2006 FIAT MULTIPLA check engine light

209
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
CAR
MAINTENANCE
PERIODICAL CHECKS
Every 1,000 km or before long journeys, check and top
up if required:
❒engine coolant fluid level;
❒brake fluid level;
❒windscreen washer fluid level;
❒tyre pressure and conditions.
❒check light system operation (headlights, direction
indicators, hazard lights, etc.);
❒check windscreen wiper/washer operation and
windscreen/rear window blade position/wear;Every 3,000 km check and top up if required: engine
oil level.
You are recommended to use FL Seleniaproducts,
designed and produced specifically for Fiat cars (see
table “Capacities” in section “Technical
specifications”).

210
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
USE OF THE CAR UNDER
HEAVY CONDITIONS
Should prevailing use of the car be under one of the
following specially heavy conditions:
❒trailer or caravan towing;
❒dusty roads;
❒short distances (less than 7-8 km) and repeated
with external temperatures below zero;
❒frequently idling engines or long distance low
speed driving (e.g.: door-to-door deliveries) or in
case of a long term inactivity;
❒urban routes;carry out checks more frequently than required on
Service Schedule:
❒check front disk brake pad conditions and wear;
❒check cleanness of bonnet and boot locks and
lever cleanness and lubrication;
❒sight inspect the conditions of: engine, gearbox,
transmission, pipes and hoses (exhaust - fuel -
brakes), rubber parts (boots, sleeves, bushes, etc.);
❒check battery charge and fluid level (electrolyte);
❒visual check on various drive belt conditions;
❒check and replace pollen filter, if required;
❒check and replace air cleaner, if required.

211
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
CAR
MAINTENANCE
CHECKING
FLUID LEVELS
1. Engine oil
2. battery
3. brake fluid
4. windscreen washer fluid
5. engine coolant
6. power steering fluid.
F0E0680m100 16Vversions
WARNINGNever smoke while working in the engine compartment; gas and inflammable
vapours may be present, with the risk of fire.
When topping up take care not to confuse the various types of fluids: they are all incompatible
with one another and could seriously damage the car.

213
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
CAR
MAINTENANCE
ENGINE OIL
The engine oil level must be checked with the car on level ground and
while the engine is still hot (approximately 5 minutes after turning it off).
❒Remove the dipstick.
❒Clean it with a cloth that does not leave threads or other impurities.
❒Put the dipstick into its seat pushing it down.
❒Take it out, the oil level shall be between the MIN and MAX marks on
the dipstick.
The space between the MIN and MAX marks corresponds to about one
litre of oil.
If the oil level is near or even below the MIN mark, add oil through the
filler neck until reaching the MAX mark.
Oil level shall never exceed the MAX mark.
F0E0166m
F0E0167m
100 16v version
JTD 120 version

215
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
CAR
MAINTENANCEUsed engine oil and filter contain harmful substances for the environment. Contact Fiat Dealership
to have the oil and filter changed, as they are equipped to dispose of the waste oil and filters
respecting the nature and the law. IMPORTANT After adding or changing the oil, let the
engine turn over for a few seconds and wait a few
minutes after turning it off before you check the level.
Do not add oil with specifications other than that already in the engine.
IMPORTANT If a routine check reveals that the oil
level is above the MAX mark, contact Fiat Dealership
to have the correct level restored.

216
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
ENGINE COOLANT
The coolant level shall be checked with cold engine and shall be between
the MIN and MAX marks on the reservoir.
If the level is low, pour slowly a mixture of 50% water and 50% FL
Selenia PARAFLU UP through the filler neck until reaching the MAX
mark.
A 50-50 mixture of PARAFLU UP and water gives freeze protection to
–35°C.
F0E0682m
The engine cooling system uses PARAFLU UP fluid, top up only with fluid of the same type.
PARAFLU UP cannot be mixed with other types of fluid; if mixed, do nor start the engine and
contact Fiat Dealership immediately.
WARNINGThe cooling system is pressurised. If necessary, replace the cap only with
another genuine one, otherwise system efficiency could be compromised.
Do not remove the reservoir cap when the engine is hot: you risk scalding
yourself.

218
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
CAR
MAINTENANCE
POWER STEERING FLUID
Check that the fluid level is between the MIN and MAX marks on the
reservoir with the car parked on level ground and engine cold.
When the oil is hot the level may exceed the MAX mark.
If necessary add oil making sure that it has the same specifications as the
oil already in the system.
F0E0684m
The oil consumption is very low; if, after topping up it becomes necessary to top up again quite
soon after, have the system checked by Fiat Dealership for any leaks.
WARNINGDo not allow the power steering fluid to come into contact with the hot parts of
the engine: it is inflammable.

221
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
CAR
MAINTENANCE
DIESEL FUEL FILTER
DRAINING THE CONDENSE (diesel versions)
IMPORTANT The presence of water in the fuel circuit
can severely damage the injection system and make
the engine misfire. If the warning light
cturns on,
contact a Fiat Dealership as soon as possible to have
the bleeding operation carried out.
If the warning light comes on immediately after
refuelling, water is probably present in the tank: turn
the engine off immediately and contact Fiat Dealership.
BATTERY
Fiat Multipla battery is of the “Limited maintenance”
type: under normal conditions of use it does not
require topping up with distilled water.
CHECKING THE BATTERY FLUID LEVEL
(electrolyte)
Check the electrolyte level (and top up if required) at
the intervals shown in the Service Schedule in this
section. Have this operation carried out at Fiat
Dealership.
Batteries contain substances that are very harmful for the environment. You are advised to have
the battery changed at a Fiat Dealership, which is properly equipped for disposing of used batteries
respecting nature and law.
The liquid in the battery is poisonous and corrosive. Avoid contact with eyes and
skin. Do not bring naked flames or possible sources of sparks near to the battery:
risk of fire and explosion.WARNING