2006 KIA AMANTI engine

753
Maintenance
1
2
3
4
5
6
7
8
910
EXTERIOR CARE Exterior general caution It is very important to follow the label
directions when using any chemical
cleaner or polish. Read all warning
and caution statements that appear
on the label.Finish maintenanceWashing To help protect your vehicle’s finish
from rust and deterioration, wash it
thoroughly and frequently at least
once a month with lukewarm or cold
water.
If you use your vehicle for off-road
driving, you should wash it after each
off-road trip. Pay special attention to
the removal of any accumulation of
salt, dirt, mud, and other foreign
materials. Make sure the drain holes
in the lower edges of the doors and
rocker panels are kept clear and
clean. Insects, tar, tree sap, bird droppings,
industrial pollution and similar
deposits can damage your vehicle’
s
finish if not removed immediately.
Even prompt washing with plain
water may not completely remove all
these deposits. A mild soap, safe for
use on painted surfaces, may be
used.
After washing, rinse the vehicle thor-
oughly with lukewarm or cold water.
Do not allow soap to dry on the fin-
ish.
✽ ✽ NOTICEDo not use strong soap, chemical
detergents or hot water, and do not
wash the vehicle in direct sunlight or
when the body of the vehicle is
warm.
CAUTION
Water washing in the engine
compartment may cause thefailure of electrical circuitslocated in the engine compart-ment.
 Pay extreme attention to wash
the engine compartment byusing water.
WARNING
After washing the vehicle, test
the brakes while driving slowly
to see if they have been affected
by water. If braking performance
is impaired, dry the brakes by
applying them lightly while
maintaining a slow forward
speed.

83
1
2
3
4
5
6
7
8
910
Specifications
EngineElectrical system
ItemGasoline Engine
BoreXStroke 3.66 in X 3.38 in (93 mm X 85.8 mm)
Displacement 3497 cc (213.3 cu.in)
Compression Ratio 10.0
SizeGasoline Engine
Battery 12V / 80AH (20HR)
Alternator 13.5V / 120A
Starter 12V-1.2kW
Spark Plug Gap
1.0 mm ~ 1.1 mm
Specification PFR5N-11, RC10PYPB4

Specifications48
1
2
3
4
5
6
7
8
910
Gear ratio
Tires
ItemFrontRear
Tire size 225/60R16 98H 225/60R16 98H
30 (210) 30 (210)
Wheel size 6.5J x 16 6.5J x 16
Wheel lug nut torque 65~79 65~79
lb·ft (kg·m, N·m) (9~11, 88~107) (9~11, 88~107)
Inflation pressure
psi (kPa)
Engine Gasoline Engine
Gear Automatic transaxle
1st 3.789
2nd 2.057
3rd 1.421
4th 1.039
5th 0.731
Reverse 3.865
F.G.R 3.333

85
1
2
3
4
5
6
7
8
910
Specifications
Light Bulbs1)HID(High Intensity Discharge) type2)With sunroof
* This mark indicates the filament is not used Capacities
Light Bulb
Wattage
Headlights (High/Low) 55/55 or 35
1)
Front turn signal lights (LED type) 13.2
Position lights 5
Side mark lights 5
Front fog lights (if equipped) 55
Stop and tail lights 28/8
Rear turn signal lights 28/8*
Back-up lights 16
High mounted stop light (LED type) 2.54
License plate lights 5
Front map lamp 5 or 10
2)
Center dome lamp 10
Door courtesy lamps 5
Vanity mirror lamps 3
Trunk room lamp 5
Foot lamp 5
Glove box lamp 5
LubricantVolume Classification
Engine oil
*1
4.5 qt. (4.3 l)
API Service SL or above,
(with filter change) ILSAC GF-3 or above
Transaxle
9.0 qt. (8.5 l)DIAMOND ATF SP-III,
fluid SK ATF SP-III
Power steering 1.1 qt. (1.0 l) PSF-IV
Coolant 10.8 qt.
Ethylene glycol base for
(10.2
l) aluminum radiator
Brake fluid0.7~0.8 qt.
FMVSS116 DOT-3
(
0.7~0.8
l) or DOT-4
Fuel 18.5 gal Unleaded gasoline with
(70 l) AKI 87 or higher
*¹Refer to the recommended SAE viscosity numbers on the page 7-52.

93
Consumer assistance
Registering Your Vehicle in a Foreign CountryIf you plan to register your vehicle in a foreign country,
you should confirm that it conforms to the regulations in
that country. Even if you successfully register the vehicle
in a foreign country, you may experience the following
problems and should therefore consider the possibility of
having to deal with them:
1.The fuel specified for your vehicle may be unavailable.If other than the specified fuel is used, it could cause
damage to the engine, the fuel injection system, and
other fuel-related parts which may not be covered
under your New Vehicle Emissions Limited Warranty.
2.We must, therefore, clearly state that when you leave the country in which you purchased your Kia as a new
and register it in another country, problems arising from
the use of fuel other than the specified fuel are not sub-
ject to manufacturer’s warranty. Because vehicles like
yours may not be marketed in the new country of reg-
istration, parts, servicing techniques and tools neces-
sary to maintain and repair your vehicle may be
unavailable.
Even if vehicles like yours are sold there, mechanical
specifications required by the government may vary
enough from the country of purchase to cause addi-
tional problems. 3.There may not be an Authorized Kia Dealer in the area
in which you plan to register your vehicle. You may addi-
tionally experience difficulty in obtaining services in a
foreign country for any number of reasons.
Further, we cannot assume any responsibility for prob-
lems that result from unsatisfactory service or lack of
service outside of the United States.
1
2
3
4
5
6
7
8
910

Consumer assistance49ELECTRICAL EQUIPMENTThe electrical system of your vehicle is designed to per-
form under all reasonably expected operating conditions.
However, before any additional electrical equipment is
installed in your vehicle, consult an Authorized Kia
Dealer, in order to ensure that you do not void your war-
ranty.
Certain electrical equipment, or the way in which it is
installed, may adversely affect the operation of your vehi-
cle, including such systems as the engine control system,
the audio system and the electrical charging system and
thus potentially void all or part of your warranty.
We assume no responsibility for any expense you may
incur or for any malfunction of your vehicle or any of its
components or systems that may result from the installa-
tion of additional electrical equipment that is not supplied,
or recommended for installation by, Kia.
Installation of a Mobile Two-Way Radio SystemIf a mobile two-way radio system is installed improperly,
or if an excessively powerful type of system is used, other
electronic systems may be adversely affected. To avoid
damage to your vehicle, consult an Authorized Kia Dealer
concerning the proper equipment and installation.
1
2
3
4
5
6
7
8
910

Consumer assistance69
1
2
3
4
5
6
7
8
910
PURCHASING FACTORY AUTHORIZED MANUALS (U.S. ONLY)The following publications covering the operation and
servicing of your vehicle can be obtained from Kia by call-
ing the toll-free phone number. For manuals prior to the
year shown below, call 1-866-542-6268.Valid only for sales within the U.S.. Canadian owners
should contact their Authorized Kia Dealer.
Service manual:
This manual covers maintenance and recommended pro-
cedures for repair to engine and chassis components. It
is written for the Journeyman mechanic, but is simple
enough for most mechanically-inclined owners to under-
stand.
Electrical troubleshooting manual:
This manual complements the Service Manual by provid-
ing in-depth troubleshooting information for each electri-
cal circuit in your vehicle.
Owner’s manual:
This manual describes the overall features and operating
procedures for the vehicle.
Amanti
UH060 PS 010
UH060 PS 011
UH060 PS 013
Amanti
Amanti
6
6
6
89.0049.0020.00
ORDER TOLL FREE: 1-866-542-6268
(NOTE: For Credit Card Holder Orders Only)
Monday-Friday 8:00 A.M. - 6:00 P.M. EST
MINIMUM CREDIT CARD PURCHASE $10.00

10 3
Index
Catalytic Converters, Operating Precautions for . . . . . 5-4
ChainsTire . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
5-10
Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-16
Charging System Warning . . . . . . . . . . . . . . . . . . . . . 4-37
Check Engine (Malfunction Indicator) Light . . . . . . . 4-40
Child Restraint System . . . . . . . . . . . . . . . . . . . . . . . . . . 3-50
Safety lock, rear door . . . . . . . . . . . . . . . . . . . . . . . 3-12
Children Restraint of Infants and Small . . . . . . . . . . . . . . . . 3-48
Restraint of Larger . . . . . . . . . . . . . . . . . . . . . . . . . 3-49
Cigarette Lighter . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-102
Cleaner, Air . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-29
Cleaning Interior Window Glass . . . . . . . . . . . . . . . . . . . . . . 7-57
Lap/Shoulder Belt Webbing . . . . . . . . . . . . . . . . . . 7-57
Upholstery and Interior Trim . . . . . . . . . . . . . . . . . 7-57
Clock Analog . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-106
Digital . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-107
Cluster, Instrument . . . . . . . . . . . . . . . . . . . . . . 4-32, 4-33
Compartment, Engine . . . . . . . . . . . . . . . . . . . . . . . . 7-14
Console Storage, center . . . . . . . . . . . . . . . . . . . . . . . 3-99
Consumer Assistance (U.S. only) . . . . . . . . . . . . . . . . 9-1
Coolant, Changing . . . . . . . . . . . . . . . . . . . . . . . . . . 7-29
Coolant Level, Checking the . . . . . . . . . . . . . . . . . . . 7-18
Cooling System, Engine . . . . . . . . . . . . . . . . . . . . . . 7-18
Cruise Control system . . . . . . . . . . . . . . . . . . . . . . . . 4-21
Cup Holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-103 Day/Night Rearview Mirror . . . . . . . . . . . . . . . . . . . 3-94
Defrost Button . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-61
Defroster
Rear Window . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-52
Digital Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-107
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-2
Disc Brake Wear Indicators . . . . . . . . . . . . . . . . . . . . 4-12
Dome Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3-97
Door Ajar Warning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-40
Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
3-9
Locks from inside the vehicle, operating . . . . . . . . 3-11
Locks from outside the vehicle, operating . . . . . . . . 3-9
Child safety lock, rear . . . . . . . . . . . . . . . . . . . . . . 3-12
Drive belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-23
Driver position memory system . . . . . . . . . . . . . . . . . 3-34
Driving At Night . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-8
Conditions, Special . . . . . . . . . . . . . . . . . . . . . . . . . 5-7
Conditions, Hazardous . . . . . . . . . . . . . . . . . . . . . . . 5-7
In Flooded Areas . . . . . . . . . . . . . . . . . . . . . . . . . . 5-12
In the Rain . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-8
Tips . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. 5-1
Your Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4-1
Winter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-9
Dual Temperature Control Selection Button . . . . . . . 4-56
1
2
3
4
5
6
7
8
910
D