2007 DODGE CALIBER fuel system

In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe
and abnormal catalyst overheating. If this occurs, stop
the vehicle, turn off the engine and allow it to cool.
Service, including a tune up to manufacturers specifica-
tions, should be obtained immediately.
To minimize the possibility of catalyst damage:
•Do not shut off the engine or interrupt the ignition
when the transaxle is in gear and the vehicle is in
motion.
•Do not try to start the engine by pushing or towing the
vehicle.
•Do not idle the engine with any spark plug wires
disconnected for prolonged period.
Crankcase Emission Control System
Proper operation of this system depends on freedom
from sticking or plugging due to deposits. As vehicle
mileage builds up, the PCV valve and passages may
accumulate deposits. If a valve is not working properly,
replace it with a new valve. DO NOT ATTEMPT TO
CLEAN THE OLD PCV VALVE!Check ventilation hose for indication of damage or
plugging deposits. Replace if necessary.
Fuel Filter
A plugged fuel filter can cause hard starting or limit the
speed at which a vehicle can be driven. Should an
excessive amount of dirt accumulate in the fuel tank,
frequent filter replacement may be necessary. The fuel
filters are located inside the fuel tank. See your dealer for
service.
Air Cleaner Element (Filter)
Under normal driving conditions, replace the filter at the
intervals shown on Schedule “A”. If, however, you drive
the vehicle frequently under dusty or severe conditions,
the filter element should be inspected periodically and
replaced if necessary at the intervals shown on Schedule
“B”.
288 MAINTAINING YOUR VEHICLE

•Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean, also.
•Do not change the thermostat for summer or winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory coolant performance, poor gas
mileage, and increased emissions.
Hoses And Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber
Pay particular attention to the hoses nearest to high heat
sources such as the exhaust manifold. Inspect hose rout-
ing to be sure hoses do not touch any heat source or
moving component that may cause heat damage or
mechanical wear.Insure nylon tubing in these areas has not melted or
collapsed
Inspect all hose connections such as clamps and cou-
plings to make sure the are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of degradation that could cause failure.
Fuel System Connections
Electronic Fuel Injection high pressure fuel systems are
designed with tubes and special connects, connections
and clamps which have unique material characteristics to
provide adequate sealing and resist attack by deterio-
rated gasoline.
You are urged to use only the manufactures-specified
tubes, connections and clamps, or their equivalent in
material and specification, in any fuel system servicing.
Brake System
In order to assure brake system performance, all brake
system components should be inspected periodically.
Suggested service intervals can be found in the Mainte-
nance Section.
298 MAINTAINING YOUR VEHICLE

FLUIDS AND CAPACITIES
U.S. Metric
Fuel (Approximate)13.5 Gallons 51.0 Liters
Engine Oil-With Filter
All Gasoline Engines (Use API Certified SAE 5W-20 Engine
Oil.)4.5 Quarts 4.26 Liters
Cooling System *
MoparAntifreeze/Coolant 5 Year/100,000 Miles Formula), or
equivalent.7.2 Quarts 6.8 Liters
* Includes heater and coolant recovery bottle filled to MAX level.
316 MAINTAINING YOUR VEHICLE

ABS (Anti-Lock Brake System)............. 220
Accelerator Pedal....................... 213
Adding Engine Coolant (Antifreeze)......... 295
Adding Fuel.......................... 252
Adding Washer Fluid.................108,133
Additives, Fuel........................ 250
Air Cleaner, Engine
(Engine Air Cleaner Filter)................ 288
Air Conditioner Maintenance.............. 290
Air Conditioning Controls................ 198
Air Conditioning, Operating Tips........... 203
Air Conditioning Refrigerant...........290,291
Air Conditioning System..............198,290
Air Pressure, Tires...................... 234
Airbag................................ 39
Airbag Deployment...................... 49
Airbag Light...................... 52,62,145
Airbag Maintenance...................... 51
Airbag, Side........................... 47
Alarm System (Security Alarm).......... 24,145
Alignment and Balance.................. 240
All Wheel Drive (AWD).................. 217
Alterations/Modifications, Vehicle............ 6Antenna, Satellite Radio.................. 195
Antifreeze (Engine Coolant).........294,316,317
Capacities........................... 316
Disposal............................ 296
Anti-Lock Brake System (ABS).......... 117,220
Anti-Theft Security Alarm (Theft Alarm)...... 24
Appearance Care....................... 303
Automatic Door Locks.................. 16,17
Automatic Transaxle........... 9,208,210,267,301
Fluid Level Check..................... 301
Interlock System.................... 14,212
Overheating......................... 267
Selection Of Lubricant................. 301
Shifting............................ 212
Special Additives..................... 301
Autostick ............................. 214
BallJoints ............................ 291
Battery ............................... 289
Keyless Transmitter Replacement (RKE)..... 23
Belts,Drive ........................... 286
Beverage Cooler........................ 134
Body Mechanism Lubrication.............. 292
346 INDEX

B-Pillar Location....................... 229
Brake Assist System..................... 118
Brake Control System, Electronic........... 118
BrakeFluid ........................... 318
Brake, Parking......................... 218
Brake System.......................219,298
Anti-Lock (ABS)................... 117,220
Hoses.............................. 299
Master Cylinder...................... 300
Parking............................ 218
Warning Light....................... 150
Brakes............................219,298
Brake/Transmission Interlock.............. 211
Break-In Recommendations, New Vehicle...... 61
Bulb Replacement....................310,311
Bulbs,Light ........................... 310
Calibration, Compass.................... 160
Capacities, Antifreeze (Engine Coolant)...... 316
Capacities, Fluid....................... 316
Caps, Filler
Fuel............................... 252
Oil (Engine)......................279,285Car Washes........................... 304
Carbon Monoxide Warning............... 251
Cargo Area Cover...................... 130
Cargo Area Features..................... 128
Cargo Compartment
Light .............................. 128
Luggage Carrier...................... 134
CargoLight ........................... 128
Cargo Load Floor....................... 130
Cargo Tie-Downs....................... 130
Carrier, Luggage....................... 134
Catalytic Converter..................... 287
Caution, Exhaust Gas..................... 61
CD (Compact Disc) Player..........162,169,180
CD (Compact Disc) Player Maintenance...... 197
Cellular Phone....................... 72,198
Center High Mounted Stop Light........... 315
Chains, Tire........................... 247
Changing A Flat Tire.................... 268
Chart,TireSizing ....................... 226
Check Engine Light
(MalfunctionIndicatorLight) .............. 281
Child Restraint......................... 54
INDEX 347
10

Engine Oil.......................... 286
Door Locks............................ 14
Door Locks, Automatic................... 16
Door Opener, Garage.................... 112
Downshifting.......................... 217
DriveBelts ............................ 286
Driver’s Seat Back Tilt.................... 96
Driving
On Slippery Surfaces.................. 224
Economy............................. 213
Electric Remote Mirrors................... 70
Electrical Power Outlets.................. 124
Electronic Brake Control System............ 118
Brake Assist System................... 118
Electronic Stability Program............. 119
Traction Control System................ 118
Electronic Speed Control (Cruise Control)..... 109
Electronic Stability Program (ESP).......... 119
Electronic Vehicle Information
Center (EVIC)......................... 152
Emergency, In Case of
Jacking............................. 268Jump Starting........................ 272
Towing ............................. 275
Emission Control System Maintenance....281,320
Engine............................... 279
Break-In Recommendations............... 61
Checking Oil Level.................... 283
Cooling ............................ 294
Exhaust Gas Caution.................. 251
Fuel Requirements.................... 248
Jump Starting........................ 272
Oil ..........................283,316,317
Oil Change Interval................... 284
Oil Filler Cap.....................279,285
Oil Filter............................ 317
OilSelection ......................... 285
Oil Synthetic......................... 285
Overheating......................... 266
Temperature Gauge................... 144
Enhanced Accident Response Feature......... 50
Event Data Recorder..................... 52
Exhaust Gas Caution............. 27,61,251,293
Exhaust System........................ 293
INDEX 349
10

Fabric Care........................... 305
Filler Location Fuel..................... 144
Filters
Air Cleaner.......................... 288
Engine Fuel......................... 288
Engine Oil.......................286,317
Flashers.............................. 266
Hazard Warning...................... 266
Turn Signal.......................... 312
Flat Tire Stowage....................... 271
Flooded Engine Starting.................. 209
Fluid, Brake........................... 318
Fluid Capacities........................ 316
Fluid Leaks............................ 63
Fluid Level Checks
Automatic Transaxle................... 301
Fluids ............................... 317
Fluids, Lubricants and Genuine Parts........ 317
FogLights ......................104,149,311
Fog Lights, Rear........................ 152
Folding Rear Seat....................... 99
Folding Rear Seat (Sedan)................. 99
FreeingAStuckVehicle .................. 274Fuel..............................248,317
Adding............................. 252
Additives ........................... 250
Capacity............................ 316
CleanAir ........................... 249
Filler Cap (Gas Cap)................144,252
Filler Door (Gas Cap).................. 144
Filter.............................. 288
Gasoline............................ 248
Gauge............................. 144
Hoses.............................. 298
Light .............................. 145
OctaneRating ........................ 248
Requirements........................ 248
System Hoses........................ 298
Tank Capacity........................ 316
Fuel System Caution.................... 254
Fueling .............................. 252
Fuses................................ 307
Garage Door Opener (HomeLink) .......... 112
Gas Cap (Fuel Filler Cap)...........252,253,280
Gasoline, Clean Air..................... 249
350 INDEX

Intermittent Wipers (Delay Wipers)......... 108
Introduction............................ 4
Jack Location.......................... 268
Jack Operation......................268,269
Jacking Instructions..................... 269
Jump Starting......................... 272
Key, Programming....................... 12
Key, Replacement....................... 12
Key, Sentry (Immobilizer).................. 11
Key-In Reminder........................ 10
Keyless Entry System (Sedan).............. 19
Keys.................................. 9
Lane Change and Turn Signals..........149,312
Lap/Shoulder Belts...................... 29
Latches
Hood.............................. 101
Lead Free Gasoline...................... 248
LifeofTires ........................... 239
Liftgate (Sedan)......................... 26
Liftgate Window Wiper/Washer............ 132LightBulbs ........................... 310
Lights ............................. 63,102
Airbag ......................... 52,62,145
Back-Up............................ 312
BrakeWarning ....................... 150
Bulb Replacement..................... 311
Cargo .............................. 128
Center Mounted Stop.................. 315
Daytime Running..................... 106
Dimmer Switch, Headlight.............. 103
Electronic Stability Program
(ESP) Indicator.................... 119,121
Engine Temperature Warning............ 146
Fog ..........................104,149,311
Headlight Switch..................... 103
Headlights.......................... 103
High Beam Indicator................... 150
Instrument Cluster.................... 103
License............................. 314
Lights On Reminder................... 104
Low Fuel........................... 145
Malfunction Indicator (Check Engine)...... 148
Map Reading........................ 102
352 INDEX