Maintenance, Car Care
201
How Emission Control Works When an automobile engine is running, it uses en-
ergy generated through the combustion of a mix-
ture of air and fuel. Depending on whether a car is
driven fast or slowly or whether the engine is cold
or hot, some of the fuel (hydrocarbons) may not
be burned completely, but may be discharged into
the engine crankcase or exhaust system. Addito-
nal hydrocarbons may enter the atmosphere th-
rough evaporation of fuel from the fuel tank. These
hydrocarbons (HC), when released into the air,
contribute to undesirable pollution.
In addition, carbon monoxide (CO) and oxides of
nitrogen (NOx) contribute to engine emissions.
They, too, are formed during the combustion pro-
cess and discharged into the exhaust system.
To reduce these pollutants, your Porsche is equip-
ped with a precisely calibrated fuel injection sys-
tem to assure a finely balanced air/fuel mixture un-
der all operating conditions.
Oxygen sensor The oxygen sensor, installed in the exhaust pipe
continuously senses the oxygen content of the ex-
haust and signals the information to an electronic
control unit. The control unit corrects the air/fuel
ratio, so the engine always receives an accurately
metered air/fuel mixture. Crankcase ventilation Through crankcase ventilation, undesirable emis-
sions from the engine crankcase are not permit-
ted to reach the outside atmosphere. These emis-
sions are recirculated from the crankcase to the
air intake system. From here the emissions mix
with the intake air and are later burned in the engi-
ne. Catalytic converters The catalytic converters are efficient ”clean-up“
devices built into the exhaust system of the vehic-
le. The catalytic converters burn the undesirable
pollutants in the exhaust gas before it is released
into the atmosphere.
The exclusive use of unleaded fuel is critical-
ly important for the life of the catalytic con-
verters. Therefore, only unleaded fuel must
be used. The catalytic converters will be damaged by:
– push or tow starting the vehicle,
– misfiring of the engine,
– turning off the ignition while the vehicle is mo-
ving or
– driving until the fuel tank is completely empty,
– by other unusual operating conditions.
fDo not continue to operate your vehicle under
these conditions, since raw fuel might reach
the catalytic converters. This could result in
overheating of the converters. Federal law pro-
hibits use of leaded fuel in this car.
212
Maintenance, Car Care Automatic car washes
Optional add-on parts or parts which project
beyond the contours of the vehicle may be
damaged by design features (e.g. brushes) of au-
tomatic car washes.
The following parts are particularly suscep-
tible to damage:
– Convertible top (hot wax treatment cannot be
used, as the wax attacks the convertible top
material),
– Windshield wipers (always switch them off to
prevent them wiping unintentionally in intermit-
tent or sensor operation)
– External telephone antenna (always unscrew)
– Fixed rear spoiler or extended rear spoiler
– Wheels (the wider the rim and the lower the tire
height, the greater the risk of damage)
– High-gloss wheels (to prevent these from get-
ting scratched, do not clean with the wheel-
cleaning brushes of the car wash).
fPlease consult the operator before using auto-
matic car washes.
fWash and dry by hand all points not reached by
a car wash, such as door and lid seams or
door sills. Note
Automatic car washes spray water at odd angles
and high pressures, which are not seen in normal
driving. Therefore, water can sometimes find its
way into the passengers compartment during or
shortly after the car wash.
Door locks fTo prevent the door locks from freezing during
the cold season, the lock cylinders should be
covered during a wash.
fShould the locks freeze, use an ordinary de-
icer. In many cases, a well warmed key can
help.
Never use excessive force.
280
Vehicle Identification, Technical Data
Technical DataEngine data
Boxster Boxster S
Type M 96/25 M 96/26
Horizontally opposed engine, liquid cooledHorizontally opposed engine, liquid cooled
Number of cylinders 6 6
Bore 3.37 in./85.5 mm 3.66 in./93 mm
Stroke 3.07 in./78 mm 3.07 in./78 mm
Cubic capacity 163.96 cu. in./2687 cm
3 193.98 cu. in./3179 cm
3
Net-horsepower, SAE J 1349 240 hp/176 kW 280 hp/206 kW
at crankshaft speed 6400 rpm 6200 rpm
Net torque, SAE J 1349 199 ft. lb./270 Nm 236 ft. lb./320 Nm
at crankshaft speed 4700 - 6000 rpm 4700 - 6000rpm
Alternator 2100 W 2100 W
Firing order 1 - 6 - 2 - 4 - 3 - 5 1 - 6 - 2 - 4 - 3 - 5
Engine control Stationary high-voltage distribution, sequential injection,
cylinder-selective knock-control, stereo oxygen sensor closed-loop control, diagnostic system,
4 overhead camshafts, Porsche VarioCam, hydraulic valve clearance compensation
Index
295
RRadiator fans .............................................. 187
Radio reception .......................................... 155
Rain sensor ................................................ 126
Range on remaining fuel ........................93
, 114
Rear fog light .....................................124, 269
Rear lid ...................................................... 148
Rear spoiler............................................68, 69
Rear view mirrors ......................................... 31
Rear window defogger.................................. 33
Rear wing
Retractable........................................... 68
Relays ........................................................ 246
Release button ........................................... 163
Remote control ............................................. 18
Replacement key .......................................... 17
Replacing bulbs .......................................... 259
Replacing wiper blades................................ 185
Retractable spoiler........................................ 68
Rims
Diameter ............................................ 234
Rim width ........................................... 234
Running in .................................................... 14
SSafety belts ..........................................42
, 217
Warning light ........................................ 43
Safety compliance sticker ........................... 278
Sealing set ................................................. 239
Seals, care of ............................................. 215
Seat ............................................................ 34
Adjustment ........................................... 34
Heating ................................................ 38Memory................................................36
Selector lever .............................................163
Selector lever position indicator ............ 87
, 165
Shifting gear ...............................................162
Shiftlock .....................................................163
Side lights ..................................................269
Side marker light ............................... 124, 268
Side vents ..................................................136
Snow chains .............................. 232
, 283
, 284
Snow tires ......................................... 231, 282
Sockets .....................................................140
Spacers .....................................................244
Spare key .....................................................17
Spare wheel ...............................................284
Speed code letter .......................................233
Speed control .............................. 82
, 129
, 130
Speed limit .......................................... 94, 233
Speedometer................................................84
Spoiler .........................................................68
Fixed ....................................................69
Retractable ...........................................68
Sport mode ..................................... 63
, 66, 67
Sports seat ..................................................34
Stability management system (PSM) ...............64
Starting ................................................. 74, 75
Starting and stopping the engine ....................74
Steering wheel
Adjustment ...........................................39
Buttons ................................................40
Lock ................................. 74
, 75, 76, 77
Rocker switches..................................163
Toggle switches ..................................163
Stopwatch ....................................................98
Storage options ..........................................142
Storing your Porsche..................................218Sun visors ................................................... 41
TTachometer ................................................. 85
Tail light ..................................................... 269
Tank .................................................. 196
, 197
cap ................................................... 197
Ventilation system.............................. 202
Telephone .................................................. 157
Temperature setting........................... 130, 133
Temperature, outside indicator ...................... 89
Test stand, measurements ............................ 66
Theft protection ........................................... 16
Tiptronic .................................................... 163
Indicator .............................................. 87
Tire pressure monitoring ............................. 103
Tires ................................... 14
, 221
, 282
, 283
Checking pressure............................. 241
Inscription .......................................... 233
Loading information ............................ 235
Pressure................................ 5
, 224
, 283
Pressure plate.................................... 279
Sealant .............................................. 239
Sidewall ............................................. 233
Size .................................................. 233
Tires and tire care ...................................... 221
Tools ......................................................... 152
Towing .............................................. 274, 275
Track ........................................................ 282
Transmission ............................. 161
, 162
, 281
Fluid .......................................... 208, 286
Trunk entrapment ....................................... 148
Turn signals ......................................... 85, 125