2007 Alfa Romeo 156 service interval

GETTING TO KNOW YOUR CAR13
Self-diagnosis and monitoring
of doors and bonnet/boot
If, after the alarm has been activated, a
second acoustic signal is heard, check that
all the doors and bonnet/boot are closed
properly and engage the system once again.
On the other if a door or bonnet/boot lid
is not correctly closed it will not be controlled
by the system.
If the control signal is repeated when the
doors and bonnet/boot are closed properly
this means that the self-diagnosis function
has detected a system operating fault, in
which case it is necessary to contact Alfa
Romeo Authorized Services.
DEACTIVATING THE ALARMTo deactivate the alarm, press the button
on the key with remote control. The system
performs the following (with the exception
of some markets):
– the direction indicators turn on twice
briefly
– two beeps are sounded briefly by the
siren
– the doors are released.
WARNINGIf the led (A-fig. 9) in the
car stays on when the system has been de-
activated, (maximum of 2 minutes or until
the ignition key is moved to MAR) the fol-
lowing should be borne in mind:
– if the led stays on permanently, it means
that the remote control batteries are flat and
need replacing;– if the led continues to flash, but at dif-
ferent intervals than normal, it means that
attempts to steal the car have been made,
counting the number of flashes it is also pos-
sible to identify the type of attempt:
1 flash: right front door
2 flashes: left front door
3 flashes: right rear door
4 flashes: left rear door
5 flashes: volumetric sensors
6 flashes: bonnet
7 flashes: boot
8 flashes: tampering with car starting
cables
9 flashes: tampering with battery or
cutting emergency key ca-
bles
10 flashes: at least three causes of
alarm.

GETTING TO KNOW YOUR CAR69
The Programmed Maintenance Schedule includes car maintenance every 20,000 km
(or 12,000 miles) or one year; this is shown automatically, with the ignition key at
MAR
,
starting from 2,000 km (or 1,240 miles) or 30 day from this deadline and it is shown again
every 200 km (or 124 miles) or 3 days. When a programmed maintenance interval
(“coupon”) is near to come, turning the ignition key to
MAR
, will display the message
SCHEDULED SERVICE WITHIN followed by the number of kilometers, days or miles to go before
vehicle maintenance. The PROGRAMMED MAINTENANCE message is displayed in km,
mi or days, according to the approaching service interval. At the very moment the value
of 0 km, 0 miles or 0 days is reached, the display will show, every time the ignition key
is turned to
MAR
, the message SCHEDULED SERVICE EXPIRED, followed by the number
of kilometers, miles or days. In this case, to reset this visual information contact
Authorised Alfa Romeo Services.
continued from previous page

GETTING TO KNOW YOUR CAR83
The Programmed Maintenance Schedule includes vehicle maintenance
every 20,000 km (or 12,000 miles) or one year; this is shown
automatically, with the ignition key at
MAR
, starting from 2,000
km (or 1,240 miles) or 30 day from this deadline and it is shown
again every 200 km (or 124 miles) or 3 days. When a programmed maintenance interval
(“coupon”) is near to come, turning the ignition key to
MAR
, will display the message
SCHEDULED SERVICE WITHIN followed by the number of kilometers, days or miles to go
before vehicle maintenance. The PROGRAMMED MAINTENANCE message is displayed in km,
mi or days, according to the approaching service interval. At the very moment the value of 0
km, 0 miles or 0 days is reached, the display will show, every time the ignition key is turned
to
MAR
, the message SCHEDULED SERVICE EXPIRED, followed by the number of
kilometers, miles or days. In this case, to reset this visual information contact Authorized Alfa
Romeo Services.
WARNINGProducts shown in the SERVICE screen and to be used for scheduled maintenance could be subject to modifications. Refer to
paragraph “Fluids and lubricants” in section “Technical specifications”.

GETTING TO KNOW YOUR CAR
107
Warning light
on the dialMessage
on display
SELESPEED GEARBOX FAILURETurning the ignition key to MAR, the warning light on the cluster shall come on and then go off af-
ter about 4 seconds. If the warning light stays on, it indicates that a fault has been detected in the Se-
lespeed gearbox; at the same time, the buzzer beeps intermittently for 4 seconds to draw the atten-
tion of the driver. Contact Alfa Romeo Authorised Services as soon as possible to remove the fault.Q-SYSTEM AUTOMATIC GEARBOX FAILURETurning the ignition key to MAR, the warning light on the cluster shall come on and then go off
after about 4 seconds. If the warning light stays on or turns on when travelling, it indicates over-
heated gearbox oil (glowing steadily) or a gearbox fault (flashing).
Warning light glowing steadily: it indicates that the gearbox oil has reached the maxi-
mum established temperature.
To make oil cooling down, stop the car, move the lever to Por Nand let the engine idle until the
warning light goes out. Resume driving without demanding high performance from the engine. If
the warning light comes on again, it is necessary to stop again with the engine idling until it goes
out again. If the interval between one lighting up of the warning light and next is below 15 minutes,
you are advised to stop the car, turn the engine off and wait for the engine-gearbox unit to cool down
completely. Contact Alfa Romeo Authorised Services as soon as possible.
Warning light flashing: it indicates a fault in the automatic gearbox.
The automatic control system provides an emergency programme. Under these circumstances,
you are advised to stop the car and turn the engine off; in fact, the next time the engine is started,
the self-diagnostic system could cut off the fault which will however be memorised. Conversely, if
the fault remains (warning light flashing), it is necessary to select the gears manually as if driving
a car with mechanical gearbox, bearing in mind that the only two speeds available are the 2
ndand
4
thgear. Contact Alfa Romeo Authorised Services as soon as possible.
t
t

GETTING TO KNOW YOUR CAR
134
This function is timed and switches off au-
tomatically after 20 minutes, or pressing the
button again; the function is also switched
off when the engine is stopped and will not
be switched on again the next time the en-
gine is started.
WARNINGThe system turns on
rearscreen heating automatically if the tem-
perature is below 3°C.
WARNINGDo not apply stickers on the
inside of the rearscreen over the heating fil-
aments to avoid damage that might cause
it to stop working properly.
WARNINGWhen reconnecting the neg-
ative battery cable after having disconnected
it, wait for 2 minutes before turning the key
to enable the climate control system to re-
set actuator strokes properly.
POLLEN FILTER This filter has the specific capability of com-
bining the mechanical filtering of the air with
an electrostatic effect so that the outside air
admitted to the passenger compartment is
purified and free from particles such as dust,
pollen, etc.
In addition to the above, it also effectively
reduces the concentration of pollutants.
The filtering action takes place under all
air inlet conditions and it is clearly most ef-
fective with the windows shut.
Have the conditions of the filter checked by
Alfa Romeo Authorized Services at least once
a year, preferably on the onset of summer.If the vehicle is used mainly in polluted
or dusty areas it should be checked and if
necessary replaced, at shorter intervals.
Failure to replace the fil-
ter may considerably re-
duce the effectiveness of
the climate control system up to
blocking the air flow from the out-
lets and vents.

CAR MAINTENANCE
252
WARNING
Engine oil
Should prevailing use of the car be under
one of the following specially heavy condi-
tions:
– trailer or caravan towing
– dusty roads
– short distances (less than 7-8 km) re-
peated and with external temperatures be-
low zero.
– frequently idling engines or long distance
low speed driving (e.g. taxis or door-to-door
deliveries) or in case of a long term inac-
tivity.
Replace engine oil more frequently than
required on
SERVICE SCHEDULE
.WARNING
Fuel oil filter
The variety of the degree of purity of the
fuel oil in commerce may make it necessary
to change the fuel oil filter more frequently
than stated in the Scheduled Maintenance
Programme. If the engine is “sobbing” it
is a sign that the filter needs changing.WARNING
Air cleaner
Using the car on dusty roads, change the
air cleaner more frequently than stated in
the Scheduled Maintenance Programme.
For any doubts about the intervals be-
tween engine oil and air cleaner changes
in relation to how the car is used, contact
Alfa Romeo Authorized Services.

CAR MAINTENANCE
253
Car maintenance should be
entrusted to Alfa Romeo
Authorized Services. For
routine and minor maintenance op-
erations you wish to carry out
yourself, always make sure you
have the proper equipment, genuine
Alfa Romeo spare parts and the
necessary fluids; do not however
carry out these operations if you
have no experience.
WARNING
Pollen filter
If the car is used frequently in dusty or
heavily polluted environments it is advisable
to replace the filtering element more fre-
quently; in particular it should be replaced if
a reduction of the amount of air admitted to
the passenger compartment is noted. WARNING
Battery
You are recommended to have the battery
charge conditions checked, preferably at the
onset of winter, to avoid the possibility of
freezing the electrolyte.
This check should be carried out more fre-
quently if the car is used prevailingly for
short journeys, or if it is fitted with services
that absorb high amounts of current per-
manently with the ignition key off, especially
if installed in the after market.
In the case of use of the car in hot climates
or particularly harsh conditions, it is wise
to check the level of the battery fluid (elec-
trolyte) at more frequent intervals than stat-
ed in the Scheduled Maintenance Pro-
gramme.

CAR MAINTENANCE
265
DIESEL FILTERDRAINING CONDENSATION
WATER
Water in the supply circuit
can seriously damage the
whole injection system and
cause malfunctions to engine oper-
ation. Should the warning lamp
c
turn on, available for the provid-
ed versions/markets, contact as
soon as possible the Alfa Romeo
Authorised Service for drainage op-
erations.
When the car is habitual-
ly driven in dusty areas,
the cleaner should be
changed at shorter intervals than
those given in the Programmed
Maintenance Schedule.Any attempt to clean the
air cleaner may cause se-
rious engine damage.
AIR FILTERThe air cleaner is connected to the tem-
perature and air flow sensors which send the
electrical signals needed for correct opera-
tion of the injection and ignition system to
the control unit.
It must therefore always be in perfect con-
ditions to ensure correct operation of the en-
gine, low consumption and exhaust emis-
sion levels.
If they are not carried out
correctly and with the due
precautions, the operations
involving cleaner replacement de-
scribed herein may compromise the
safety of the car.
This operation should be carried
out by Alfa Romeo Authorized Ser-
vices.