2006 FIAT STILO fuel filter

213
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
ANNUAL INSPECTION
SCHEDULE
For cars with an annual mileage of below
30.000 km (for example about 15.000 km)
the following yearly inspection programme
is advised:
❒check tyre conditions/wear and adjust
pressure if required (including the
space-saver spare wheel);
❒check light system operation (head-
lights, direction indicators, hazard lights,
boot lights, passenger compartment
lights, glovebox light, warning lights,
etc.);
❒check windscreen wiper/washer oper-
ation, adjust nozzles;
❒check windscreen/rear window blade
position/wear;
❒ check front disk brake pad conditions
and wear;
❒sight inspect the conditions of: engine,
gearbox, transmission, pipes and hoses
(exhaust - fuel - brakes), rubber parts
(boots, sleeves, bushes, etc.) fuel and
brake system hoses;
❒check cleanness of bonnet and boot
locks, and lever cleanness and lubrica-
tion
❒check battery charge (by optical depth
gauge);
❒visual check on various drive belt con-
ditions;
❒check and top up fluid levels (engine
coolant, brakes, windscreen washer,
battery, etc.);
❒change engine oil and oil filter, if re-
quired (Multijet versions);
❒replace pollen filter.
ADDITIONAL CHECKS
Every 1,000 km or before long journeys,
check and top up if required:
❒engine coolant fluid level;
❒ brake fluid level;
❒ windscreen washer fluid level;
❒tyre pressure and conditions.
Every 3,000 km check and top up if re-
quired: engine oil level.
You are recommended to use FL Sele-
niaproducts, designed and produced
specifically for Fiat cars (see table “Ca-
pacities” in section “Technical specifica-
tions”).

215
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
IMPORTANT - Battery
The charge in the battery should be
checked at the start of winter to limit the
risk of electrolyte freezing.
This check should be carried out more
frequently if the car is used mainly for
short trips, or if it is fitted with accessories
that permanently absorb electricity even
with the ignition key removed, especially
in the case of after market accessories. If
the car is used in hot climates or particu-
larly harsh conditions it is wise to check
the level of the battery fluid (electrolyte)
more frequently than specified in the “Ser-
vice schedule”. IMPORTANT - Pollen filter
If the car is used frequently in dusty or
heavily polluted environments it is advis-
able to replace the filtering element more
frequently; in particular it should be re-
placed if a reduction of the amount of air
admitted to the passenger compartment
is noted.
IMPORTANT - Diesel filter
The possibility of topping up with diesel
fuel not complying with EN590 European
Norm might make it necessary to replace
the filter more frequently than indicated
in the “Service Schedule”.Car maintenance should be
entrusted to Fiat Dealership.
For routine and minor main-
tenance operations you wish
to carry out yourself, always make sure
you have the proper equipment, gen-
uine Fiat spare parts and the necessary
fluids; do not however carry out these
operations if you have no experience.

225
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
AIR FILTER
Air filter replacement shall be carried out
at a Fiat Dealership.
POLLEN FILTER
Pollen filter replacement shall be carried
out at a Fiat Dealership.
DIESEL FUEL FILTER
DRAINING THE CONDENSE
(Multijet versions)
IMPORTANT The presence of water in
the fuel circuit can severely damage the
whole injection system and make the en-
gine misfire. If the warning light
cturns
on (together with the message on the dis-
play), contact a Fiat Dealership as soon
as possible to have the bleeding operation
carried out.

CAPACITIES
257
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
1.416V1.616V1.816V2.420V
Fuel tank:
including a reserve of:
Engine cooling
system
– with climate control:
Engine sump:
Engine sump and filter:
Gearbox/differential casing:
Selespeed transmission
hydraulic system
(where provided):
Hydraulic brake circuit
with ABS:
Windscreen /
rear window / headlight
washer fluid reservoir: (*)
(*) The values in brackets refer to versions with headlight washers.Recommended products and
genuine lubricants
Unleaded petrol
with no less than 95 R.O.N
(Specification EN228)
Mixture of 50% demineralised
water and 50%
PARAFLU UP
SELENIA K
(versions 1.4
16V, 1.616Vand 1.816V)
SELENIA RACING
(versions 2.4
20V)
TUTELA CAR TECHNYX
TUTELA CAR
CS SPEED
TUTELA TOP 4
Mixture of water and
TUTELA PROFESSIONAL
SC 35 litres
58
9
–
2.5
2.8
1.87
–
–
3 (6)kg
–
–
5.25
2.2
2.5
1.7
–
0.525
–litres
58
9
–
4.3
4.5
1.65
–
–
3 (6)kg
–
–
6.55
3.9
4.0
1.5
–
0.525
–litres
58
9
–
3.7
4.2
1.98
–
–
3 (6)kg
–
–
7.3
3.3
3.7
1.8
–
0.525
–litres
58
9
–
4.5
4.7
1.76
0.8
–
3 (6)kg
–
–
8.3
3.9
4.0
1.6
0.73
0.525
–

258
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
1.9 Multijet 8V1.9 Multijet 16V
Fuel tank:including a reserve of:
Engine cooling system
– with climate control:
Engine sump:
Engine sump and filter:
Gearbox/differential casing:
Hydraulic brake circuit
with ABS:
Windscreen /
rear window / headlight
washer fluid reservoir: (*)
(*) The values in brackets refer to versions with headlight washers.litres
58
9
–
4.4
4.7
1.76
–
3 (6)kg
–
–
7.3
3.8
4.0
1.6
0.525
–litres
58
9
–
4.4
4.7
1.87
–
3 (6)kg
–
–
7.3
3.8
4.0
1.7
0.525
–Recommended products and
genuine lubricants
Diesel fuel formotor vehicles
(Specification EN590)
Mixture of 50% demineralised
water and 50% PARAFLU UP
SELENIA WR
TUTELA CAR TECHNYX
TUTELA TOP 4
Mixture of water and
TUTELA PROFESSIONAL
SC 35

264
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
– types of bulbs .................................. 182
Capacities .............................................. 257
Car inactivity.......................................... 156
Car maintenance............................. 209
– additional checks ............................ 213
– annual Inspection Schedule .......... 213
– scheduled service ........................... 210
– Service Schedule ............................. 211
Cargo box .............................................. 91
Carrying children safely ...................... 116
Ceiling lights ......................................... 67
Central door locking system ............ 79
Checking fluid levels ........................... 216
Child lock .............................................. 79
Child restraint systems
(specifications for use) .................... 119
Cigar lighter .......................................... 72
Climate control system
– automatic two-zone
climate control system ................ 51
– manual climate control system .. 48
CO
2emissions ..................................... 263
Code Card ............................................ 10
Containing running costs ................... 149Controls ................................................ 68
Correct use of the car................. 135
Courtesy mirror light
(bulb replacement) ............................ 194
Cruise Control .................................... 65
Current outlet....................................... 72
Cut-off switch fuel .............................. 69
Dashboard............................................. 5
Dashboard and controls.............. 4
Daylight sensor .................................... 61
Dead lock (device) .............................. 14
Diesel fuel filter ..................................... 225
Diesel particulate filter (DPF) ........... 108
Dimensions ........................................... 250
Dipped beam headlights...................... 59
Direction indicators
– control ............................................. 60
– front bulb replacement ................ 186
– rear bulb replacement ................. 188
– side bulb replacement .................. 186
Doors ..................................................... 79
Dualdrive (electric power steering) 102
Easy entry ............................................ 38
ABS ........................................................ 95
Accessories purchased
by the owner ......................................... 101
Air bags
– front................................................... 126
– side..................................................... 130
Air filter .................................................. 225
Armrests (front rear) .......................... 70
Ashtray .................................................... 72
ASR .......................................................... 98
At the filling station .............................. 105
Automatic headlights sensor
(daylight sensor) ................................. 611
Battery
– checking the charge ....................... 226
– jump starting.................................... 170
– replacing .......................................... 227
Bodywork ............................................... 233
Bonnet ..................................................... 92
Boot ......................................................... 81
Boot light (bulb replacement) ........... 195
Brake Assist ........................................... 96
Brakes ...................................................... 244
Bulb (replacement)............................... 181
I I
N N
D D
E E
X X

265
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
Gearbox
– using manual gearbox .................. 140
– using Selespeed gearbox ............. 141
Glass holder .......................................... 73
Glove box light
(bulb replacement) ............................ 194
Glove box/oddment
compartments ................................... 71
Handbrake ........................................... 139
Hazard lights ......................................... 68
Head restraints ..................................... 41
Headlight washer .................................. 65
Headlights ............................................... 94
Heating and ventilation system ..44-46
Identification data ............................... 238
If an exterior light burns out ............. 184
If an interior light burns out .............. 192
Ignition switch ...................................... 20
In an emergency............................. 169
Independent additional heater ......... 56
Installation of electric/
electronic devices .............................. 101
Instrument panel ................................. 6
Instruments ........................................... 21
Interior fittings ..................................... 70
Interiors ................................................. 235Isofix (child restraint system) ........... 121
Jacking the car ..................................... 206
Keys ....................................................... 10
Load limiters ....................................... 113
Main beam headlights......................... 59
MSR (system) ....................................... 99
Multifunction display ........................... 23
Number plate lights
(bulb replacement) ............................ 191
OCS
(Occupant Classification System) .. 129
Oddment compartments .................. 73
Paint ...................................................... 233
Parking ................................................... 139
Parking lights ......................................... 69
Parking sensors .................................... 103
Performance ......................................... 253
Pollen filter ............................................ 225
Power windows ................................... 80
Presetting for mounting the
“Isofix ” child restraint system ...... 121 Electric power steering “Dualdrive” .. 102
Electronic alarm ................................... 17
Engine
– identification code ........................ 240
– technical data ......................... 241-242
Engine compartment
– washing ............................................ 234
Engine oil
– consumption .................................. 220
Environment protection .................... 108
EOBD (system) .................................... 99
ESP (system) ......................................... 97
External lights ....................................... 59
Fiat CODE (system) .......................... 8
Fire extinguisher .................................. 208
Fix&Go automatic ............................... 177
Flashing the headlights ........................ 59
Fluid level checks ................................. 216
Fluids and lubricants ........................... 259
Follow me home (device) ................. 60
Front fog lights ............................... 68-69
– (bulb replacement)......................... 186
Fuel consumption ................................. 261
Fuel feed/ignition ................................. 241
Fuel filler cap ........................................ 106
Fuses (replacement) ........................... 196

ENGINE OIL CHANGE
1.416V - 1.616V- 1.816V- 2.420V- 1.9 Multijet 8V - 1.9 Multijet 16V
Tank capacity58
Reserve9
Only refuel cars with petrol engines with unleaded petrol with octane rating (RON) not less than 95.
Only refuel cars with diesel engines with diesel fuel for motor vehicles conforming to the EN590 European Specification.
REFUELLING (litres)
195/65 R15 91T
205/55 R16 91V
195/65 R15 91H (❒)
215/45 R17 87W
195/65 R15 91H
205/55 R16 91V
215/45 R17 87W
195/65 R15 91V
205/55 R16 91V
215/45 R17 87W
205/55 R16 91W
215/45 R17 87W1.9
2.1
1.9
2.3
1.9
2.1
2.3
1.9
2.1
2.3
2.1
2.31.9
2.1
1.9
2.3
1.9
2.1
2.3
1.9
2.1
2.3
2.1
2.32.1 - 2.3 (❒)/3.0 (**)
2.3
2.1 - 2.3 (❒)/3.0 (**)
2.7
2.1 - 2.3 (❒)/3.0 (**)
2.3
2.7
2.1 - 2.3 (❒)/3.0 (**)
2.3
2.7
2.3
2.72.1 - 2.3 (❒)/3.0 (**)
2.3
2.1 - 2.3 (❒)/3.0 (**)
2.5
2.1 - 2.3 (❒)/3.0 (**)
2.3
2.5
2.1 - 2.3 (❒)/3.0 (**)
2.3
2.5
2.3
2.54.2
4.2
4.2
4.2 1.4
16V
1.9 Multijet 8V1.616V
1.816V1.9 Multijet 16V
2.420V
VERSIONS STANDARD TYRES SPARE
Size Medium load Full load WHEEL
Front Rear Front Rear
Fiat Auto S.p.A.
Quality - Assistenza Tecnica - Ingegneria Assistenziale
Largo Senatore G. Agnelli, 5 - 10040 Volvera - Torino (Italia)
Print No. 603.81.012 - XI/2006 - 2
ndEdition
1.416V1.616V1.816V2.420V1.9 Multijet8V1.9 Multijet 16V
litres kg litres kg litres kg litres kg litres kg
Engine sump 2.5 2.2 4.3 3.9 3.7 3.3 4.5 3.9 4.4 3.8
Engine sump and filter 2.8 2.5 4.9 4.4 4.2 3.7 4.7 4.0 4.7 4.0
(❒) Multi Wagon Versions
(**) Under maximum load conditions = 510 kg (comprising driver’s weight. special equipment and the remaining load distributed over the rear pulled down seats).