2007 DODGE SPRINTER fuel cap

367 *Technical data
Rims and tires
6
\3 Rims and tires
!
CAUTION
Only use tires which have been tested
and approved for your Sprinter vehicle
by the vehicle manufacturer. Tires ap-
proved by the vehicle manufacturer are
developed to provide the best possible
performance in conjunction with the
driving safety systems on your Sprinter
vehicle such as ABS, BAS, ASR or ESP
®.
Using tires other than those approved
by the vehicle manufacturer may result
in damage that is not covered by the
Sprinter warranty.
Using tires other than those approved
by the vehicle manufacturer can have
detrimental effects, such as
\4poor handling characteristics
\4increased noise
\4increased fuel consumption
Moreover, tires and rims not approved
by the vehicle manufacturer may, un-
der load, exhibit dimensional variations
and different tire deformation charac-
teristics that could cause them to come
into contact with the vehicle body or
axle parts. Damage to the tires or the
vehicle may be the result.
Warning
G
Loose wheel nuts or bolts could cause the
vehicle to lose a wheel while it is in motion.
This would jeopardize the operating and
road safety of the vehicle. You could lose
control of the vehicle as a result, cause an
accident an injure yourself or others.
If a wheel was replaced or new wheel nuts
are used, the wheel bolts or wheel nuts must
be retightened to the specified tightening
torque after 30 miles (50 km).
If new or repainted wheels are mounted, the
wheel bolts or wheel nuts must be retight-
ened again to the specified tightening
torque after approximately 600 to 3000
miles (about 1000 to 5000 km).
iFurther information on tires and rims is
available at any authorized Sprinter
Dealer. A placard with the recommend-
ed tire inflation pressures is located on
\4the driver’s door B-pillar for vehi-
cles with a gross weight capacity
less than 10,000 lbs (4500 kg)
(\2page 375)
\4on a label below the driver’s seat on
an outward facing position of the
mounting pillar for vehicles with a
gross weight capacity above
10,000 lbs (4500 kg) (\2page 375)
The tire inflation pressure should be
checked regularly and should only be
adjusted on cold tires.

369 *Technical data
Tire inflation pressure
6
\3 Tire inflation pressureFor vehicles with a gross weight capacity
above 10,000 lbs (4500 kg) only.
For vehicles with a gross weight capacity
less than 10,000 lbs (4500 kg) observe the
recommended cold tire inflation pressures
listed on the tire and loading information
placard on the driver’s door B-pillar
(\2page 210).
Observe the information on recommended
tyre inflation pressure in the “Operation”
section (\2page 210).
The following table lists the recommended
cold tire inflation pressures for all load
conditions up to the maximum permissible
weight limits (GAWR). The tire inflation
pressures listed apply to the tires installed
as original equipment.
Set the correct tyre pressure before load-
ing the vehicle. If the vehicle has been
loaded, check the tyre pressures and cor-
rect them if necessary.The tires can be considered cold if the ve-
hicle has been parked for at least 3 hours
or driven less than 1 mile (1.6 km) at an
ambient temperature of approximately
68 °F (20 °C).
Keeping the tires properly inflated pro-
vides the best handling, tread life and
riding comfort.
Tire temperature and tire inflation pressure
are also increased while driving, depending
on the driving speed and the tire load.
Tire inflation pressure changes by approxi-
mately 1.5 psi (0.1 bar) per 18 °F (10 °C)
of air temperature change. Keep this in
mind when checking tire inflation pressure
where the temperature is different from
the outside temperature.
iIn addition to the following table the
recommended cold tire inflation pres-
sures are listed on a label below the
driver’s seat on an outward facing posi-
tion of the mounting pillar.
Warning
G
Follow recommended tire inflation pres-
sures.
Do not underinflate tires. Underinflated tires
wear excessively and/or unevenly, adverse-
ly affect handling and fuel economy, and are
more likely to fail from being overheated.
Do not overinflate tires. Overinflated tires
can adversely affect handling and ride com-
fort, wear unevenly, increase stopping dis-
tance, and result in sudden deflation
(blowout) because they are more likely to
become punctured or damaged by road de-
bris, potholes etc.

380 Indextemperature gauge
(vehicle with steering wheel
buttons)
. . . . . . . . . . . . . . . . . . . . . 255
Cornering lamps
changing bulbs
. . . . . . . . . . . . . . . . 307
Correct use
. . . . . . . . . . . . . . . . . . . . . 7
Cruise control . . . . . . . . . . . . . . . . . 147
deactivating . . . . . . . . . . . . . . . . . . 149
display message
. . . . . . . . . . . . . . 287
downhill gradients . . . . . . . . . . . . . 148
lever
. . . . . . . . . . . . . . . . . . . . . . . . 148
malfunction
. . . . . . . . . . . . . . . . . . 287
problems
. . . . . . . . . . . . . . . . . . . . 263
setting the speed
. . . . . . . . . . . . . . 149
uphill gradients
. . . . . . . . . . . . . . . 148
Cup holders
. . . . . . . . . . . . . . . . . . . 167
Curb weight . . . . . . . . . . . . . . . . . . . 228
D
Dashboard lighting
see Instrument lighting
Data cards, vehicle
. . . . . . . . . . . . . 373
Dehumidification
. . . . . . . . . . . . . . 134
Delayed switch-off
exterior lighting
(vehicles with steering wheel
buttons)
. . . . . . . . . . . . . . . . . . . . . 104Department of Transportation
see DOT
Diesel
. . . . . . . . . . . . . . . . . . . . . . . . 359
consumption
. . . . . . . . . . . . . . . . . 366
low outside temperatures
. . . . . . . 360
reserve fuel warning lamp . . . . . . . 276
tank capacity
. . . . . . . . . . . . . . . . . 365
Diesel engine
preglow indicator lamp
. . . . . 111
, 276
winter driving
. . . . . . . . . . . . . . . . . 360
Digital speedometer
. . . . . . . . . . . . . . 6
Digital total distance recorder
. . . . . 6
Direction of rotation (tires)
. . . . . . 204
Disconnecting the battery . . . . . . . 335
Display
vehicles with steering wheel buttons
display messages
. . . . . . . . . . . . 284
outside temperature . . . . . . . . . . . 93
standard display
. . . . . . . . . . . . . . 93
vehicles without steering wheel buttons
display messages . . . . . . . . . . . . 281
outside temperature . . . . . . . . . . . 87
Door control panel
. . . . . . . . . . . . . . 22
opening the door . . . . . . . . . . . . . . . 55
power windows . . . . . . . . . . . . . . . 144
Doors
display message . . . . . . . . . . . . . . . 298
locking and unlocking
. . . . . . . . . . . 52opening/closing
. . . . . . . . . . . . . . . . 55
DOT
. . . . . . . . . . . . . . . . . . . . . . 225
, 229
Downhill gradients
cruise control
. . . . . . . . . . . . . . . . . 148
parking
. . . . . . . . . . . . . . . . . . 114
, 116
Drinking alcohol or taking drugs and
driving
. . . . . . . . . . . . . . . . . . . . . . . 116
Drinks holder
see Cup holders
Driving abroad
. . . . . . . . . . . . . . . . . 180
Driving on flooded roads
(fording)
. . . . . . . . . . . . . . . . . . . . . . 117
Driving safety system
. . . . . . . . . . . . 42
see Antilock Brake System (ABS)
see Acceleration Skid Control (ASR)
see Brake Assist (BAS)
see Electronic brake force distribution
(EBV)
see Electronic Stability Program (ESP
®)
Driving system
. . . . . . . . . . . . 147
–153
cruise control
. . . . . . . . . . . . . . . . . 147
malfunctions . . . . . . . . . . . . . . . . . 262
Parktronic
. . . . . . . . . . . . . . . . . . . . 150
reverse warning feature
. . . . . . . . . 153
Driving tips
. . . . . . . . . . . . . . . . . . . 175
automatic transmission
. . . . . . . . . 123
braking
. . . . . . . . . . . . . . . . . . . . . . 113
driving abroad
. . . . . . . . . . . . . . . . 180
D

382 IndexF
Fastening seat belts
see Wearing seat belts
Fault memory
see Malfunction memory
Fax machine
. . . . . . . . . . . . . . . . . . 183
Fire extinguisher
. . . . . . . . . . . . . . . 299
First-aid kit
. . . . . . . . . . . . . . . . . . . 299
Flat tire
changing a wheel
. . . . . . . . . . . . . . 320
Premium tire sealant . . . . . . . . . . . 326
Flow improvers
. . . . . . . . . . . . . . . . 361
Folding seat
. . . . . . . . . . . . . . . . . . . . 74
Folding table in the backrest
. . . . . 166
Front foglamps
. . . . . . . . . .77
, 79
, 307
changing bulbs
. . . . . . . . . . . . . . . . 307
Fuel
gauge
. . . . . . . . . . . . . . . . . . . . . . . . 86
line
. . . . . . . . . . . . . . . . . . . . . 251
, 252
loss
. . . . . . . . . . . . . . . . . . . . 251
, 252
malfunctions
. . . . . . . . . . . . . . . . . 252
see Gasoline or Diesel
Fuel filter with
water separator
draining
. . . . . . . . . . . . . . . . . . . . . 317
Fuel requirements
diesel engine
. . . . . . . . . . . . . . . . . 359gasoline engine
. . . . . . . . . . . . . . . 359
Fuse box
in the driver's seat . . . . . . . . . . . . . 348
main
. . . . . . . . . . . . . . . . . . . . . . . . 345
Fuse chart
. . . . . . . . . . . . . . . . . . . . 345
fuses in the driver’s seat base
. . . . 349
Fuses
. . . . . . . . . . . . . . . . . . . . . . . . 345
G
Gasoline
. . . . . . . . . . . . . . . . . . . . . . 358
consumption
. . . . . . . . . . . . . . . . . 366
reserve fuel warning lamp
. . . . . . . 276
tank capacity
. . . . . . . . . . . . . . . . . 365
Gauge
vehicles without steering wheel buttons
standard display
. . . . . . . . . . . . . . 87
GAWR
. . . . . . . . . . . . . . . . . . . . . . . . 229
Gear oil . . . . . . . . . . . . . . . . . . . . . . . 364
Glove box . . . . . . . . . . . . . . . . . . . . . 165
ventilated . . . . . . . . . . . . . . . . . . . . 136
Gross Axle Weight Rating
see GAWR
Gross Trailer Weight
see GTW
Gross Vehicle Weight
see GVWGross Vehicle Weight Rating
see GVWR
GTW
. . . . . . . . . . . . . . . . . . . . . . . . . 229
GVW . . . . . . . . . . . . . . . . . . . . . . . . . 229
GVWR . . . . . . . . . . . . . . . . . . . . . . . . 229
H
Handbrake
. . . . . . . . . . . . . . . . . . . . 115
applying
. . . . . . . . . . . . . . . . . . . . . 114
display message
. . . . . . . . . . . . . . . 290
emergency braking . . . . . . . . . . . . 115
indicator lamp
. . . . . . . . . . . . . . . . 114
releasing
. . . . . . . . . . . . . . . . . . . . . 115
Hazard warning lamps
. . . . . . . . . . . 80
switching on
. . . . . . . . . . . . . . . . . . . 80
Head restraints . . . . . . . . . . . . . . . . . 72
removing
. . . . . . . . . . . . . . . . . . . . . 73
Headlamp flasher
. . . . . . . . . . . . 77
, 78
Headlamps
bulbs
. . . . . . . . . . . . . . . . . . . . . . . 307
cleaning . . . . . . . . . . . . . . . . . . . . . 244
cleaning system
. . . . . . . . . . . 127
, 193
indicator lamp
. . . . . . . . . . . . . . . 280
fogged-up
. . . . . . . . . . . . . . . . . . . . 257
malfunctions . . . . . . . . . . . . . . . . . 257
Heated
rear window . . . . . . . . . . . . . . . . . . 128
GH F

387 Index
Removing/installing the floor covering
in the driver’s footwell
. . . . . . . . . . 336
Reserve warning indicator (fuel)
. . 276
Residual heat mode
. . . . . . . . . . . . 134
problems
. . . . . . . . . . . . . . . . . . . . 267
Restraint system
. . . . . . . . . . . . . . . 24
airbags
. . . . . . . . . . . . . . . . . . . . . . . 25
belt force limiters
. . . . . . . . . . . . . . 30
child restraint systems
. . . . . . . . . . 37
display message
. . . . . . . . . . . . . . 288
emergency tensioning retractor
. . . 30
front airbags
. . . . . . . . . . . . . . . . . . 33
malfunction . . . . . . . . . . . . . . . . . . 272
seat belt
. . . . . . . . . . . . . . . . . . . . . . 25
thorax sidebag
. . . . . . . . . . . . . . . . . 34
windowbags
. . . . . . . . . . . . . . . . . . . 35
Reverse lamp . . . . . . . . . . . . . . . . . 309
changing bulbs . . . . . . . . . . . . . . . 310
Reverse warning feature
. . . . . . . . 153
Rims
. . . . . . . . . . . . . . . . . . . . . . . . . 230
Roll-back warning
see Parktronic
Roof load
. . . . . . . . . . . . . . . . . . . . . 372
Roof rack . . . . . . . . . . . . . . . . . . . . . 162
Roof ventilator
. . . . . . . . . . . . . . . . 146
S
Seat
adjusting
. . . . . . . . . . . . . . . . . . . . . 68
folding rear bench seat
. . . . . . . . . . 74
folding seat
. . . . . . . . . . . . . . . . . . . 74
fore-and-aft adjustment
. . . . . . . . . . 69
heating
. . . . . . . . . . . . . . . . . . . . . . . 73
malfunction
. . . . . . . . . . . . . . . . 266
height
. . . . . . . . . . . . . . . . . . . . . . . . 69
suspension
. . . . . . . . . . . . . . . . . . . . 70
swivelling . . . . . . . . . . . . . . . . . . . . . 70
vertical lock . . . . . . . . . . . . . . . . . . . 70
Seat belt
. . . . . . . . . . . . . . . . . . . . . . . 25
adjusting height
. . . . . . . . . . . . . . . . 27
cleaning
. . . . . . . . . . . . . . . . . . . . . 246
telltale
. . . . . . . . . . . . . . . . . . . . . . 280
wearing . . . . . . . . . . . . . . . . . . . . . . 27
Seat heating
switching on
. . . . . . . . . . . . . . . . . . . 73
Seating capacity
. . . . . . . . . . . . . . . 206
Securing a load
. . . . . . . . . . . . . . . . 158
Securing tensioning straps
. . . . . . 158
Selector lever
lock
. . . . . . . . . . . . . . . . . . . . 111
, 121
Service
calling up the due date
vehicles with steering wheel buttons
. . . . . . . . . . . . . . . . . . . . 239
vehicles without steering wheel but-
tons
. . . . . . . . . . . . . . . . . . . . . . 240
indicator . . . . . . . . . . . . . . . . . . . . . 238
Service information
. . . . . . . . . . . . . . 5
Service life
tires
. . . . . . . . . . . . . . . . . . . . . . . . 203
Service products
. . . . . . . . . . . 187
, 237
capacities
. . . . . . . . . . . . . . . . . . . . 365
coolants, lubricants, etc.
. . . . . . . . 362
diesel
. . . . . . . . . . . . . . . . . . . . . . . 359
engine oils
. . . . . . . . . . . . . . . . . . . 356
fuels
. . . . . . . . . . . . . . . . . . . . . . . . 358
gasoline . . . . . . . . . . . . . . . . . . . . . 358
notes
. . . . . . . . . . . . . . . . . . . . . . . 355
windshield washer fluid
. . . . . . . . . 193
Setting the blower speed . . . . . . . . 133
Setting the date
vehicles with steering wheel
buttons
. . . . . . . . . . . . . . . . . . . . . . 102
vehicles without steering wheel
buttons . . . . . . . . . . . . . . . . . . . . . . . 88
Settings
resetting all (vehicles with steering
wheel buttons)
. . . . . . . . . . . . . . . . . 96
Shift range
automatic transmission
. . . . . . . . . 123
display
. . . . . . . . . . . . . . . . . . . . . . 121
S

391 Index
closing
. . . . . . . . . . . . . . . . . . . . . . . 52
correct use
. . . . . . . . . . . . . . . . . . . . 7
data cards . . . . . . . . . . . . . . . . . . . 373
identification number
. . . . . . . . . . 373
leaving in storage
. . . . . . . . . . . . . 265
locking with key
. . . . . . . . . . . . . . . . 55
locking/unlocking centrally
. . . . . . . 64
opening
. . . . . . . . . . . . . . . . . . . . . . 52
with remote control
. . . . . . . . . . . 54
with the key
. . . . . . . . . . . . . . . . . 54
registering
. . . . . . . . . . . . . . . . . . . . . 5
towing
. . . . . . . . . . . . . . . . . . . . . . 342
towing out
. . . . . . . . . . . . . . . . . . . 343
tow-starting . . . . . . . . . . . . . . . . . . 341
transporting . . . . . . . . . . . . . . . . . . 344
Vehicle alteration
. . . . . . . . . . . . . . . . 6
Vehicle capacity weight
. . . . . . . . . 231
Vehicle identification plates
. . . . . 373
Vehicle loading
load limit
. . . . . . . . . . . . . . . . . . . . 206
loading terminology
. . . . . . . . . . . . 228
terminology
. . . . . . . . . . . . . . . . . . 228
Vehicle maximum load
on the tire
. . . . . . . . . . . . . . . . . . . . 231
Vehicle safety certification label
. 373
Vehicle tool kit
. . . . . . . . . . . . . . . . 300
Vehicle/engine emission label
. . . 375
W
Warning labels
. . . . . . . . . . . . . . . . . . 8
Warning lamp
ESP
®/ASR
. . . . . . . . . . . . . 43
, 44
, 268
warning lamp
. . . . . . . . . . . . . . . . . 299
Warning triangle . . . . . . . . . . . . . . . 299
Warranty information
. . . . . . . . . . . . . 5
Washer fluid
. . . . . . . . . . . . . . . . . . 127
adding
. . . . . . . . . . . . . . . . . . . . . . 193
Water separator
draining the fuel filter
. . . . . . . . . . 317
Wheel
. . . . . . . . . . . . . . . . . . . . . . . . 117
changing
. . . . . . . . . . . . . . . . . . . . 320
Wheel nuts/wheel bolts
retightening . . . . . . . . . . . . . . . . . . 324
tightening torque
. . . . . . . . . . . . . . 324
Wheel, tires and
. . . . . . . . . . . . . . . 199
Windows
cleaning the rear window
. . . . . . . . 244
cleaning the side windows . . . . . . . 244
cleaning the windshield
. . . . . . . . . 243
fogged-up
. . . . . . . . . . . . . . . . . . . . 134
power windows
. . . . . . . . . . . . . . . 144
washer fluid
. . . . . . . . . . . . . . . . . . 127Windshield
cleaning
. . . . . . . . . . . . . . . . . . . . . 243
heating . . . . . . . . . . . . . . . . . . 127
, 134
malfunction
. . . . . . . . . . . . . . . . 266
Windshield heating
. . . . . . . . . . . . . 127
Windshield washer fluid
display message
. . . . . . . . . . 287
, 298
wiping with
. . . . . . . . . . . . . . . . . . . 127
Windshield washer system
. . . . . . 193
indicator lamp
. . . . . . . . . . . . . . . . 280
rain sensor
. . . . . . . . . . . . . . . . . . . 126
Windshield wipers
. . . . . . . . . . . . . 126
cleaning
. . . . . . . . . . . . . . . . . . . . . 243
intermittent wipe
. . . . . . . . . . . . . . 126
malfunctions
. . . . . . . . . . . . . . . . . 258
rain sensor
. . . . . . . . . . . . . . . 126
, 127
setting the sensitivity (vehicles with
steering wheel buttons)
. . . . . . . 105
rear window wiper
. . . . . . . . . . . . . 127
replacing the wiper blades
. . . . . . . 319
windshield washer fluid
. . . . . . . . . 127
Winter driving
. . . . . . . . . . . . . 234
, 235
snow chains
. . . . . . . . . . . . . . . . . . 236
Winter operation
tires
. . . . . . . . . . . . . . . . . . . . . . . . 234
Wiper blades
. . . . . . . . . . . . . . . . . . 319
Working on the vehicle
. . . . . . . . . 124
W