2007 DODGE RAM 1500 GAS brakes

Brake System
Power Disc Brakes (front and rear)
Disc brakes do not require adjustment; however, several
hard stops during the break-in period are recommended
to seat the linings and wear off any foreign material.
Brake And Power Steering Hoses
When the vehicle is serviced for scheduled maintenance,
inspect surface of hoses and nylon tubing for evidence of
heat and mechanical damage. Hard and brittle rubber,
cracking, tears, cuts, abrasion, and excessive swelling
indicate deterioration of the rubber. Particular attention
should be made to examining those hose surfaces nearest
to high heat sources, such as the exhaust manifold.
Insure nylon tubing in these areas has not melted or
collapsed.Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
NOTE:Often, fluid such as oil, power steering fluid,
and brake fluid are used during assembly plant opera-
tions to facilitate the assembly of hoses to couplings.
Therefore, oil wetness at the hose-coupling area is not
necessarily an indication of leakage. Actual dripping of
hot fluid when systems are under pressure (during
vehicle operation), should be noted before hose is re-
placed based on leakage.
NOTE:Inspection of brake hoses should be performed
whenever the brake system is serviced and every engine
oil change. Inspect hydraulic brake hoses for surface
cracking, scuffing, or worn spots. If there is any evidence
of cracking, scuffing, or worn spots, the hose should be
replaced immediately! Eventual deterioration of the hose
can take place resulting in a possibility of a burst failure.
MAINTAINING YOUR VEHICLE 475
7

WARNING!
Worn brake hoses can burst and cause brake failure.
You could have an accident. If you see any signs of
cracking, scuffing, or worn spots, have the brake
hoses replaced immediately.
Brake Master Cylinder — Brake Fluid Level Check
The fluid level of the master cylinder should be checked
when performing under the hood service, or immedi-
ately if the brake system warning lamp indicates system
failure.
The brake master cylinder has a translucent plastic
reservoir. On the outboard side of the reservoir, there is a
“MAX” dot and an “MIN” dot. The fluid level must be
kept within these two dots. Do not add fluid above the
MAX mark, because leakage may occur at the cap.With disc brakes the fluid level can be expected to fall as
the brake linings wear. However, an unexpected drop in
fluid level may be caused by a leak and a system check
should be conducted.
Refer to Fluids, Lubricants and Genuine Parts for the
correct Fluid type.WARNING!
Use of a brake fluid that may have a lower initial
boiling point, or is unidentified as to specification,
may result in sudden brake failure during hard
prolonged braking. You could have an accident.
476 MAINTAINING YOUR VEHICLE

Ball Joints............................. 464
Battery............................... 461
Emergency Starting..................... 438
Saving Feature (Protection)............... 166
Bearings.............................. 482
Belts, Drive............................ 458
Belts, Seat............................34,73
Body Mechanism Lubrication............... 466
B-Pillar Location........................ 362
Brake Assist System...................... 346
Brake Control System, Electronic............. 344
Brake Fluid.........................476,515
Brake System........................340,475
Anti-Lock (ABS)....................341,344
Disc Brakes.......................... 475
Fluid Check.......................... 476
Hoses.............................. 475
Master Cylinder....................... 476
Parking............................. 338Warning Light........................ 232
Break-In Recommendations, New Vehicle....... 112
Bulb Replacement....................... 499
Bulbs, Light............................ 498
Cab Top Clearance Lights.................. 507
Calibration, Compass..................... 184
Camper............................... 215
Capacities, Fluid........................ 512
Caps, Filler
Oil (Engine).......................... 456
Power Steering........................ 464
Radiator (Coolant Pressure)............... 471
Car Washes............................ 488
Carbon Monoxide Warning...........217,218,383
Cargo Light............................ 168
Cassette Tape and Player Maintenance......... 281
Catalytic Converter...................... 459
CD (Compact Disc) Player............238,246,260
INDEX 551
10

Cruise Control (Speed Control).............. 175
Cup Holder............................ 199
Customer Assistance..................... 542
Data Recorder, Event....................58,97
Daytime Running Lights................... 167
Dealer Service.......................... 453
Defroster, Rear Window................124,209
Defroster, Windshield...............219,285,287
Delay (Intermittent) Wipers................. 171
Differential, Limited-Slip.................. 336
Dipsticks
Automatic Transmission................. 480
Power Steering........................ 464
Disc Brakes............................ 475
Disposal
Antifreeze (Engine Coolant)............... 472
Door Ajar............................. 236
Door Locks............................. 26Door Opener, Garage..................... 186
Drive Belts............................ 458
Drive Shaft Universal Joints................ 465
Dual Rear Wheels.....................379,434
DVD Player (Video Entertainment System)...... 275
E-85 Fuel............................. 386
Electric Rear Window Defrost............124,209
Electrical Power Outlets................... 196
Electronic Brake Control System............. 344
Electronic Speed Control (Cruise Control)...... 175
Electronic Stability Program (ESP).........234,352
Electronically Shifted Transfer Case........321,329
Emergency Brake........................ 338
Emergency, In Case of
Freeing Vehicle When Stuck............... 442
Hazard Warning Flasher................. 420
Jacking............................. 427
Jump Starting......................... 438
INDEX 553
10