2007 FIAT GRANDE PUNTO petrol

209
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
Normal paint maintenance consists in
washing at intervals depending on the con-
ditions and environment of use. For exam-
ple, in highly polluted areas, or if the roads
are sprayed with salt, it is wise to wash the
car more frequently.
To correctly wash the car:
❒ remove the aerial from the roof to pre-
vent damage to it if the car is washed in
an automatic system;
❒ wash the body using a low pressure jet
of water;
❒ wipe a sponge with a slightly soapy so-
lution over the bodywork, frequently
rinsing with the sponge;
❒ rinse well with water and dry with a jet
of air or a chamois leather.
When drying, take particular care with the
less visible parts like door surrounds, bon-
net and around the headlights where wa-
ter may stagnate. The car should not be
taken to a closed area immediately, but left
in the open so that residual water can
evaporate.Do not wash the car after it has been left
in the sun or with the bonnet hot: this may
alter the shine of the paintwork.
Exterior plastic parts must be cleaned in
the same way as the rest of the car.
Where possible, do not park under trees;
the resinous substance many species re-
lease give the paint a dull appearance and
increase the possibility of triggering rust
processes.
IMPORTANT Bird droppings must be
washed off immediately and thoroughly as
the acid they contain is particularly ag-
gressive.
Detergents cause water pollu-
tion. Therefore the engine
compartment should be
washed in areas equipped for
collecting and purifying the liquid used
in the washing process.
Windows
Use specific window cleaner products.
Use also clean cloths to avoid scratching
the glass or damaging the transparency.
IMPORTANT The inside of the
rearscreen should be wiped gently with a
cloth in the direction of the filaments to
avoid damaging the heating device.
Engine compartment
At the end of the winter the engine com-
partment should be carefully washed,
without directing the jet against electron-
ic control units. Contact a specialised
workshop to have this done.
IMPORTANT The car should be washed
with the engine cold and the ignition key
at STOP. After washing make sure that
the various protections (e.g. rubber caps
and various covers) have not been dam-
aged or removed.
Front headlights
IMPORTANT Never use aromatic sub-
stances (e.g.: petrol) or ketones (e.g.: ace-
tone) for cleaning front headlight plastic
lens.
189-210 Punto GDX GB 20-07-2007 9:43 Pagina 209

210
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
CLEANING SEATS AND FABRIC
AND VELVET PARTS
Use a soft brush or vacuum cleaner to re-
move dust. Velvet is cleaned better if the
brush is moistened.
Rub the seats with a sponge moistened
with a solution of water and neutral de-
tergent.
Never use flammable prod-
ucts like oil ether or rectified
petrol for cleaning car interiors. Elec-
trostatic discharges generated by rub-
bing during cleaning operations could
cause fire.
WARNING
Do not keep aerosol cans in
the car: they might explode.
Aerosol cans must never be exposed
to a temperature above 50° C. The
temperature inside the car exposed
to the sun may go well beyond that
figure.
WARNING
INTERIORS
Periodically check that water is not
trapped under the mats (due to water
dripping off shoes, umbrellas, etc.) which
could cause oxidisation of the sheet met-
al.INTERIOR PLASTIC PARTS
For routine cleaning of interior plastic
parts use a soft cloth moistened with wa-
ter and neutral soap. Remove grease or
persisting stains using appropriate solvent-
free products designed to preserve ap-
pearance and colour of plastic compo-
nents.
IMPORTANT Never use spirit or petro-
leum to clean the instrument panel.
STEERING WHEEL/GEAR LEVER
KNOB WITH GENUINE
LEATHER COVERING
These components shall only be cleaned
with water and neutral soap. Never use
spirit or alcohol-based products.
Before using special products for clean-
ing interiors, read carefully label instruc-
tions and indications to make sure they
are free from spirit and/or alcohol-based
substances.
If when cleaning the windscreen with spe-
cial glass products, some drops fall on the
leather covering of the steering wheel/gear
lever knob remove them immediately and
then clean with water and neutral soap.
IMPORTANT Take the utmost care when
engaging the steering lock to prevent
scratching the leather covering. Upholstery of your car has
been designed to withstand
wear deriving from common
use of the car. You are how-
ever recommended to avoid strong
and/or continuous scratching with
clothing accessories such as metallic
buckles, studs, Velcro fastenings and
the like, since these items cause cir-
cumscribed stress of the cover fabric
that could lead to yarn breaking, and
damage the cover as a consequence.
189-210 Punto GDX GB 20-07-2007 9:43 Pagina 210

215
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
1.4
350A1000
Otto
4 in line
72 x 84
1368
11.1
57
77
6000
115
11.7
3000
NGK
ZKR7A-10
Unleaded petrol 95
RON
(Specification
EN228) 1.2
199A4000
Otto
4 in line
70.8 x 78.86
1242
11.1
48
65
5500
102
10.4
3000
NGK
ZKR7A-10
Unleaded petrol 95
RON
(Specification
EN228)1.4
16V
199A6000
Otto
4
in line
72 x 84
1368
10.8:1
70
95
6000
125
12.9
4500
NGK
ZKR7A-10
Unleaded petrol 95
RON
(Specification
EN228)1.4 T-JET
198A4000
Otto
4 in line
72,0 x 84,0
1368
9,8
88
120
5000
206
21
1750
NGK
IKR9F8
Unleaded petrol 95
RON
(Specification
EN228)
ENGINE
GENERAL
Engine code
Cycle
Number and layout of cylinders
Piston bore and stroke mm
Total displacement cm3
Compression ratio
Maximum power (EEC) kW
HP
corresponding ratio rpm
Maximum torque (EEC) Nm
kgm
corresponding ratio rpm
Spark plugs
Fuel
211-231 Punto GDX GB 31-07-2007 11:15 Pagina 215

224
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
PERFORMANCE
Top admitted speed after initial car use in km/h.
PETROL VERSIONS
1.2 1.4 1.4 16V1.4 T-JET
155 165 178 195
MULTIJET VERSIONS
1.3 Multijet 75 HP 1.3 Multijet 90 HP 1.9 Multijet 1.9 Multijet Sport
165 175 190 200
211-231 Punto GDX GB 31-07-2007 11:15 Pagina 224

3 door
4 seat
1015
480
850
850
1495
900
400
75
603 door
5 seat
1015
560
850
850
1575
900
400
75
605 door
5 seat
1030
560
850
850
1590
900
400
75
603 door
4 seat
1025
480
850
850
1505
1000
400
75
603 door
5 seat
1025
560
850
850
1585
1000
400
75
605 door
5 seat
1040
560
850
850
1600
1000
400
75
603 door
4 seat
1060
480
850
850
1540
1000
400
75
603 door
5 seat
1060
560
850
850
1620
1000
400
75
605 door
5 seat
1075
560
850
850
1635
1000
400
75
603 door
4 seat
1155
480
950
850
1635
1000
400
75
603 door
5 seat
1155
560
950
850
1715
1000
400
75
605 door
5 seat
1170
560
950
850
1730
1000
400
75
60
225
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
WEIGHTS
Petrol versions 1.2 1.4 1.4 16V1.4 T-JET
Weights (kg)
Empty weight
(including all fluids,
fuel tank at 90%
and with
no optional):
Payload (*)
including the driver:
Maximum admitted
loads (**)
– front axle:
– rear axle:
– total:
Towable loads
– trailer with brakes:
– trailer without brakes:
Maximum load on roof:
Maximum load on
tow hitch
(trailer with brakes):
(*) If special equipment is fitted (sunroof, tow hitch, etc.) the unladen car weight increases, thus reducing the specified payload.
(**) Loads not be exceeded. The driver is responsible for arranging the loads in the boot and/or on the roof so that they comply
with these limits.
211-231 Punto GDX GB 31-07-2007 11:15 Pagina 225

Specified fuels and
original lubricants
Unleaded petrol with
no less than 95 R.O.N.
(EN 228 Specification)
Diesel fuel for motor
vehicles
(EN590 Specification)
Mixture of 50% water
and PARAFLU UP (
❒)
SELENIA K P.E.
SELENIA WR
TUTELA CAR
TECHNYX (
▲)
TUTELA CAR
MATRYX (
❍)
TUTELA TOP 4
Mixture of water and
TUTELA
PROFESSIONAL
SC 35
227
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
1.3
Multijet
75 HP
–
–
45
5 ÷ 7
7.3
–
–
3.0
3.2
1.7 (
▲)
(*)
0.5
2.2
4.5 1.4
45
5 ÷ 7
–
–
5.27
2.4
2.6
–
–
1.5 (▲)
0.5
2.2
4.5 1.2
45
5 ÷ 7
–
–
5.27
2.4
2.6
–
–
1.5 (▲)
0.5
2.2
4.5
1.3
Multijet
90 HP
–
–
45
5 ÷ 7
7.4
–
–
3.0
3.2
2.0 (
❍)
(**)
0.5
2.2
4.5
1.9
Multijet
–
–
45
5 ÷ 7
6.35
–
–
3.8
4.18
2.0 (
❍)
0.5
2.2
4.5
1.416V
45
5 ÷ 7
–
–
5.27
2.75
2.9
–
–
1.65 (
▲)
0.5
2.2
4.5
1.4
T-JET
45
5 ÷ 7
–
–
6.0
2,4
2,6
–
–
1.7 (
▲)
0.5
2,2
4,5
CAPACITIES
Fuel tank: litres
including a reserve of: litres
Fuel tank: litres
including a reserve of: litres
Engine cooling system:litres
Engine sump: litres
Engine sump and filter: litres
Engine sump: litres
Engine sump and filter: litres
Gearbox/differential
casing kg:
Hydraulic brake circuit: kg
Windscreen, rear window
andheadlight washer litres
fluid reservoir: litres
(*) Valve also valid for 1.3 Multijet 90 HP version with 5-gear transmission.
(**) Version with 6-speed gearbox
(
❒) When the vehicle is used under particularly harsh climate conditions, we recommend using a 60-40 mixture of PARAFLU UP
and demineralised water.
211-231 Punto GDX GB 31-07-2007 11:15 Pagina 227

228
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
SELENIA K P.E.
Contractual
Technical Reference
N° F603.C07
SELENIA WR
Contractual
Technical Reference
N° F515.D06According to
Service Schedule
According to
Service Schedule Synthetic-based oils, grade SAE 5W-40, ACEA C3.
FIAT 9.55535-S2qualification
Synthetic-based oils, grade SAE 5W-40.
FIAT 9.55535-N2qualification
FLUIDS AND LUBRICANTS
RECOMMENDED PRODUCTS AND THEIR SPECIFICATIONS
Use Fluid and lubricant specifications Original Change
for correct car operation fluids and
lubricants
Oil for
petrol engines
Oils for
diesel engines
For diesel engines, in the event of emergencies when genuine products are not available, lubricants providing at least ACEA B4
performance are allowed; in that case, engine best performance is not guaranteed; we recommend to have it replaced as soon as
possible with the recommended lubricants by the Fiat Dealership.
Use of products with low-quality properties than ACEA A3 and ACEA B4 could cause damages to the engine that are not covered
by the warranty.
For very cold climate conditions, ask Fiat Dealership for the appropriate Seleniaproduct to use.
211-231 Punto GDX GB 31-07-2007 11:15 Pagina 228

Lubricants and
greases
for transmission
Use Fluid and lubricant specifications Original fluids and Applications
for correct car operation lubricants
(*) IMPORTANT Do not top up or mix with fluids having characteristics different from those specified.(❒) When the vehicle is used under particularly harsh climate conditions, we recommend using a 60-40 mixture of PARAFLU UP and
demineralised water.LSynthetic-based oils, grade SAE 75W- 85
that passes API GL4 PLUS specifications.
Synthetic-based oil, grade SAE 75W-85
that passes API GL-4 specifications
Grease containing Molybdenum bisulphide for high
temperature appliances. N.L.G.I. 1-2 consistency.y
Specifc grease to be used for constant-velocity joints with
low friction coefficient. N.L.G.I. 0-1 consistency.
Poly-urea oil synthetic-based grease suitable for high
temperatures. NL.GI. 2 consistency
Synthetic fluid FMVSS no. 116 DOT 4, ISO 4925
SAE J1704, CUNA NC 956- 01
Red protective with antifreeze action, based on
inhibited monoethylen glycol with organic formula
based on O.A.T, that passes CUNA NC 956-16,
ASTM D 3306 specifications.
Mixture of alcohol, water and surfactants
CUNA NC 956-II
TUTELA CAR
TECHNYX
Contractual Technical
Reference N° F010.B05
TUTELA CAR
MATRYX
Contractual Technical
Reference N° F108.F02
TUTELA ALL
STAR Contractual
Technical Reference
N° F702.G07
TUTELA
STAR 700
Contractual Technical
Reference N° F701.C07
TUTELA STAR 325Contractual Technical
Reference N° F301.D03
TUTELA TOP 4Contractual Technical
Reference N° F001.A93
PARAFLU UP (*)Contractual Technical
Reference N° F101.M01
TUTELA PROFES-
SIONAL SC 35
Contractual Technical
Reference N° F201.D02
Mechanical gearbox
and differential (petrol
versions and 1.3 Multijet
75 HP versions)
Mechanical gearbox
and differential
(1.3 Multijet 90HP
versions and
1.9 Multijet versions)
CV joints
on wheel side
CV joints on differential
side (excluding 1.9
Multijet versions)
CV joints
on differential side
(1.9 Multijet versions)
Brake and clutch
hydraulic controls
Radiator antifreeze
proportion: 50% water
and 50% PARAFLU UP
(❒)
To be used diluted or
undiluted in windscreen/
rear window washer/
wiper systems
229
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
Brake fluids
Protective agent for
radiators
Windscreen/ rear
window washer fluid
211-231 Punto GDX GB 31-07-2007 11:15 Pagina 229