2007 DODGE CHARGER power steering

Refrigerant Recovery and Recycling
R-134a Air Conditioning Refrigerant is a hydrofluorocar-
bon (HFC) that is endorsed by the Environmental Pro-
tection Agency and is an ozone-saving product. How-
ever, the manufacturer recommends that air conditioning
service be performed by dealers or other service facilities
using recovery and recycling equipment.
NOTE:Use only manufacturer approved A/C System
Sealers, Stop Leak Products, Seal Conditioners, Compres-
sor Oil, and Refrigerants.
A/C Air Filter — If Equipped
The filter is located in the fresh air inlet under the hood,
behind a removable panel in the cowl on the passenger
side of the vehicle, next to the windshield wipers. When
installing a new filter, ensure its proper orientation. To
replace the filter, remove the access door in the cowl
screen by pressing the retaining clips. Slide the lid on the
filter adapter forward and down and remove used filter.
Install new filter with arrows pointing in the direction of
airflow, which is toward the rear of the vehicle (text and
arrows on the filter indicate this).Refer to the “Maintenance Schedule” in this manual for
the recommended air conditioning filter replacement
intervals.
Power Steering — Fluid Check
Checking the power steering fluid level at a defined
service interval is not required. The fluid should only be
checked if a leak is suspected, abnormal noises are
apparent, and/or the system is not functioning as antici-
pated. Coordinate inspection efforts through a certified
DaimlerChrysler Dealership.
WARNING!
Fluid level should be checked on a level surface and
with the engine off to prevent injury from moving
parts and to insure accurate fluid level reading. Do
not overfill. Use only manufacturer’s recommended
power steering fluid.
MAINTAINING YOUR VEHICLE 305
7

Brake And Power Steering Hoses
When the vehicle is serviced for scheduled maintenance,
inspect surface of hoses and nylon tubing for evidence of
heat and mechanical damage. Hard and brittle rubber,
cracking, tears, cuts, abrasion, and excessive swelling
indicate deterioration of the rubber. Particular attention
should be made to examining those hose surfaces nearest
to high heat sources, such as the exhaust manifold.
Insure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
NOTE:
•
Often, fluid such as oil, power steering fluid, and
brake fluid are used during assembly plant operations
to facilitate the assembly of hoses to couplings. There-
fore, oil wetness at the hose-coupling area is not
necessarily an indication of leakage. Actual dripping
of hot fluid when systems are under pressure (during
vehicle operation), should be noted before a hose is
replaced based on leakage.
•Inspect the brake hoses whenever the brake system is
serviced and at every engine oil change. Inspect hy-
draulic brake hoses for surface cracking, scuffing, or
worn spots. If there is any evidence of cracking,
scuffing, or worn spots, the hose should be replaced
immediately! Eventual deterioration of the hose can
take place resulting in a possibility of a burst failure.
WARNING!
Worn brake hoses can burst and cause brake failure.
You could have an accident. If you see any signs of
cracking, scuffing, or worn spots, have the brake
hoses replaced immediately.
314 MAINTAINING YOUR VEHICLE

Cavity Car-
tridge
FuseMini
FuseDescription
17 — 20 Amp
YellowCluster
18 — 20 Amp
YellowSelectable Power Outlet
19 — 10 Amp
RedStop Lights
20———
21———
22———
23———
24———
25———
26———
27 — 10 Amp
RedAirbag/Airbag Control
Module (ACM)
28 — 10 Amp
RedCurtain Airbag - if
equippedCavity Car-
tridge
FuseMini
FuseDescription
29 — 5 Amp
OrangeAnti-lock Brakes Module
- if equipped/Cluster/
Front Control Module
(FCM)/Powertrain Con-
trol Module (PCM)/
Sentry Key Remote Key-
less Entry/Stop Lights
30 — 10 Amp
RedDoor Modules/Power
Mirrors - if equipped/
Steering Control Module
31———
32———
33———
34———
MAINTAINING YOUR VEHICLE 327
7

Chassis
Component Fluids, Lubricants and Genuine Parts
Automatic Transmission MoparATF+4 Automatic Transmission Fluid.
Brake Master Cylinder MoparDOT 3, SAE J1703 should be used. If DOT 3, SAE J1703 brake
fluid is not available, then DOT 4 is acceptable. Use only recommended
brake fluids.
Front Axle API Certified GL-5 SAE 75W90 Synthetic Gear Lubricant or equivalent.
Power Steering Reservoir MoparPower Steering Fluid + 4, MoparATF+4 Automatic Transmission
Fluid.
Rear Axle API Certified GL-5 SAE 75W140 Synthetic Gear Lubricant or equivalent.
Transfer Case MoparTransfer Case Lubricant LX, P/N 05170055AA, or equivalent.
MAINTAINING YOUR VEHICLE 339
7

Enhanced Accident Response Feature......... 48
Ethanol.............................. 251
Event Data Recorder..................... 49
Exhaust Gas Caution...............60,253,308
Exhaust System......................60,307
Exterior Folding Mirrors.................. 67
Exterior Lighting........................ 95
Filters
Air Cleaner.......................... 300
Air Conditioning..................188,305
Engine Fuel......................... 301
Engine Oil.......................300,338
Engine Oil Disposal................... 299
Flashers
Hazard Warning...................... 272
Turn Signal........................98,131
Flash-To-Pass........................... 98
Flat Tire Changing...................... 274
Flooded Engine Starting.................. 195
Floor Console.......................... 120
Fluid Capacities........................ 337
Fluid Leaks............................ 61Fluid Level Checks
Brake.............................. 315
Cooling System....................... 308
Engine Oil.......................295,296
Power Steering....................... 305
Fluids............................... 338
Fluids, Lubricants and Genuine Parts........ 338
Fog Lights..........................97,133
Folding Rear Seat....................... 93
Freeing A Stuck Vehicle.................. 284
Front Suspension Ball Joints............... 306
Front Wheel Bearings.................... 318
Fuel................................. 250
Adding............................. 254
Clean Air........................... 251
Ethanol............................. 251
Filler Cap (Gas Cap)................... 254
Filter.............................. 301
Gasoline............................ 250
Gauge............................. 129
Hoses.............................. 313
Methanol........................... 251
Octane Rating.....................250,338
374 INDEX

Materials Added to.................... 299
Recommendation..................297,337
Synthetic........................... 299
Viscosity.........................298,337
Onboard Diagnostic System............292,293
Opener, Garage Door (HomeLink) ......... 109
Operating Precautions................... 292
Outside Rearview Mirrors................. 67
Overdrive............................ 202
Overhead Console...................... 108
Overheating, Engine..................130,272
Owner’s Manual (Operator Manual)......... 365
Panic Alarm........................... 20
Parking Brake......................... 213
Parking On Hill........................ 213
Passing Light........................... 98
Pedals, Adjustable...................... 104
Personal Settings....................... 146
Pets.................................. 58
Phone, Cellular......................... 69
Phone, Hands-Free (UConnect™)............ 69
Placard, Tire and Loading Information....... 228Power
Brakes............................. 214
Distribution Center (Fuses).............. 323
Door Locks.......................... 24
Mirrors............................. 68
Outlet (Auxiliary Electrical Outlet)........ 117
Seats............................... 89
Steering.........................217,305
Steering, Checking.................... 305
Sunroof............................ 114
Windows............................ 28
Pregnant Women and Seat Belts............. 41
Preparation for Jacking................... 274
Pretensioners
Seat Belts............................ 39
Programmable Electronic Features..... 110,113,146
Programming Transmitters
(Remote Keyless Entry)..............21,110,113
Radial Ply Tires........................ 235
Radiator Cap (Coolant Pressure Cap)........ 310
Radio Broadcast Signals.................. 149
Radio, Navigation...................... 168
INDEX 379
10

Untwisting Procedure................... 39
Seats................................. 88
Adjustment.......................... 88
Heated.............................. 91
Lumbar Support....................... 90
Power.............................. 89
Rear Folding......................... 93
Reclining............................ 90
Security Alarm (Theft Alarm)............15,135
Selection of Coolant (Antifreeze).........309,338
Self-Sealing Tires....................... 240
Sentry Key (Immobilizer).................. 13
Service Assistance...................... 362
Service Contract........................ 364
Service Engine Soon Light
(Malfunction Indicator).................. 136
Service Manuals........................ 365
Setting the Clock.................152,158,169
Settings, Personal....................... 146
Shifting.............................. 197
Automatic Transmission..........197,200,205
Shoulder Belt Upper Anchorage............. 38
Shoulder Belts.......................... 34Side Airbag............................ 47
Signals, Turn........................98,131
Slippery Surfaces, Driving On............. 212
Snow Chains (Tire Chains)................ 240
Snow Tires............................ 241
Spare Tire.......................235,236,275
Spark Plugs........................... 300
Speed Control (Cruise Control)............. 105
Speedometer.......................... 129
Starting.............................. 194
Automatic Transmission................ 195
Engine Fails to Start................... 195
Starting and Operating................... 194
Starting Procedures..................... 194
Steering
Column Controls...................... 98
Linkage............................ 306
Power...........................217,305
Tilt Column......................... 103
Wheel, Tilt.......................... 103
Steering Wheel Mounted Sound
System Controls........................ 176
Storage...........................120,329
INDEX 381
10