specifications ..........................300
Exhaust fumes ..........................213
F
Floor mats ...................................87
Fluid capacities .........................300
Fuel ............................................281
calculating fuel economy .......286
cap ...........................................283
2007 Freestar(win)
Owners Guide (post-2002-fmt)
USA(fus)
Index
308

headlamps .................................45
headlamps, flash to pass ..........46
instrument panel, dimming .....47
interior lamps .....................49–51
replacing bulbs ...................52, 55
Lane change indicator
(see Turn signal) ........................49
Liftgate ............................87–88, 92
remote release ..................95, 101
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........215
Load limits .................................200
Locks
autolock .....................................96
childproof ..................................98
doors ..........................................95
Lubricant specifications ...........300
Lug nuts ....................................245
Luggage rack ...............................92
Lumbar support, seats .............115
M
Message center .....................78–79
english/metric button ...............81
system check button ................81
warning messages .....................82
Mirrors .........................................69
automatic dimming rearview
mirror ........................................69
fold away ...................................70
heated ........................................70
programmable memory ..........102
side view mirrors (power) .......69
signal .........................................70
Motorcraft parts ........265, 281, 299
O
Octane rating ............................285Oil (see Engine oil) ..................271
Overdrive ...................................220
P
Parking brake ............................216
Parts (see Motorcraft parts) ....299
Passenger Occupant
Classification Sensor .................139
Pedals (see Power
adjustable foot pedals) ...............71
Power adjustable foot pedals .....71
Power distribution box
(see Fuses) ...............................231
Power door locks ..................95–96
Power liftgate ......................88, 101
Power mirrors .............................69
Power point .................................66
Power steering ..........................218
fluid, checking and adding ....292
fluid, refill capacity ................300
fluid, specifications .................300
Power Windows ...........................67
R
Radio ..........................19, 21, 24, 27
Relays ........................................227
Remote entry system .........98, 100
illuminated entry ............104–105
locking/unlocking
doors ................................100–101
panic alarm .............................102
replacement/additional
transmitters .............................103
replacing the batteries ...........103
Reverse sensing system ...........222
2007 Freestar(win)
Owners Guide (post-2002-fmt)
USA(fus)
Index
310