2007 DODGE SPRINTER fuel filter

317 Practical hints
Fuel system
5
\3 Fuel systemOn vehicles with a diesel engine, it is nec-
essary to drain the fuel filter if the/ in-
dicator lamp lights up.
To this end, have the fuel filter with water
separator drained at an authorized Sprint-
er Dealer which has the necessary special-
ist knowledge and tools to carry out the
work required.The fuel filter with water separator is in the
engine compartment.
1Drain hose
2Drain plug
\1Apply the handbrake and move the se-
lector lever to positionP.
\1Switch off the engine and open the
hood (\2page 185).
\1Place a suitable container under drain
hose1.
\1Switch on the ignition (\2page 67).\1Unscrew drain plug2 immediately
one turn or until liquid flows out of
drain hose1.
\1Make sure that the liquid flows into the
container under drain hose 1.
\1Close drain plug 2 as soon as approx-
imately 0.2 US qt (0.2 l) of liquid has
been collected.
\1When you have drained the fuel filter
with water separator, turn the key back
to position0 in the ignition lock
(\2page 67).
\1Dispose of the collected liquid in an en-
vironmentally responsible manner.Draining the fuel filter!
CAUTION
Drain the fuel filter with water separa-
tor immediately if the/ indicator
lamp lights up. The engine could be
damaged.
Environmental note
H
When handling, storing and disposing of die-
sel and diesel mixtures, please observe the
relevant regulations.
iThe electric fuel delivery pump stops
the flow of liquid automatically after
30 seconds.

318 Practical hintsFuel system
5
\1Drain the fuel filter again if the/ in-
dicator lamp remains lit.If the fuel tank on a vehicle with diesel en-
gine has been run dry, there is a possibility
that the engine may not start immediately
after refueling because air may remain in
the fuel system.
After refueling:
\1Switch on the ignition for approximate-
ly 10 seconds.
\1Start the engine repeatedly for no more
than 60 seconds until it runs smoothly.If the engine does not start:
\1Wait approximately 2 minutes.
\1Then start the engine repeatedly again
for no more than 60 seconds until it
runs smoothly.
If this attempt also fails, do not continue to
start the engine. Consult an authorized
Sprinter Dealer.Environmental note
H
Have the drained liquid disposed of at an
authorized Sprinter Dealer.!
CAUTION
If the / indicator lamp remains lit
even after draining for the second time,
have the cause checked immediately at
an authorized Sprinter Dealer.
Bleeding the fuel systemiToo many attempts to start the engine
could drain the battery.

358 *Technical dataService products and capacities
6
Adding engine oil Fuels for gasoline engines
Premium unleaded gasoline
!
CAUTION
Diesel engine:
Never use any amount of engine oil for
the diesel engine that does not con-
form to MB 229.51 or MB 229.31 spec-
ifications. Otherwise the diesel particle
filter (DPF) could be damaged.
If the above specified engine oils are
not available, you may also use engine
oils conforming to MB 228.5, 229.3
and 229.5 specifications. You should
add no more than 1 qt (1 l) of these en-
gine oils, however.
FuelsWarning
G
Gasoline is highly flammable and poisonous.
It burns violently and can cause serious inju-
ry. Whenever you are around gasoline, avoid
inhaling fumes and skin contact, extinguish
all smoking materials. Never allow sparks,
flame or smoking materials near gasoline!
Direct skin contact with fuels and the inha-
lation of fuel vapors are damaging to health.
Switch off the engine before refueling.!
CAUTION
If you are refueling the vehicle from
drums or canisters, you should filter
the fuel before adding it to the tank.
This will prevent malfunctions in the
fuel system caused by contaminated
fuel.
!
CAUTION
To maintain the engine’s durability and
performance, premium unleaded gaso-
line must be used. If premium unleaded
is not available and low octane fuel is
used, follow these precautions:
\4Have the fuel tank only partially
filled with unleaded regular and fill
up with premium unleaded as soon
as possible.
\4Avoid full throttle driving and abrupt
acceleration.
\4Do not exceed an engine speed
of 3000 rpm if the vehicle is loaded
with a light load, such as two per-
sons and no cargo.
\4Do not exceed
2/3 of maximum ac-
celerator pedal position if the vehi-
cle is fully loaded or operating in
mountainous terrain.

365 *Technical data
Service products and capacities
6
CapacitiesVehicle
Engine with
oil filter
Tank
Cooling
system
Windshield washer /
headlamp cleaning
system
Engine oil
Capacity
Including
reserve fuel
Coolant
1
1 Do not exceed a proportion of 55% by volume (antifreeze protection down to about -45 °C) as the heat dissipation properties deteriorate at higher concentrations.
Observe the Mercedes-Benz Specifications for Service Products, Sheet 310.
Water with MB windshield
washer fluid
2500 CRD, 3500 CRD
13.21 US qt.
(12.5 l)
25.0 US gal
(100 l)
5.3 US gal
(20 l)
10.75 US qt.
(10.0 l)
approx. 7.40 US qt. (7.0 l)
2500, 3500
10.04 US qt.
(9.5 l)
25.0 US gal
(100 l)
5.3 US gal
(20 l)
7.40 US qt.
(7.0 l)
approx. 7.40 US qt. (7.0 l)

382 IndexF
Fastening seat belts
see Wearing seat belts
Fault memory
see Malfunction memory
Fax machine
. . . . . . . . . . . . . . . . . . 183
Fire extinguisher
. . . . . . . . . . . . . . . 299
First-aid kit
. . . . . . . . . . . . . . . . . . . 299
Flat tire
changing a wheel
. . . . . . . . . . . . . . 320
Premium tire sealant . . . . . . . . . . . 326
Flow improvers
. . . . . . . . . . . . . . . . 361
Folding seat
. . . . . . . . . . . . . . . . . . . . 74
Folding table in the backrest
. . . . . 166
Front foglamps
. . . . . . . . . .77
, 79
, 307
changing bulbs
. . . . . . . . . . . . . . . . 307
Fuel
gauge
. . . . . . . . . . . . . . . . . . . . . . . . 86
line
. . . . . . . . . . . . . . . . . . . . . 251
, 252
loss
. . . . . . . . . . . . . . . . . . . . 251
, 252
malfunctions
. . . . . . . . . . . . . . . . . 252
see Gasoline or Diesel
Fuel filter with
water separator
draining
. . . . . . . . . . . . . . . . . . . . . 317
Fuel requirements
diesel engine
. . . . . . . . . . . . . . . . . 359gasoline engine
. . . . . . . . . . . . . . . 359
Fuse box
in the driver's seat . . . . . . . . . . . . . 348
main
. . . . . . . . . . . . . . . . . . . . . . . . 345
Fuse chart
. . . . . . . . . . . . . . . . . . . . 345
fuses in the driver’s seat base
. . . . 349
Fuses
. . . . . . . . . . . . . . . . . . . . . . . . 345
G
Gasoline
. . . . . . . . . . . . . . . . . . . . . . 358
consumption
. . . . . . . . . . . . . . . . . 366
reserve fuel warning lamp
. . . . . . . 276
tank capacity
. . . . . . . . . . . . . . . . . 365
Gauge
vehicles without steering wheel buttons
standard display
. . . . . . . . . . . . . . 87
GAWR
. . . . . . . . . . . . . . . . . . . . . . . . 229
Gear oil . . . . . . . . . . . . . . . . . . . . . . . 364
Glove box . . . . . . . . . . . . . . . . . . . . . 165
ventilated . . . . . . . . . . . . . . . . . . . . 136
Gross Axle Weight Rating
see GAWR
Gross Trailer Weight
see GTW
Gross Vehicle Weight
see GVWGross Vehicle Weight Rating
see GVWR
GTW
. . . . . . . . . . . . . . . . . . . . . . . . . 229
GVW . . . . . . . . . . . . . . . . . . . . . . . . . 229
GVWR . . . . . . . . . . . . . . . . . . . . . . . . 229
H
Handbrake
. . . . . . . . . . . . . . . . . . . . 115
applying
. . . . . . . . . . . . . . . . . . . . . 114
display message
. . . . . . . . . . . . . . . 290
emergency braking . . . . . . . . . . . . 115
indicator lamp
. . . . . . . . . . . . . . . . 114
releasing
. . . . . . . . . . . . . . . . . . . . . 115
Hazard warning lamps
. . . . . . . . . . . 80
switching on
. . . . . . . . . . . . . . . . . . . 80
Head restraints . . . . . . . . . . . . . . . . . 72
removing
. . . . . . . . . . . . . . . . . . . . . 73
Headlamp flasher
. . . . . . . . . . . . 77
, 78
Headlamps
bulbs
. . . . . . . . . . . . . . . . . . . . . . . 307
cleaning . . . . . . . . . . . . . . . . . . . . . 244
cleaning system
. . . . . . . . . . . 127
, 193
indicator lamp
. . . . . . . . . . . . . . . 280
fogged-up
. . . . . . . . . . . . . . . . . . . . 257
malfunctions . . . . . . . . . . . . . . . . . 257
Heated
rear window . . . . . . . . . . . . . . . . . . 128
GH F

391 Index
closing
. . . . . . . . . . . . . . . . . . . . . . . 52
correct use
. . . . . . . . . . . . . . . . . . . . 7
data cards . . . . . . . . . . . . . . . . . . . 373
identification number
. . . . . . . . . . 373
leaving in storage
. . . . . . . . . . . . . 265
locking with key
. . . . . . . . . . . . . . . . 55
locking/unlocking centrally
. . . . . . . 64
opening
. . . . . . . . . . . . . . . . . . . . . . 52
with remote control
. . . . . . . . . . . 54
with the key
. . . . . . . . . . . . . . . . . 54
registering
. . . . . . . . . . . . . . . . . . . . . 5
towing
. . . . . . . . . . . . . . . . . . . . . . 342
towing out
. . . . . . . . . . . . . . . . . . . 343
tow-starting . . . . . . . . . . . . . . . . . . 341
transporting . . . . . . . . . . . . . . . . . . 344
Vehicle alteration
. . . . . . . . . . . . . . . . 6
Vehicle capacity weight
. . . . . . . . . 231
Vehicle identification plates
. . . . . 373
Vehicle loading
load limit
. . . . . . . . . . . . . . . . . . . . 206
loading terminology
. . . . . . . . . . . . 228
terminology
. . . . . . . . . . . . . . . . . . 228
Vehicle maximum load
on the tire
. . . . . . . . . . . . . . . . . . . . 231
Vehicle safety certification label
. 373
Vehicle tool kit
. . . . . . . . . . . . . . . . 300
Vehicle/engine emission label
. . . 375
W
Warning labels
. . . . . . . . . . . . . . . . . . 8
Warning lamp
ESP
®/ASR
. . . . . . . . . . . . . 43
, 44
, 268
warning lamp
. . . . . . . . . . . . . . . . . 299
Warning triangle . . . . . . . . . . . . . . . 299
Warranty information
. . . . . . . . . . . . . 5
Washer fluid
. . . . . . . . . . . . . . . . . . 127
adding
. . . . . . . . . . . . . . . . . . . . . . 193
Water separator
draining the fuel filter
. . . . . . . . . . 317
Wheel
. . . . . . . . . . . . . . . . . . . . . . . . 117
changing
. . . . . . . . . . . . . . . . . . . . 320
Wheel nuts/wheel bolts
retightening . . . . . . . . . . . . . . . . . . 324
tightening torque
. . . . . . . . . . . . . . 324
Wheel, tires and
. . . . . . . . . . . . . . . 199
Windows
cleaning the rear window
. . . . . . . . 244
cleaning the side windows . . . . . . . 244
cleaning the windshield
. . . . . . . . . 243
fogged-up
. . . . . . . . . . . . . . . . . . . . 134
power windows
. . . . . . . . . . . . . . . 144
washer fluid
. . . . . . . . . . . . . . . . . . 127Windshield
cleaning
. . . . . . . . . . . . . . . . . . . . . 243
heating . . . . . . . . . . . . . . . . . . 127
, 134
malfunction
. . . . . . . . . . . . . . . . 266
Windshield heating
. . . . . . . . . . . . . 127
Windshield washer fluid
display message
. . . . . . . . . . 287
, 298
wiping with
. . . . . . . . . . . . . . . . . . . 127
Windshield washer system
. . . . . . 193
indicator lamp
. . . . . . . . . . . . . . . . 280
rain sensor
. . . . . . . . . . . . . . . . . . . 126
Windshield wipers
. . . . . . . . . . . . . 126
cleaning
. . . . . . . . . . . . . . . . . . . . . 243
intermittent wipe
. . . . . . . . . . . . . . 126
malfunctions
. . . . . . . . . . . . . . . . . 258
rain sensor
. . . . . . . . . . . . . . . 126
, 127
setting the sensitivity (vehicles with
steering wheel buttons)
. . . . . . . 105
rear window wiper
. . . . . . . . . . . . . 127
replacing the wiper blades
. . . . . . . 319
windshield washer fluid
. . . . . . . . . 127
Winter driving
. . . . . . . . . . . . . 234
, 235
snow chains
. . . . . . . . . . . . . . . . . . 236
Winter operation
tires
. . . . . . . . . . . . . . . . . . . . . . . . 234
Wiper blades
. . . . . . . . . . . . . . . . . . 319
Working on the vehicle
. . . . . . . . . 124
W