2006 SAAB 9-2X maintenance schedule

Maintenance and service
11 - 2 7
11
– CONTINUED –

Recommended clutch fluidFMVSS No. 116, fresh DOT 3 or 4 brake flu-id
Brake boosterIf the brake booster does not operate as
described in the following, have it checked
by your Saab dealer.
1. With the engine off, depress the brake
pedal several times, applying the same
pedal force each time. The distance the
pedal travels should not vary.
2. With the brake pedal depressed, start
the engine. The pedal should move slight-
ly down to the floor.
3. With the brake pedal depressed, stop
the engine and keep the pedal depressed
for 30 seconds. The pedal height should
not change.
4. Start the engine again and run for ap-
proximately one minute then turn it off.
Depress the brake pedal several times to
check the brake booster. The brake boost-
er operates properly if the pedal stroke de-
creases with each depression.
Brake pedalCheck the brake pedal free play and re-
serve distance according to the mainte-
nance schedule in the “Saab Warranty
and Service Record Booklet”.
Checking the brake pedal free
play1) 0.04 – 0.12 in (1.0 – 3.0 mm)Stop the engine and firmly depress the
brake pedal several times. Lightly press
the brake pedal down with one finger to
check the free play with a force of less
than 2 lbs (10 N, 1 kg).
If the free play is not within proper specifi-
cation, contact your Saab dealer.
Be careful not to spill clutch fluid
when adding it. If clutch fluid
touches the exhaust pipe, it may
cause a bad smell, smoke, and/or
a fire. If clutch fluid gets on the ex-
haust pipe, be sure to wipe it off.
Avoid mixing DOT 3 and DOT 4
brake fluids even if they are of the
same brand.
1
B00377
A1910BE-A-GSAAB.book Page 27 Tuesday, September 6, 2005 8:37 AM
ProCarManuals.com

11 - 2 8
Maintenance and service

Checking the brake pedal re-
serve distance1) More than 2.56 in (65 mm)Depress the pedal with a force of approxi-
mately 66 lbs (294 N, 30 kg) and measure
the distance between the upper surface of
the pedal pad and the floor.
When the measurement is smaller than
the specification, or when the pedal does
not operate smoothly, contact with your
Saab dealer.
Clutch pedal (MT vehicles)Check the clutch pedal free play and re-
serve distance according to the mainte-
nance schedule in the “Saab Warranty
and Service Record Booklet”.
Checking the clutch functionCheck the clutch engagement and disen-
gagement.
1. With the engine idling, check that there
are no abnormal noises when the clutch
pedal is depressed, and that shifting into
1st or reverse feels smooth.
2. Start the vehicle by releasing the pedal
slowly to check that the engine and trans-
mission smoothly couple without any sign
of slippage.

Checking the clutch pedal
free play1) 0.16 – 0.51 in (4.0 –13.0 mm)Lightly press the clutch pedal down with
your finger until you feel resistance, and
check the free play.
If the free play is not within proper specifi-
cation, contact your Saab dealer.
1
B00378
1
B00377
A1910BE-A-GSAAB.book Page 28 Tuesday, September 6, 2005 8:37 AM
ProCarManuals.com

11 - 3 0
Maintenance and service
Parking brake strokeCheck the parking brake stroke according
to the maintenance schedule in the “Saab
Warranty and Service Record Booklet”.
When the parking brake is properly adjust-
ed, braking power is fully applied by pull-
ing the lever up seven to eight notches
gently but firmly (approximately 44 lbs
[196 N, 20 kg]). If the parking brake lever
stroke is not within the specified range,
have the brake system checked and ad-
justed at your Saab dealer.
Tires and wheels
Types of tiresYou should be familiar with type of tires
present on your vehicle.
The factory-fitted tires are all-season tires
except for the 17-inch tires that are option-
al on the Aero (those are summer tires).

All season tires
All season tires are designed to provide
an adequate measure of traction, handling
and braking performance in year-round
driving including snowy and icy road con-
ditions. However all season tires do not of-
fer as much traction performance as win-
ter (snow) tires in heavy or loose snow or
on icy roads.
All season tires are identified by “ALL
SEASON” and/or “M+S” (Mud & Snow) on
the tire sidewall.

Summer tires
Summer tires are high-speed capability
tires best suited for highway driving under
dry conditions.
Summer tires are inadequate for driving
on slippery roads such as on snow-cov-
ered or icy roads.
If you drive your vehicle on snow-covered
or icy roads, we strongly recommend the
use of winter (snow) tires.When installing winter tires, be sure to re-
place all four tires.

Winter (snow) tires
Winter tires are best suited for driving on
snow-covered and icy roads. However
winter tires do not perform as well as sum-
mer tires and all season tires on roads oth-
er than snow-covered and icy roads.

Tire inspectionCheck on a daily basis that the tires are
free from serious damage, nails, and
stones. At the same time, check the tires
for abnormal wear.
Contact your Saab dealer immediately if
you find any problem.NOTE
When the wheels and tires strike
curbs or are subjected to harsh treat-
ment as when the vehicle is driven on a
rough surface, they can suffer damage
that cannot be seen with the naked eye.
This type of damage does not become
evident until time has passed. Try not
to drive over curbs, potholes or on oth-
er rough surfaces. If doing so is un-
avoidable, keep the vehicle’s speed
down to a walking pace or less, and ap-
proach the curbs as squarely as possi-
ble. Also, make sure the tires are not
B00379
A1910BE-A-GSAAB.book Page 30 Tuesday, September 6, 2005 8:37 AM
ProCarManuals.com

Index
14-5
14
J
Jack and jack handle ........................................................ 9-15
Jump starting ...................................................................... 9-8
K
Key
Interlock release ............................................................ 3-5
Number .......................................................................... 2-2
Reminder chime ............................................................ 3-5
Keys ................................................................................... 2-2
L
Leather seat materials ...................................................... 10-5
Light
Cargo area .......................................................... 6-2, 11-52
Dome .................................................................. 6-2, 11-52
Map ..................................................................... 6-2, 11-52
Light control switch ........................................................... 3-15
Limited slip differential (LSD) ............................................ 7-14
Loading your vehicle ........................................................ 8-10
LSD (Limited slip differential) ............................................ 7-14
M
Main fuse ........................................................................ 11-42
Maintenance
Precautions .................................................................. 11-3
Schedule ...................................................................... 11-3
Seatbelt ....................................................................... 1-17
Tools ............................................................................ 9-15
Malfunction indicator lamp (Check Engine light) .............. 3-11
Manual climate control system ........................................... 4-3Manual transmission (MT) .................................................. 7-8
Map light .................................................................. 6-2, 11-52
Maximum load limits ......................................................... 8-13
Meters and gauges ............................................................. 3-6
Mirrors ............................................................................... 3-24
N
New vehicle break-in driving – the first 1,000 miles
(1,600 km) ....................................................................... 8-2
O
Odometer/Trip meter ........................................................... 3-6
Off road driving ................................................................... 8-6
Oil filter .............................................................................. 11-8
Oil level
Engine .......................................................................... 11-8
Front differential gear oil (AT vehicles) ....................... 11-22
Manual transmission .................................................. 11-19
Rear differential .......................................................... 11-23
Oil pressure warning light ................................................. 3-11
Outside mirrors ................................................................. 3-25
Outside temperature indicator ............................................. 3-8
Overheating engine .......................................................... 9-10
P
Parking
Brake ............................................................................ 7-19
Brake stroke ............................................................... 11-30
Light switch .................................................................. 3-19
Tips .............................................................................. 7-19
Periodic inspections ............................................................ 8-4
A1910BE-A-GSAAB.book Page 5 Tuesday, September 6, 2005 8:37 AM
ProCarManuals.com