2006 VOLVO XC70 service

This manual deals with the operation and care of your Volvo
Welcome to the worldwide family of Volvo owners.
We trust that you will enjoy many years of safe driv-
ing in your Volvo, an automobile designed with your
safety and comfort in mind. To help ensure your
satisfaction with this vehicle, we encourage you to
familiarize yourself with the equipment descriptions,
operating instructions and maintenance requirements/
recommendations in this manual. We also urge you
and your passengers to wear seat belts at all times in
this or any other automobile. And, of course, please
do not operate a vehicle if you may be affected by
alcohol, medication or any impairment that could
hinder your ability to drive.Your Volvo is designed to meet all applicable safety and
emission standards, as evidenced by the certification
labels attached to the driver's door opening and on the
left wheel housing in the engine compartment.
For further information please contact your
retailer, or:
In the USA: In Canada:
Volvo Cars of North America Volvo Cars of Canada Ltd.
Customer Care Center National Customer Service
P.O. Box 914 175 Gordon Baker Road
Rockleigh, New Jersey 07647-0914 North York, Ontario M2H 2N7
1-800-458-1552 1-800-663-8255
www.volvocars.us
www.volvocanada.com

Volvo and the environment
In addition to continuous environmental refinement of conventional
gasoline-powered internal combustion engines, Volvo is actively looking
at advanced technology alternative-fuel vehicles.
When you drive a Volvo, you become our partner in the work to lessen
the car's impact on the environment.
To reduce your vehicle's environmental impact, you can:
•Maintain proper air pressure in your tires. Tests have shown de-
creased fuel economy with improperly inflated tires
•Follow the recommended maintenance schedule in your Warranty and
Service Records Information booklet.
•Drive at a constant speed
•See an authorized Volvo retailer as soon as possible for inspection if
the check engine (malfunction indicator) lamp
illuminates, or stays on
after the vehicle has started
•Properly dispose of any vehicle related waste such as used motor oil,
used batteries, brake pads, etc.
•When cleaning your car, use Volvo's own car care products, all of
which have systematically been adapted to the environment
PremAir®
On the surface of the radiator in the engine compartment, there is a special
coating called PremAir®. PremAir® works as a catalytic converter,
converting most of the ozone passing through the radiator into oxygen,
thereby reducing harmful ground-level ozone.
PremAir is a registered trademark of Engelhard Corporation.
Volvo is committed to the well being of our customers. As a natural
part of this commitment, we care about the environment in which we all
live. Caring for the environment means an everyday involvement in
reducing our environmental impact.
Volvo's environmental activities are based on a holistic view, which
means we consider the overall environmental impact of a product
throughout its complete life cycle. In this context, design, production,
product use, and recycling are all important considerations.
In production, Volvo has partly or completely phased out several
chemicals including freons, lead chromates, naphtanates, asbestos,
mercury and cadmium; and reduced the amount of chemicals used in
our plants 50% since 1991.
In use, Volvo was the first in the world to introduce into production a
three-way catalytic converter with a Lambda sond, now called oxygen
sensor, in 1976. The current version of this highly efficient system
reduces emissions of harmful substances (CO, HC, NOx) from the
exhaust pipe by approximately 95% and the search to eliminate the
remaining emissions continues. Volvo is the only automobile manufac-
turer to offer CFC-free retrofit kits for the air conditioning system for
all models as far back as the M/Y 1975 240. Advanced electronic
engine controls, refined purification systems and cleaner fuels are
bringing us closer to our goal.
After Volvo cars and parts have fulfilled their use, recycling is the next
critical step in completing the life cycle. The metal content is about
75% of the total weight of a car, which makes the car among the most
recycled industrial products. In order to have efficient and well con-
trolled recycling, many Volvo variants have printed dismantling
manuals, indicating the weight and material of individual components.
For Volvo, all homogeneous plastic parts weighing more than 1.7 oz.
(50 grams) are marked with international symbols that indicate how the
component is to be sorted for recycling.

4
8803443a
Seat belt use during pregnancy
Seat belt use during
pregnancy
 
 

 


< 






  

 

 
 


 

 



 
 



"
 


 
  

 

( 

  


>  
 
 







,
 
 




 1
4 8
   



 

 

 

Child seats
9

*%

 
  




•Never use a seat belt for more than one
occupant.
•Never wear the shoulder portion of the
belt under the arm, behind the back or
otherwise out of position. Such use could
cause injury in the event of an accident.
•Seat belts lose much of their strength
when exposed to violent stretching and
should be replaced after any collision,
even if they appear to be undamaged.
•Never repair the belt yourself; have this
work done by an authorized Volvo service
technician only.
•Any device used to induce slack into the
shoulder belt portion of the three-point
belt system will have a detrimental effect
on the amount of protection available to
you in the event of a collision.
•The seat back should not be tilted too far
back. The shoulder belt must be taut in
order to function properly.
•Do not use child safety seats or child
booster cushions/backrests in the front
passenger’s seat. We also recommend that
children who have outgrown these devices
sit in the rear seat with the seat belt
properly fastened.
Seat belts

5
Supplemental Restraint System (SRS)
SRS warning light
Supplemental Restraint
System
( 

  

 6 
)

" 
) ,)")1
6? )")
    
  

 



 

 




( 
  
)")

()")
 

,  

1

  
 



8
.  
 

  

4


8

 
 
)")



 
  





 

8

 



•If the SRS warning light stays on after the
engine has started or if it illuminates while
you are driving, have the vehicle inspected
by a trained and qualified Volvo service
technician as soon as possible.
•Never try to repair any component or part
of the SRS yourself. Any interference in
the system could cause malfunction and
serious injury. All work on these systems
should be performed by an authorized
Volvo service technician.


 >
  ,

 
 
$ 


1

 





 

 

, 1
 

 

 
 
>






6 






 


<
 
 
 
 

  #
•Switch off the ignition for at least 10
minutes and disconnect the battery
•Wait at least one minute.
•Insert the key in the ignition and turn it to
position II.
•Press firmly on the brake pedal.
•Move the gear selector from (P)ark to the
(N)eutral position.

8
Front airbags
8802024e
Airbag decal on the passenger's dashboardAirbag decal on outside of both sun visors
SRS decal at far right of the passenger’s
dashboard


•Children must never be allowed in the
front passenger’s seat. Volvo recommends
that ALL occupants (adults and children)
shorter than 4 feet 7 inches (140 cm) be
seated in the back seat of any vehicle with
a passenger-side front airbag. See page 21
for guidelines.
•Occupants in the front passenger's seat
must never sit on the edge of the seat, sit
leaning toward the instrument panel or
otherwise sit out of position.
•The occupant's back must be as upright as
comfort allows and be against the seat
back with the seat belt properly fastened.
•Feet must be on the floor, e.g., not on the
dash, seat or out of the window.


•No objects or accessory equipment, e.g.
dashboard covers, may be placed on,
attached to, or installed near the air bag
hatch (the area above the glove compart-
ment) or the area affected by airbag
deployment (see the illustration on page
6).
•There should be no loose articles, e.g.
coffee cups, on the floor, seat, or dash-
board area.
•Never try to open the airbag cover on the
steering wheel or the passenger’s side
dashboard. This should only be done by a
trained and qualified Volvo service
technician.
@
   
 
>


10
Occupant Weight Sensor (OWS)


•Never try to open, remove, or repair any
components in the OWS system. This
could result in system malfunction.
Maintenance or repairs should only be
carried out by an authorized Volvo service
technician.
•The front passenger’s seat should not be
modified in any way. This could reduce
pressure on the seat cushion, which might
interfere with the OWS system’s function.



   



8
 





C  


 

 

   
+

4)   

A6

 
 

Modifications

 







8



? 

?  
, 1
$

   


6
#
 
65
 (
5  5
 5
9
+
<83%/"E 2.0/.
23%/
% &22 /F& %FF*

65
 5


G



 5  )
%.FB<
"

+
7*
*.
% &22 00- &*FF


•No objects that add to the total weight on
the seat should be placed on the front
passenger’s seat. If a child is seated in the
front passenger’s seat with any additional
weight, this extra weight could cause the
OWS system to enable the airbag, which
might cause it to deploy in the event of a
collision, thereby injuring the child.
•The seat belt should never be wrapped
around an object on the front passenger’s
seat. This could interfere with the OWS
system’s function.
•The front passenger’s seat belt should
never be used in a way that exerts more
pressure on the passenger than normal.
This could increase the pressure exerted
on the weight sensor by a child, and could
result in the airbag being enabled, which
might cause it to deploy in the event of a
collision, thereby injuring the child.

12
Side impact (SIPS) airbags
8802205d
1
8801920d2 3
Side impact airbags - front
seats only
( 

 
 




 )
9
)  ,)9)1



)9)

    




 
 
)9)

 
 

  
     

 
 



)9)

,

1
  





 
 

 
 


Components in the SIPS airbag system
 )9)

     



,%1 

 

   


   ,*1
    $
,-1
Location of the side impact (SIPS) airbag

•The SIPS airbag system is a supplement
to the structural Side Impact Protection
System and the three-point seat belt
system. It is not designed to deploy during
collisions from the front or rear of the car
or in rollover situations.
•The use of seat covers on the front seats
may impede SIPS airbag deployment.
•No objects, accessory equipment or
stickers may be placed on, attached to or
installed near the SIPS airbag system or in
the area affected by SIPS airbag deploy-
ment.
•Never try to open or repair any compo-
nents of the SIPS airbag system. This
should be done only by a trained and
qualified Volvo service technician.
•In order for the SIPS airbag to provide its
best protection, both front seat occupants
should sit in an upright position with the
seat belt properly fastened.
•Failure to follow these instructions can
result in injury to the occupants of the
vehicle in the event of an accident.

13
Volvo Inflatable Curtain (VIC)
WARNING!
•The VIC system is a supplement to the Side Impact Protection
System. It is not designed to deploy during collisions from the front
or rear of the car or in rollover situations.
•Never try to open or repair any components of the VIC system.
This should be done only by a trained and qualified Volvo service
technician.
•In order for the VIC to provide its best protection, both front seat
occupants and both outboard rear seat occupants should sit in an
upright position with the seat belt properly fastened; adults using
the seat belt and children using the proper child restraint system.
Only adults should sit in the front seats. Children must never be
allowed in the front passenger seat. See page 21 for guidelines.
Failure to follow these instructions can result in injury to the
vehicle occupants in an accident.
Volvo Inflatable Curtain (VIC)
This system consists of inflatable curtains located along the sides of the
roof liners, stretching from the center of both front side windows to the
rear edge of the rear side door windows. It is designed to help protect the
heads of the occupants of the front seats and the occupant of the
outboard rear seating positions in certain side impact collisions.

 
 


5
,651
)

(
) ,)9) 
1
 
 



5
,651

 

65
)9) 
  
 

NOTE: If the inflatable curtain deploys, it remains inflated for approxi-
mately 3 seconds.
8802260n8802259m