2006 Seat Ibiza 5D change wheel

If and when
204
WARNING
Loosen the wheel bolts only about one turn before raising the vehicle with
the jack, loosening the wheel bolts more than one turn can result in an acci-
dent.
Note
•
Do not use the hexagonal socket in the screwdriver handle to loosen or
tighten the wheel bolts.
•
If the wheel bolt is very tight, you may be able to loosen it by pushing
down the end of the spanner carefully with your foot. Hold on to the vehicle
for support and take care not to slip.
Raising the vehicle
The vehicle must be raised with a jack to remove the wheel.
– Locate the jacking point under the door sill closest to the wheel to be changed ⇒fig. 142.
– Wind up the jack under the jacking point until the arm of the jack is directly below the vertical rib under the door sill.
– Align the jack so that the arm of the jack fits around the rib under the door sill and the movable base plate of the jack is flat on the
ground ⇒fig. 143.
– Raise the vehicle until the defective wheel is just clear of the ground.Recesses at the front and rear of the door sills mark the jacking points
⇒fig. 142. A position has been made for each wheel. Do not fit the jack
anywhere else.
An unstable surface under the jack may cause the vehicle to slip off the jack.
Therefore, the jack must be fitted on solid ground offering good support. Use
Fig. 142 The jacking
points
Fig. 143 Fitting the jack
ibiza_angles_0706_DEF Seite 204 Freitag, 1. September 2006 1:18 13

If and when205
Safety First
Operating instructions
Tips and Maintenance
Te c h n i c a l D a t a
a large and stable base, if necessary. On a hard, slippery surface (such as
tiles) use a rubber mat or similar to prevent the jack from slipping.
WARNING
•
Take all precautions so that the base of the jack does not slip. Failure to
do so could result in an accident.
•
The vehicle can be damaged if the jack is not applied at the correct
jacking points. There is also a risk of injury since the jack can slip off
suddenly if it is not properly engaged.
Removing and fitting the wheel
For removing and fitting the wheel, the following tasks must
be completed.Change the wheel as described below, after loosening the wheel
bolts and raising the vehicle with the jack. Removing a wheel
– Unscrew the bolts using the
hexagonal tool in the handle of the
screwdriver (vehicle tool) and place them on a clean surface
⇒ fig. 144.
Fitting a wheel
– Screw in the wheel bolts and tighten them lightly using the hexagonal socket in the screwdriver handle.
The wheel bolts should be clean and turn easily. Before fitting the spare
wheel, inspect the condition of the wheel and hub mounting surfaces. These
surfaces must be clean before fitting the wheel.
The hexagonal socket in the screwdriver handle makes it easier to turn the
wheel bolts when they are loose. The reversible screwdriver blade should be
removed when the tool is used for this purpose.
If tyres with a specific direction of ro tation are fitted, note the direction of
rotation.
Note
Do not use the hexagonal socket in the screwdriver handle to loosen or
tighten the wheel bolts.
Fig. 144 Wheel change:
Hexagon socket in screw-
driver handle to turn the
wheel bolts after they
have been loosened
ibiza_angles_0706_DEF Seite 205 Freitag, 1. September 2006 1:18 13

General notes on the technical data
236WeightsKerb weight refers to the basic model with a fuel tank filled to 90% capacity
and without optional extras. The figure quoted includes 75 kg to allow for the
weight of the driver.
For special versions and optional equipment fittings or for the addition of
accessories, the weight of the vehicle will increase ⇒.
WARNING
•
Please note that the centre of gravity may shift when transporting
heavy objects; this may affect the vehi cle's handling and lead to an acci-
dent. Always adjust your speed and dr iving style to suit road conditions
and requirements.
•
Never exceed the gross axle weight rating or the gross vehicle weight
rating. If the allowed axle load or the allowed total weight is exceeded, the
driving characteristics of the vehicle may change, leading to accidents,
injuries and damage to the vehicle.
To w i n g a t r a i l e rTrailer weightsTrailer weights
The trailer weights and drawbar loads approved are selected in intensive
trials according to precisely defined criteria. The approved trailer weights are
valid for vehicles in EU for maximum speeds of 80 km/h (in certain circum-
stances up to 100 km/h). The figures may be different in other countries. All
data in the official vehicle documents take precedence over these data ⇒. Drawbar load
The
maximum permitted weight exerted by the trailer drawbar on the ball joint
of the towing bracket must not exceed 75 kg.
In the interest of road safety, we recommend that you always tow
approaching the maximum drawbar load. The response of the trailer on the
road will be poor if th e drawbar load is too small.
If the maximum permissible drawbar load cannot be met (e.g. with small,
empty and light-weight single axle trailers or tandem axle trailers with an axle
base of less than 1 metre), at least 4% of the actual trailer weight is a legal
stipulation for a drawbar load.
WARNING
•
For safety reasons, you should not drive at speeds above 80 km/h when
towing a trailer. This also applies to countries where higher speeds are
permitted.
•
Never exceed the maximum trailer weights or the draw bar loading. If
the permissible axle load or the perm issible total weight is exceeded, the
driving characteristics of the vehicle may change, leading to accidents,
injuries and damage to the vehicle.
WheelsTyre pressure, snow chains, wheel boltsTyre pressures
The sticker with the tyre pressure values can be found on the inside of the
tank flap. The tyre pressure values given there are for cold tyres. The slightly
raised pressures of warm tyres must not be reduced ⇒.
ibiza_angles_0706_DEF Seite 236 Freitag, 1. September 2006 1:18 13

General notes on the technical data 237
Safety First
Operating instructions
Tips and Maintenance
Te c h n i c a l D a t a
Snow chains
Snow chains are only permitted on the front wheels and only for tyres 155/80
R13; 165/70 R14 and 185/80 R14. Snow ch
ains must have fine-pitch links
which do not protrude more than 15 mm, including tension device.
Remaining tyres can be fitted with chains no thicker than 9 mm.
Wheel bolts
After the wheels have been changed, the tightening torque of the wheel bolts
should be checked as soon as possible with a torque wrench ⇒. The tight-
ening torque for steel and alloy wheels is 120 Nm.
WARNING
•
Check the tyre pressure at least once per month. Correct tyre pressure
is very important. If the tyre pressure is too high or too low, there is an
increased danger of accidents, particularly at high speeds.
•
If the torque of the wheel bolts is too low, they could loosen whilst the
vehicle is in motion. Risk of accident! If the tightening torque is too high,
the wheel bolts and threads could be damaged.Note
We recommend that you ask your Authorised Service Centre for information
about appropriate wheel, tyre and snow chain size.
ibiza_angles_0706_DEF Seite 237 Freitag, 1. September 2006 1:18 13

Technical Data255
Safety First
Operating instructions
Tips and Maintenance
Te c h n i c a l D a t a
Dimensions and capacities
Dimensions
Length, width 3953 mm/ 1698 mm
Height at kerb weight 1441 mm
Front and rear projection 931 mm/ 662mm
Wheelbase 2460 mm
Turning circle 10,54 m
Track width
a)
a)This data will change depending on the type of wheel rim.
Front Rear
1435 mm 1424 mm
1419 mm 1408 mm
Capacities
Fuel tank 45 l. Reserve 7 l.
Windscreen washer fluid container with headlight washer 2 l/ 4,5 l
Tyre pressure
Summer-grade tyres:
The correct tyre pressure can be seen on the sticker on the inside of the tank flap.
Winter tyres:
The pressure of these tyres is the same as the summer tyre pressure plus 0.2 bar.
ibiza_angles_0706_DEF Seite 255 Freitag, 1. September 2006 1:18 13

Index
258Bulb changes
general notes . . . . . . . . . . . . . . . . . . . . . . . 214
Buzzer . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92, 130CCar care Exterior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 161
Car care products . . . . . . . . . . . . . . . . . . . . . . . 160
Car phone . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 170
Car washes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 161
Catalytic converter . . . . . . . . . . . . . . . . . . . . . . 150
Central locking . . . . . . . . . . . . . . . . . . . . . . . . . . 68 Automatic speed dependent locking and un-locking system* . . . . . . . . . . . . . . . . . . . . . 70
Emergency unlocking system . . . . . . . . . . . . 71
Locking system for invo luntary unlocking . . 70
Selective unlocking system* . . . . . . . . . . . . 70
Unlocking system* . . . . . . . . . . . . . . . . . . . . 70
Central locking button Central locking . . . . . . . . . . . . . . . . . . . . . . . 71
unlocking . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Cetane number . . . . . . . . . . . . . . . . . . . . . . . . . 175
Change lamps dipped headlight lamp . . . . . . . . . . . . . . . . 216
Changing gear See Manual gearbox . . . . . . . . . . . . . . . . . . 134
Changing lamps interior light and reading light . . . . . . . . . . 224
changing lamps rear lights on frame . . . . . . . . . . . . . . . . . . . 223 Changing the lamps
glove box light* . . . . . . . . . . . . . . . . . . . . . . 224
indicator lights . . . . . . . . . . . . . . . . . . . . . . 219
main beam lights . . . . . . . . . . . . . . . . . . . . 217
Main headlight lamps . . . . . . . . . . . . . . . . . 215
number plate light . . . . . . . . . . . . . . . . . . . 223
rear lights on the tailgate: access to the lamp .222
rear lights on the tailgate: access to the rear lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 221
side beam lights . . . . . . . . . . . . . . . . . . . . . 218
Side indicator lights . . . . . . . . . . . . . . . . . . 221
Changing windscreen wiper blades . . . . . . . . . 186
Chassis number . . . . . . . . . . . . . . . . . . . . . . . . 234
Checking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 191
Checking battery electrolyte level . . . . . . . . . . 191
Checking engine oil level . . . . . . . . . . . . . . . . . 180
Child safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Child seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42 Categorisation in groups . . . . . . . . . . . . . . . 42
Group 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Group 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Group 3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Groups 0 and 0+ . . . . . . . . . . . . . . . . . . . . . . 42
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . . . 41
Securing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
Child seats ISOFIX and Toptether system . . . . . . . . . . . . 46
on the front passenger seat . . . . . . . . . . . . . 26
Cigarette lighter . . . . . . . . . . . . . . . . . . . . . . . . 112
Cleaning alloy wheels . . . . . . . . . . . . . . . . . . . . 165 Cleaning and caring for your vehicle . . . . . . . . 160
Cleaning chrome . . . . . . . . . . . . . . . . . . . . . . . . 164
Cleaning cloth seat covers . . . . . . . . . . . . . . . . 167
Cleaning dash panel . . . . . . . . . . . . . . . . . . . . . 166
Cleaning engine compartment . . . . . . . . . . . . . 166
Cleaning fabric trim . . . . . . . . . . . . . . . . . . . . . 167
Cleaning leather . . . . . . . . . . . . . . . . . . . . . . . . 167
Cleaning plastic parts . . . . . . . . . . . . . . . . . . . . 166
Cleaning seat belts . . . . . . . . . . . . . . . . . . . . . . 168
Cleaning steel wheels . . . . . . . . . . . . . . . . . . . . 164
Cleaning windows . . . . . . . . . . . . . . . . . . . . . . . 163
Cleaning wooden trim . . . . . . . . . . . . . . . . . . . . 167
Climatronic
automatic mode . . . . . . . . . . . . . . . . . . . . . 124
controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . 123
General notes . . . . . . . . . . . . . . . . . . . . . . . 126
manual mode . . . . . . . . . . . . . . . . . . . . . . . 125
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
Cockpit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 49
Control Light switches . . . . . . . . . . . . . . . . . . . . . . . . 88
wing mirrors . . . . . . . . . . . . . . . . . . . . . . . . 100
Control lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Control lighting . . . . . . . . . . . . . . . . . . . . . . . . . . 49
Controls Electric windows . . . . . . . . . . . . . . . . . . . . . . 82
Convenience closing Sliding/tilting roof . . . . . . . . . . . . . . . . . . . . 86
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
ibiza_angles_0706_DEF Seite 258 Freitag, 1. September 2006 1:18 13

Index261
Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 164
Luggage compartment . . . . . . . . . . . . . . . 15, 114
Luggage compartment cover . . . . . . . . . . . . . . 115MMain beam . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
Main beam headlights
Indicator lamp . . . . . . . . . . . . . . . . . . . . . . . . 62
Main headlight lamps . . . . . . . . . . . . . . . . . . . . 215
Manual gearbox . . . . . . . . . . . . . . . . . . . . . . . . . 134
Manual heating . . . . . . . . . . . . . . . . . . . . . . . . . 118 controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . 117
Manual heating system Defrosting the windscreen . . . . . . . . . . . . . 118
Demisting the windscreen and side windows . .118
MFD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53
Mileage display . . . . . . . . . . . . . . . . . . . . . . . . . . 56
Mirrors courtesy mirror . . . . . . . . . . . . . . . . . . . . . . . . 94
Interior mirror . . . . . . . . . . . . . . . . . . . . . . . . . 99
Wing mirrors . . . . . . . . . . . . . . . . . . . . . . . . . 100
Mobile phone . . . . . . . . . . . . . . . . . . . . . . . . . . . 170
Modifications . . . . . . . . . . . . . . . . . . . . . . . . . . . 169
Multi-function display . . . . . . . . . . . . . . . . . . . . . 53NNumber of seats . . . . . . . . . . . . . . . . . . . . . . . . . . 16
OObservations . . . . . . . . . . . . . . . . . . . . . . . . . . . 151
Octane number . . . . . . . . . . . . . . . . . . . . . . . . . 174
Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 179
Oil change . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 182
Oil properties . . . . . . . . . . . . . . . . . . . . . . . . . . . 179
One-touch opening and closing Electric windows . . . . . . . . . . . . . . . . . . . . . . 83
Opening and locking . . . . . . . . . . . . . . . . . . . . . . 81
Overview Control lamps . . . . . . . . . . . . . . . . . . . . . . . . . 58
Instrument panel . . . . . . . . . . . . . . . . . . . . . . 49
Instruments . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Warning lamps . . . . . . . . . . . . . . . . . . . . . . . . 58PPaintworkPolishing . . . . . . . . . . . . . . . . . . . . . . . . . . . 163
Waxing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 162
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 139
Parking lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . 92
Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 169
Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Petrol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 174 Trips to foreign countries . . . . . . . . . . . . . . 151
Petrol additives . . . . . . . . . . . . . . . . . . . . . . . . . 174
Petrol engines, starting . . . . . . . . . . . . . . . . . . . 131
Physical principles of a frontal collision . . . . . . 17
Plastic key tab . . . . . . . . . . . . . . . . . . . . . . . . . . . 74 Plastic parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . 163
Pollen filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 126
RRadio frequency remote control
Changing the battery . . . . . . . . . . . . . . . . . . . 77
Radio wave remote control . . . . . . . . . . . . . . . . . 76
Rain sensor* . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Rear cup holder* . . . . . . . . . . . . . . . . . . . . . . . . 111
Rear fog lamp indicator lamp . . . . . . . . . . . . . . . . . . . . . . . . 88
Rear seat bench . . . . . . . . . . . . . . . . . . . . . . . . . 107
Rear seats, folding down . . . . . . . . . . . . . . . . . . . . . . . . 107
Rear window heating Heating element wires . . . . . . . . . . . . . . . . 164
Rear window wiper . . . . . . . . . . . . . . . . . . . . . . . 97
Rear-view mirror . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Rearview mirrors . . . . . . . . . . . . . . . . . . . . . . . . . 99
Refuelling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 173
Remote control key Buttons . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 76
Synchronising . . . . . . . . . . . . . . . . . . . . . . . . 77
Removing and fitting the wheel . . . . . . . . . . . . 205
Repairs Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Replacement keys . . . . . . . . . . . . . . . . . . . . . . . . 75
Replacing lamps fog lights . . . . . . . . . . . . . . . . . . . . . . . . . . . 220
ibiza_angles_0706_DEF Seite 261 Freitag, 1. September 2006 1:18 13

Index263
Switches
Electric windows . . . . . . . . . . . . . . . . . . . . . . 82
Sliding/tilting roof . . . . . . . . . . . . . . . . . . . . . 85
Switching off the engine . . . . . . . . . . . . . . . . . . 133TTailgate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Tank fuel level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52
reserve indicator . . . . . . . . . . . . . . . . . . . . . . 52
tank capacity . . . . . . . . . . . . . . . . . . . . . . . . . 52
TCS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
TCS (Traction control system) Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 64
The danger of not using the seat belt . . . . . . . . 18
Tightening torque of wheel bolts . . . . . . . . . . . 237
Tools . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 198
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 228
Towing a trailer . . . . . . . . . . . . . . . . . . . . 156, 236
Towing bracket . . . . . . . . . . . . . . . . . . . . . . . . . . 157
Towing bracket, fitting . . . . . . . . . . . . . . . . . . . 171
Towing eye . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 228
Tow-starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . 228
Traction control system warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 64
Trailer turn signals Indicator lamps . . . . . . . . . . . . . . . . . . . . . . . 65
Warning lamp . . . . . . . . . . . . . . . . . . . . . . . . . 92
Trailer weights . . . . . . . . . . . . . . . . . . . . . . . . . . 236
Trips, checklist . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 Turn signals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91
Warning lamp . . . . . . . . . . . . . . . . . . . . . . 61, 92
Two-way radio . . . . . . . . . . . . . . . . . . . . . . . . . . 170
Type plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 234
Tyre Mobility-System (Tyre repair kit) . . . 200, 206
Tyre pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . 193
Tyre pressures . . . . . . . . . . . . . . . . . . . . . . . . . . 236
Tyre repair kit . . . . . . . . . . . . . . . . . . . . . . 200, 206
Tyres and wheels Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . 194
Tyres service life . . . . . . . . . . . . . . . . . . . . . . . . 193
Tyres tread depth . . . . . . . . . . . . . . . . . . . . . . . . 194
Tyres with directional tread pattern . . . . . . . . . 192
UUnderbody sealant . . . . . . . . . . . . . . . . . . . . . . 165
USB* connection . . . . . . . . . . . . . . . . . . . . . . . . 114VVehicle battery . . . . . . . . . . . . . . . . . . . . . . . . . . 190
Vehicle data . . . . . . . . . . . . . . . . . . . . . . . . . . . . 234
Vehicle identification data . . . . . . . . . . . . . . . . 234
Vehicle identification number . . . . . . . . . . . . . 234
Vehicle interior heating or cooling system . . . 121
Vehicle paint Car care products . . . . . . . . . . . . . . . . . . . . . 160
Vehicle tools Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 198
Vehicle wallet storage . . . . . . . . . . . . . . . . . . . . 108 vent wings* . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
Ventilation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 118
Ventilation slits . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Volumetric sensor*
Activation . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
Deactivation . . . . . . . . . . . . . . . . . . . . . . . . . . 79
WWarning lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Warning lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Warning triangle . . . . . . . . . . . . . . . . . . . . . . . . 114
Washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 185
Washing by hand . . . . . . . . . . . . . . . . . . . . . . . . 161
Washing the vehicle . . . . . . . . . . . . . . . . . . . . . 161
Washing with high pressure cleaners . . . . . . . 162
Water in the windscreen washer tank . . . . . . . 185
Wear indicators . . . . . . . . . . . . . . . . . . . . . . . . . 194
Wheel bolts . . . . . . . . . . . . . . . . . . . . . . . 203, 237Torque . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 195
Wheel change . . . . . . . . . . . . . . . . . . . . . . . . . . 201
Wheel trims . . . . . . . . . . . . . . . . . . . . . . . . . . . . 202
Wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . 192, 236
Why assume the correct sitting position? . . . . . 25
Why should head restraints be correctly adjusted? 12
Why wear seat belts? . . . . . . . . . . . . . . . . . . . 16, 17
Why wear seatbelts? . . . . . . . . . . . . . . . . . . . . . . 25
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82
Windscreen . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
ibiza_angles_0706_DEF Seite 263 Freitag, 1. September 2006 1:18 13