2006 FORD MONDEO maintenance

Downloaded from www.Manualslib.com manuals search engine OPENING AND CLOSING
THE BONNET
Opening the bonnet
WARNING
Remove the key immediatelyafter opening the bonnet.
The bonnet must be opened fromthe outside.
Swivel the Ford badge in the radiatorgrille to the side. Insert the key in thelock on the radiator grille.
Turn the key first anticlockwise 1.Raise the bonnet slightly and turn thekey fully clockwise 2 to open thebonnet. It is held by gas filled liftcylinders.
Closing the bonnet
To close, lower the bonnet and allowit to drop into the catch for the last20 – 30 cm.
Always check to ensure that thebonnet lock is fully engaged.
ENGINE OIL CHECK
WARNING
Do not use oil additives or otherengine treatments. They areunnecessary and could, undercertain conditions, lead to enginedamage which is not covered byFord Warranty.
The oil consumption of new enginesreaches the normal value only afterapproximately 5 000 km (3 000miles).
149
MaintenanceE73406 E73407

Downloaded from www.Manualslib.com manuals search engine Make sure the vehicle is standing onlevel ground. Check the engine oilbefore starting the engine. If theengine was running, switch it off andwait some minutes for the engine oilto flow back into the sump beforechecking it. Pull out the dipstick, wipeit with a clean, non-fluffy cloth,re-insert it completely and pull it outonce more.
If the level is between the marks,there is no need to refill. Hot oil mayexceed the MAX mark by a fewmillimetres due to thermal expansion.
If the level is at the MIN mark, refillusing only engine oil meeting theFord specification. Approximately0.5-1.5 litres (depending on engine)of engine oil will raise the level of theoil film on the dipstick from the MINto the MAX mark.
Duratec-HE/SCiA
Duratec-VE/STB
Duratorq-TDDi/TDCiC
Top up to only the upper mark (MAX).
150
MaintenanceE73412

Downloaded from www.Manualslib.com manuals search engine Engine oil filler cap
To open, turn anti-clockwise and pullup. Do not open the cap while theengine is running.
To close, turn the cap clockwise untilit clicks.
Engine oil change
Use Ford/Motorcraft Formula ESAE 5W-30 engine oil. Alternativeengine oils with the viscosity SAE5W-30 meeting the requirementsof Ford SpecificationWSS-M2C913-B may also beused.
Engine oil top-up
If you are unable to find an oil thatmeets any of these specifications,you must use an oil of the viscositySAE 5W-30, SAE 10W-40 or SAE5W-40, according to outsidetemperatures, meeting therequirements of either ACEA A1/B1or ACEA A3/B3 specifications. Useof these oils may result in longercranking periods, reduced engineperformance, reduced fuel economy,and increased emission levels.
ENGINE COOLANT
CHECK
151
MaintenanceE73413 E73415

Downloaded from www.Manualslib.com manuals search engine WARNING
To avoid scalding, never removethe cap from the coolantreservoir when the engine is hot. Donot restart the engine until theproblem has been eliminated.
The coolant level is visible throughthe translucent reservoir. The coolantlevel should be between the MINand the MAX mark when the engineis cold. Hot coolant expands andmay, therefore, extend beyond theMAX mark.
WARNING
Take great care when addingcoolant. Avoid spillage on anypart of the engine.
The coolant should be added whenthe engine is cold. If coolant has tobe added when the engine is hot, firstwait 10 minutes for the engine tocool. Unscrew the cap slowly. Anypressure will escape while you areturning the cap. Fully remove the cap.
WARNING
Do not allow this fluid to makecontact with the skin or eyes. Ifthis should happen rinse the affectedareas immediately with plenty ofwater and contact your doctor.
When the vehicle is new, the coolingsystem is filled with coolant whichoffers anti−freeze protection downto approximately –25 ºC.
Add coolant that meets the FordSpecification.
AUTOMATIC
TRANSMISSION FLUID
CHECK
Your dealer checks the fluid level inthe automatic transmission whencarrying out routine maintenancework on your vehicle.
BRAKE AND CLUTCH
FLUID CHECK
WARNING
Do not allow this fluid to makecontact with the skin or eyes. Ifthis should happen rinse the affectedareas immediately with plenty ofwater and contact your doctor.
Brake and clutch fluid systems aresupplied from the same reservoir.
The level of the fluid must bebetween the MIN and MAX markson the side of the reservoir.
152
MaintenanceE73414

Downloaded from www.Manualslib.com manuals search engine POWER STEERING FLUID
CHECK
The fluid level should come up to theMAX mark when the engine is cold.
If it drops below the MIN mark, topup with the specified fluid.
WASHER FLUID CHECK
Front and rear washer systems aresupplied from the same reservoir.The reservoir is located behind theright-hand headlamp.
Replace the cap securely aftertopping up.
Washer jets
To ensure the system functionsproperly, keep the washer jets freeof snow and ice.
Switching on the heated windscreendefrosts both the windscreen andthe front washer jets.
153
MaintenanceE73416 E73422

Downloaded from www.Manualslib.com manuals search engine TECHNICAL SPECIFICATIONS
Vehicle fluids
SpecificationRecommended fluidPart
WSS-M2C204-AFord Power Steering FluidPower assisted steering
WSS-M97B44-DMotorcraft SuperPlusAntifreezeCoolant
Capacities
Vehicles with a petrol engine
Capacities
Capacity inlitres (gallons)ItemVariant
Max-markPower assisted steering fluidAll
58.5 litresFuel tankAll
4.3 litresEngine oil - with filter1.8 l Duratec-HE
3.9 litresEngine oil - without filter1.8 l Duratec-HE
8.3 litresCooling system including heating1.8 l Duratec-HE
6.6 litresWindscreen washer system - withheadlamp washer1.8 l Duratec-HE
2.6 litresWindscreen washer system -without headlamp washer1.8 l Duratec-HE
4.3 litresEngine oil - with filter1.8 l Duratec-SCi
3.9 litresEngine oil - without filter1.8 l Duratec-SCi
8.3 litresCooling system including heating1.8 l Duratec-SCi
5.0 litresWindscreen washer system - withheadlamp washer1.8 l Duratec-SCi
2.5 litresWindscreen washer system -without headlamp washer1.8 l Duratec-SCi
4.3 litresEngine oil - with filter2.0 l Duratec-HE
3.9 litresEngine oil - without filter2.0 l Duratec-HE
8.1 litresCooling system including heating2.0 l Duratec-HE
6.5 litresWindscreen washer system - withheadlamp washer2.0 l Duratec-HE
154
Maintenance

Downloaded from www.Manualslib.com manuals search engine Capacity inlitres (gallons)ItemVariant
2.6 litresWindscreen washer system -without headlamp washer2.0 l Duratec-HE
5.7 litresEngine oil - with filter2.5 l Duratec-VE
5.2 litresEngine oil - without filter2.5 l Duratec-VE
9.5 litresCooling system including heating2.5 l Duratec-VE
6.5 litresWindscreen washer system - withheadlamp washer2.5 l Duratec-VE
2.6 litresWindscreen washer system -without headlamp washer2.5 l Duratec-VE
5.7 litresEngine oil - with filter3.0 l Duratec-VE/ST
5.2 litresEngine oil - without filter3.0 l Duratec-VE/ST
9.5 litresCooling system including heating3.0 l Duratec-VE/ST
6.5 litresWindscreen washer system - withheadlamp washer3.0 l Duratec-VE/ST
2.6 litresWindscreen washer system -without headlamp washer3.0 l Duratec-VE/ST
Vehicles with a diesel engine
Capacities
Capacity in litres(gallons)ItemVariant
Max-markPower assisted steering fluidAll
58.5 litresFuel tankAll
6.0 litresEngine oil - with filterAll
5.8 litresEngine oil - without filterAll
10.6 litresCooling system including heating - withauxiliary heaterAll
10.4 litresCooling system including heating - withoutauxiliary heaterAll
6.5 litresWindscreen washer system - withheadlamp washerAll
2.6 litresWindscreen washer system - withoutheadlamp washerAll
155
Maintenance

Downloaded from www.Manualslib.com manuals search engine BATTERY CARE
The battery requires very littlemaintenance. The fluid level ischecked regularly during the routineservice inspections.
USING BOOSTER
CABLES
Connect batteries with only the samenominal voltage (12 volts). Usebooster cables with insulated clampsand adequate size cable. Do notdisconnect the battery from thevehicle’s electrical system.
To connect the boostercables
Flat batteryA
Booster batteryB
•Position the vehicles so that theydo not touch one another.
•Switch off the engine and anyelectrical equipment.
158
Vehicle batteryE73405