2007 FIAT 600 light

115CAR MAINTENANCE
Incorrect assembly of
electric and electronic de-
vices may cause severe
damage to your car. Go to a Fiat
Dealership if you want to install
accessories (alarms, mobile
phone, etc.): they will suggest the
most suitable devices and advise
you if a higher capacity battery
needs to be installed.
Batteries contain sub-
stances that can be very
dangerous for the envi-
ronment. t is advisable to have the
battery changed by a Fiat Dealer-
ship where it will be disposed of
according to the law.
If the vehicle must re-
main unused for a long
time at very low temper-
ature, remove the battery and
carry it to a warm place, to avoid
freezing.When you must perform
any operation on the bat-
tery or near it, always pro-
tect your eyes with the special
goggles.
USEFUL ADVICE FOR
LENGTHENING THE LIFE OF
YOUR BATTERY
To avoid draining your battery and
lengthen its life, observe the follow-
ing indications:
– when you park the car, ensure the
doors, tailgate and bonnet are closed
properly;
– switch off all lights inside the car:
the car is however equipped with a
system which switches all internal
lights off automatically;
– do not keep accessories (e.g. sound
system, hazard lights, etc.) switched on
for a long time when the engine is not
running;
– before performing any operation
on the electrical system, disconnect
the battery negative cable;
– battery terminals shall always be
perfectly tightened.IMPORTANT If the charge level re-
mains for a long time under 50%, the
battery is damaged by sulphation, re-
ducing its capacity and starting atti-
tude.
The battery will also be more at risk
of freezing (e.g. already at -10°C). Re-
fer to the paragraph “Car inactivity” in
“Starting and driving” if the car is left
parked for a long time.
If after buying the car, you want to
install electric accessories which re-
quire permanent electric supply
(alarm, etc.) contact Fiat Dealership
whose qualified personnel, in addition
to suggesting the most suitable de-
vices, will evaluate the overall electric
absorption, checking whether the car’s
electric system is capable of with-
standing the load required, or whether
it should be integrated with a more
powerful battery.
Since these devices continue ab-
sorbing energy even when the ignition
key is off, they gradually run down the
battery.
105-123 Seicento GB 22-11-2007 10:51 Pagina 115

121CAR MAINTENANCE
TIPS FOR KEEPING
THE BODYIN GOOD
CONDITIONS
Paintwork
The paintwork is not only to make
your car look attractive but also to
protect the steel.
If your car is scuffed or scratched
deeply you are therefore advised to
touch up the paintwork as necessary
to prevent rust from forming.
Only use genuine products when
touching up the paintwork (see the
TECHNICAL SPECIFICATIONSchapter.
Ordinary maintenance of the paint-
work means washing it. The frequency
you should do this depends on the
conditions and the environment the
car is driven in. For example, in areas
with a high level of air pollution, or on
roads sprinkled with road saltwash
the car more frequently.Detergents pollute wa-
ter. For this reason, the
car must be washed in an
area equipped for the collection
and purification of the liquids
used while washing.
To wash the car properly:
1) Remove the aerial from the roof
to avoid damaging it in an automatic
car wash.
2) Wash the body using a low pres-
sure jet of water.
3) Wipe a sponge with a slightly
soapy solution over the bodywork,
frequently rinsing the sponge.
4) Rinse well with water and dry
with a jet of air or a chamois leather.
When drying the car, be careful to
get at those parts which are not so
easily seen e.g. the door frames, bon-
net and around the headlights where
water can most readily collect.
– the use of zinc-plated (or pre-
treated) sheet steel which is highly re-
sistant to rust;
– the spraying of the underbody, en-
gine compartment, inside the wheel-
arches and other parts with wax-
based products with a high protective
capacity;
– spraying plastic-coating materials
to protect the most exposed points:
under the door, inside the wings, the
edges etc.;
– the use of “open” box sections to
prevent condensation and water from
building up and rusting the inside of
the parts.
BODY AND UNDERBODY
WARRANTY
Your Fiat 600 is covered by guaran-
tee against any original structural or
body part being holed by rust. Refer
to the “Warranty Booklet” for the
general conditions of this guarantee.
105-123 Seicento GB 22-11-2007 10:51 Pagina 121

122CAR MAINTENANCE
Engine compartment
At the end of each winter season,
carefully clean the engine compart-
ment. Have this done at a garage. Leave the car in the open so that the
water can evaporate.
Do not wash the car after it has
been parked in the sun or while the
bonnet is hot: it could take the shine
off the paint.
Outside plastic parts must be
cleaned following the usual car wash-
ing procedure.
Where possible avoid parking the
car under trees; the resinous sub-
stances that certain species of tree
shed dull the paintwork and increase
the possibility of rust forming.
IMPORTANT Bird droppings
must be washed off immediately and
with great care as their acid is partic-
ularly aggressive.Detergents pollute wa-
ter. The car must there-
fore be washed in an area
equipped for the collection and
purification of the liquids used
while washing.
IMPORTANTThe engine com-
partment should be washed while the
engine is cold and with the ignition key
at STOP. After washing, make sure
that the various protections (e.g. rub-
ber boots and various guards) have
not be removed or damaged. To better protect the paintwork,
polish with specific protective wax.
When the paintwork tends to lose
its shine because of the build-up of
smog, use polish wax which has a
slightly abrasive as well as protective
action.
Windows
Use specific window cleaners to
clean the windows. Use very clean
cloths to avoid scratching the glass or
damaging its transparency.
IMPORTANT To prevent damage
to the electrical heater element, wipe
the inside of the heated rear window
gently in the same direction as the el-
ements.
105-123 Seicento GB 22-11-2007 10:51 Pagina 122

123CAR MAINTENANCE
CLEANING SEATS
AND FABRICS
– Remove dust with a soft brush and
vacuum cleaner.
– Brush the seats with a damp
sponge with water and a neutral soap.
– Remove any grease stains with a
specific product.
CLEANING LEATHER SEATS
– Remove the dry dirt with a
chamois leather or very slightly moist
cloth without exerting too much pres-
sure.
– Remove liquid or grease stains
with a dry absorbent cloth without
rubbing. Then wipe with a chamois
leather or soft cloth moistened with
water and neutral soap.
If the stain does not come out, use a
special cleaning compound being par-
ticularly careful to follow the instruc-
tions for use.
IMPORTANT Never use alcohol
or alcohol-base products.PLASTIC PARTS INSIDE
THE CAR
Use special products designed not to
alter the appearance of the compo-
nents.
IMPORTANT Do not use alcohol
or petrol to clean the instrument
panel.
Do not keep aerosol
cans in the car. There is
the risk they might ex-
plode. Aerosol cans must never
be exposed to a temperature
above 50°C; when the weather
starts to get hot the tempera-
ture inside the car might go well
beyond that figure.INTERIORS
From time to time check that water
has not collected under the mats
(from dripping shoes, umbrellas etc.)
which could cause the steel to rust.
Never use inflammable
products such as petro-
leum ether or petrol to
clean inside the car. The electro-
static loads that are generated
while rubbing to clean could be-
come a fire risk.
105-123 Seicento GB 22-11-2007 10:51 Pagina 123

137INDEX
I I
N N
D D
E E
X X
ABS ............................................ 54
Accessories purchased by the
owner ......................................... 66
– Installation of electrical/
electronic devices .................... 67
– Radio transmitters and
mobile phones ...................... 67
Air filter ....................................... 113
Air recirculation ......................... 35
Ashtray ......................................... 42
Battery
– checking fluid level ............... 114
– jump starting .................. 84-101
– recharging .............................. 101
– replacing the battery ........... 114
– useful advice .......................... 115
– warning light for check ....... 115
Bodywork .................................... 124
Bonnet .......................................... 51
Boot
– extension ............................... 48
– opening ................................... 47
– securing the load .................. 49Brake fluid level .......................... 112
Brake lights .................................. 95
Brakes
– fluid level ................................ 112
– service and emergency ....... 126
Bulbs
– bulb replacement ................. 89
– exterior bulb replacement .. 92
– general information ............. 90
– interior bulb replacement .. 107
– types ....................................... 91Capacities .................................. 133
Car maintenance
– additional operations .......... 108
– annual inspection plan ......... 108
– scheduled servicing .............. 105
– service schedule ................... 106
Car parked .................................. 71
Car radio ..................................... 64
Carrying children in safety ..... 13
Ceiling (courtesy) light
– bulb replacement ................ 97– controls .................................. 39
Central locking ........................... 45
Cigar lighter ................................ 42
Clock.............................................. 24
Clutch ........................................... 127
CO
2emissions ........................... 136
Control buttons ......................... 40
Correct use of the vehicle ....... 70
Courtesy (ceiling) lights
– bulb replacement ................ 97
– controls .................................. 39
Courtesy light
– bulb replacement ................ 97
– controls .................................. 39
Dashboard ................................. 19
Dimensions ................................. 131
Dipped beam headlights
– bulb replacement ................ 92
– controls .................................. 37
Directable, adjustable air vents 33
Direction indicators
– controls .................................. 38
137-144 Seicento GB 28-11-2007 9:38 Pagina 137

138INDEX
– front bulb replacement ..... 93
– rear bulb replacement ....... 95
– side bulb replacement ....... 94
Display of fuel cut
off activated .............................. 22
Doors ........................................... 45
Driving style ................................ 74
Economical driving .................. 75
Electric power assisted
steering ...................................... 61
Electric windows ........................ 46
Electronic control units ............ 116
Engine
Engine compartment
(washing) ................................... 122
Engine coolant level ................. 111
Engine oil
Engine oil consumption ............ 111
Engine oil level ............................ 110
– consumption ......................... 111
– level check ............................. 110
– Technical specifications ...... 125
– cooling .................................... 111
– features .................................. 126
– fluid level check .................... 110
– identification code ............... 124
– on/power supply .................. 127
EOBD (System) ........................... 60
EOBD system ............................. 60
Fiat Code (The system) ......... 4
Fiat CODE system ..................... 4
Filling the tank ............................ 68
Fog lights
– control .................................... 40
– direction ................................. 54
Front air bags ............................ 56
– front air bags ......................... 56
– general information ............. 58
– passenger front air bag ....... 57
Front fog lights
– bulb replacement ................ 94
– on/off button ......................... 40
Fuel ................................................ 68
– consumption ......................... 136
– fuel cut off switch ............... 41
– gauge ....................................... 21
Fuel consumption ...................... 136
Fuel cut off switch .............. 22-41
Fuel gauge .................................... 21
Fuses ............................................. 100
Gearbox
– type ......................................... 127
– use of the gearbox ............... 72
Government homologation
(remote control) ............... 9-139
Handbrake ......................... 72-126
Hazard warning lights
– controls .................................. 40
Head restraints ........................... 30
Headlights
– angle compensation ............. 53
– light beam direction ............ 53
Heated rear window ................. 40
Heater controls .......................... 33
Heating ......................................... 33
Horn ............................................. 41
Identification data .................... 124
Ignition switch ............................ 18
In an emergency ......................... 83
Instrument panel ........................ 20
Jack
– usage ................................ 87-102
– warnings ................................. 86
Keys ........................................... 4
– duplication ............................. 7
Knowing your car ....................... 6
Lubricants (specifications) .... 136
Luggage compartment .............. 47
137-144 Seicento GB 28-11-2007 9:38 Pagina 138

139INDEX
Main beam headlights
– bulb replacement ................ 92
– controls .................................. 37
– flashing .................................... 38
Manual climate control system
– climate control (cooling) .... 36
– controls .................................. 35
– maintenance .......................... 36
Milometer .................................... 21
Number plate lights .............. 95
On board instruments ........... 21
Paint ........................................... 121
Performance ............................... 131
Personalized adjustments ......... 29
Pretensioners .............................. 10
Protecting devices that reduce
emissions ................................... 76
Raising the vehicle .................. 102
Rear fog lamps
– bulb replacement ................ 95
– on/off button ......................... 40Rear screen washer
– controls .................................. 39
– fluid level ................................ 112
Rear view mirrors
– exterior .................................. 31
– interior ................................... 31
Rearscreen wiper
– blades ...................................... 118
– controls .................................. 39
– jets ........................................... 120
Restricting management
expenses .................................... 73
Reversing lights ........................... 95
Roof rack/ski rack ...................... 52
Rubber hoses ............................. 118
Seat belts
– general information ............ 11
– maintenance .......................... 12
– pretensioners ........................ 10
– transporting children
safely ....................................... 13
– usage ....................................... 7
Seats
– access to rear seats ............. 31– backrest adjustment ............ 30
– children (transporting) ....... 13
– cleaning ................................... 123
– lengthwise adjustment ........ 29
Side lights
– controls .................................. 37
– front bulb replacement ..... 93
– rear bulb replacement ....... 95
Signals for correct driving ........ 5
Snow chains ............................... 81
Spark plugs .................................. 126
Speedometer .............................. 21
Starting the engine
– emergency starting .............. 71-83
– ignition switch ....................... 18
– jump starting .................. 84-101
– procedure for starting ........ 70
– to switch off the engine ...... 71
– warming up the engine
once started .......................... 70
Steering ................................. 61-129
Steering lock ............................... 18-72
Steering wheel levers
– left lever ................................. 37
137-144 Seicento GB 28-11-2007 9:38 Pagina 139

140INDEX
– right lever .............................. 38
Storing the car ............................ 82
Sun roof
– electrically operated ........... 43
Sun visors .................................... 43
Suspension ................................... 127
Symbols ........................................ 4
Tank cap
Technical specifications ............ 124
Third brake lights ....................... 96
To the service station ................ 67
Tools ............................................. 86
Top speed .................................... 133
Towing the car .......................... 103
Towing trailers
– fitting diagram ........................ 78
– installation of tow hook ..... 77
– warnings ................................. 77
Transmission ............................... 126
Travelling safely and in harmony
with nature ............................... 4
Tyre inflation pressure ............. 130
Tyres
– changing a wheel ................... 87– inflation pressure ................ 130
– maintenance .......................... 117
– snow tyres ............................. 80
– types ....................................... 130
Usage conditions ..................... 75
Van ............................................. 62
Various controls ........................ 40
Vehicle inactivity ........................ 82
Ventilation ................................... 35
Warning lights ........................ 23
Weights ........................................ 132
Wheel
– maintenance .......................... 117
– replacement .......................... 87
– spare wheel ........................... 128
– types ....................................... 130
Wheel geometry ........................ 128
Windows (cleaning) .................. 122
Windscreen and rearscreen wiper
blades ......................................... 118
Windscreen washer
– controls .................................. 38– fluid level ................................ 112
Windscreen wiper
– blades ...................................... 118
– controls .................................. 38
– jets ........................................... 120
Windscreen/rearscreen
washer fluid level ..................... 112
137-144 Seicento GB 28-11-2007 9:38 Pagina 140