2006 YAMAHA YD110 brake fluid

Owners are personally responsible for their vehicle’s condition. Your Motorcycle’s vital functions can start to deteriorate
quickly and unexpectedly-even if it remains unused (for instance, if it is exposed to the elements). Any damage, fluid
leak or loss of tyre pressure could have serious consequence Therefore’ it is very important that, in addition to a
thorough visual inspection, you check the following points before each ride.PRE-OPERATION CHECKS
PRE-OPERATION CHECK LIST
ITEMPAGE CHECKS
Front brake
Rear brake
Clutch
Throttle grip and housing
Engine oil
Drive chain
Wheels and tyres
Control and meter cable
Brake and shift pedal shafts
 Check tyre pressure, wear, damage and spoke tightness.
 Tighten spokes if necessary.  Check operation, condition and free play.
 Adjust if necessary.
 Check for smooth operation.
 Lubricate if necessary.
 Check oil level.
 Fill with oil if necessary.
 Check chain slack and condition.
 Lubricate if necessary.
 Adjust if necessary.
 Check for smooth operation.
 Lubricate if necessary.  Check for smooth operation.
 Lubricate if necessary.  Check operation, condition and free play.
 Adjust if necessary.  Check operation, condition and free play.
 Adjust if necessary.3-4, 6-22
3-4, 6-23
3-3-, 6-22
6-17, 6-29
6-11, 6-12
6-29
6-30 6-25, 6-26
6-18 – 6-21
4.1
PG1_55.pmd9/24/2005, 7:53 AM 28

4.2
PRE-OPERATION CHECKS
IF WAITING AT TRAFFIC SIGNAL IS FOR LONG, SWITCH OFF THE ENGINE TO PROTECT
THE ENVIRONMENT AND TO LOWER FUEL CONSUMPTION
NOTE :Pre-operator checks should be made each time the Motorcycle is used. Such an inspection can be accomplished
in a very short time; and the added safety it assures is more than worth the time involved. WARNINGIf any item in the Pre-Operation Check is not working properly, have it inspected and repaired before operating
the Motorcycle.
ITEMPAGE CHECKS
Brake and clutch lever pivots
Center stand pivot
Chassis fasteners
Fuel Tank
Lights, signals and switches
Battery
 Check for smooth operation.
 Lubricate if necessary.
 Check for proper operation.  Make sure that all nuts, bolts, and screws are properly tightened
 Tighten if necessary.
 Check fuel level.
 Fill with fuel if necessary.6-30
6-30
-
3-5, 3.6
3-2, 6-37
6-33 – 6-35 Check for smooth operation.
 Lubricate if necessary.
 Check fluid level.
 Fill with distilled water if necessary.
PG1_55.pmd9/24/2005, 7:53 AM 29

1. Before cleaning the Motorcycle :
eksVjlkbfdy dh lQkbZ djus ls
igys %
a. Block off the end of the exhaust
pipe to prevent water entry; a
plastic bag and string rubber
band may be used.
,XtkWLV ikbZi ¼fudkl&ikbi½ ls ikuh
ds izos'k dks jksdus ds fy, ikbi ds
,d fljs dks IykfLVd cSx vkSj jcj
cSaM dk iz;ksx djds] can fd;k tk
ldrk gSA
b. Make sure the spark plug and all
filler caps are properly installed.
lqfuf'pr djssa fd LikWdZ Iyx vkSj
lHkh fQYyj&dSSIl Bhd rjg ls yxk,
x;s gksaA
2. If the engine case is excessively
greasy, apply degreaser with a
paint brush. Do not apply
degreaser to the chain,
sprockets, or wheel axles.
;fn batu dk dsl vR;kf/kd :i ls
fpduk gS rks isaV czq'k dh lgk;rk ls
bl ij ^fpdukbZ vojks/kd* yxk,aA
psu] LizkWdsV~l vFkok ifg, ds ,Dlyksa
ij fM&xzhlj dk mi;ksx u djsaA
A. CLEANING
lQkbZ
Frequent, thorough cleaning of your
Motorcycle will not only enhance its
appearance but will improve its
general performance and extend the
useful life of many components.tYnh&tYnh] iwjh rjg lQkbZ u dsoy
vkidh eksVjlkbfdy dks ns[kus esa vPNk
cukrh gS cfYd bldh lk/kkj.k dk;Z{kerk
esa lq/kkj ykrh gS vkSj blls cgqr ls iqtsZ
ds dk;Z&dky esa o f) gksrh gS CAUTION :
 Improper cleaning can damage
the cowlings, panels and other
plastic parts. Use only a soft,
clean cloth or sponge with mild
detergent and water to clean
plastic.
 Do not use any harsh chemical
products on plastic parts. Be
sure to avoid using cloths or
sponges which have been in
contact with strong or abrasive
cleaning products, solvent or
thinner, fuel (gasoline), rust
removers or inhibitors, brake
fluid, antifreeze or electrolyte.
lko/kkuh %
xyr rjhds ls dh xbZ lQkbZ ls
eksVjlkbfdy ds dkůyx] iSuy rFkk
vU; IykWfLVd ds iqtsZ [kjkc gks ldrs
gSaA IykWfLVd ds iqtksZa dks lkQ djus
ds fy, eghu fMVtsZaV vkSj ikuh ds
lkFk dsoy lkQ] eqyk;e diM+s dk
gh iz;ksx djsaA

IykfLVd ds iqtsZ ¼daiksusaV~l½ ds fy,
fdlh rst dsehdYl dk iz;ksx u
djsaAlqfuf'pr djsa fd mu diM+ksa
vFkok Liat ds iz;ksx ls cpk tk, tks
'kfDr'kkyh vFkok ,cjsflo lQkbZ
mRiknksa] nzkod] vFkok fFkuj] b±/ku]
¼xSl½ tax izfrjks/kdksa vFkok
tax&fueZwydksa] cszd ds b±/ku] 'khr
fojks/kh ¼,aVh&Ýht½ vFkok bysDVªksykbV
ds laidZ esa vk tkrs gSaA
7.1
CLEANING AND STORAGElQkbZ rFkk HkaMkj.k
pg56_96.pmd9/24/2005, 7:54 AM 84