2006 DODGE VIPER cooling

WARNING!
•The warning words “DO NOT OPEN HOT” on
the cooling system pressure cap are a safety pre-
caution. Never add coolant when the engine is
overheated. Do not loosen or remove the cap to
cool an overheated engine. Heat causes pressure
to build up in the cooling system. To prevent
scalding or injury, do not remove the pressure cap
while the system is hot or under pressure.
•Do not use a pressure cap other than the one
specified for your vehicle. Personal injury or
engine damage may result.
Disposal of Used Engine Coolant
Used ethylene glycol based engine coolant is a regulated
substance requiring proper disposal. Check with your
local authorities to determine the disposal rules for your
community. To prevent ingestion by animals or childrendo not store ethylene glycol based engine coolant in open
containers or allow it to remain in puddles on the
ground. If ingested by a child, contact a physician
immediately. Clean up any ground spills immediately.
Coolant Level
The coolant bottle provides a quick visual method for
determining that the coolant level is adequate. With the
engine idling, and warm to normal operating tempera-
ture, the level of the coolant in the bottle should be
between the ranges indicated on the bottle.
The radiator normally remains completely full, so there is
no need to remove the radiator cap unless checking for
coolant freeze point or replacing coolant. Advise your
service attendant of this. As long as the engine operating
temperature is satisfactory, the coolant bottle need only
be checked once a month.
MAINTAINING YOUR VEHICLE 193
7

When additional coolant is needed to maintain the
proper level, it should be added to the coolant bottle. Do
not overfill.
Points to Remember
NOTE:When the vehicle is stopped after a few miles (a
few kilometers) of operation, you may observe vapor
coming from the front of the engine compartment. This is
normally a result of moisture from rain, snow, or high
humidity accumulating on the radiator and being vapor-
ized when the thermostat opens, allowing hot coolant to
enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant recovery bottle.
•Check coolant freeze point in the coolant bottle. If
antifreeze needs to be added, contents of the coolant
bottle also must be protected against freezing.
•If frequent coolant additions are required, or if the
level in the coolant recovery bottle does not drop when
the engine cools, the cooling system should be pres-
sure tested for leaks.
•Maintain coolant concentration at 50% HOAT engine
coolant (minimum) and distilled water for proper
corrosion protection of your engine which contains
aluminum components.
•Make sure that the radiator and coolant recovery
bottle overflow hoses are not kinked or obstructed.
•Keep the front of the radiator clean. If your vehicle is
equipped with air conditioning, keep the front of the
condenser clean, also.
194 MAINTAINING YOUR VEHICLE

FLUIDS AND CAPACITIES
U.S. Metric
Fuel (approximate)
8.3 Liter Engine (Premium 91
Octane)18.2 gallons 68.9 liters
Engine Oil-With Filter
8.3 Liter Engines (SAE 0W-40) 10 qts. 9.5 Liters
Cooling System *
8.3 Liter Engines* (Mopar
Antifreeze/Coolant 5 Year/
102,000 Mile Formula) or
equivalent.16 qts. 15 Liters
* Includes heater and coolant recovery bottle filled to
MAX level.
220 MAINTAINING YOUR VEHICLE

Chains, Tire............................ 147
Charging System Light..................... 94
Chart, Tire Sizing........................ 131
Check Engine Light (Malfunction Indicator Light) . 170
Checks, Safety........................... 53
Child Restraint........................36,41
Child Restraint Tether Anchors............... 39
Circuit Breakers......................... 203
Clean Air Gasoline....................... 149
Climate Control......................... 111
Clock................................. 97
Compact Disc Maintenance................. 110
Console............................... 68
Console, Floor........................... 68
Contract, Service........................ 244
Converter, Catalytic...................... 176
Convertible............................. 57
Convertible Boot.......................61,66
Convertible Top.......................57,202Convertible Top Maintenance............... 202
Coolant Pressure Cap..................... 192
Cooling System......................... 190
Adding Coolant (Antifreeze).............. 192
Coolant Capacity...................... 220
Coolant Level......................190,193
Disposal of Used Coolant................ 193
Drain, Flush, and Refill.................. 191
Inspection........................... 193
Points to Remember.................... 194
Pressure Cap......................... 192
Radiator Cap......................... 192
Rubber and Plastic Components............ 195
Selection of Coolant (Antifreeze)......191,220,221
Crankcase Emission Control System.......... 178
Customer Assistance..................... 242
Daytime Running Lights................... 78
Dealer Service.......................... 171
252 INDEX

Defroster, Windshield...................... 53
Delay (Intermittent) Wipers................. 85
Diagnostic System, Onboard................ 169
Dimmer Control......................... 77
Dimmer Switch, Headlight.................. 80
Disposal
Antifreeze (Engine Coolant)............... 193
Door Locks............................. 14
Door Locks, Automatic.................... 16
Doors................................. 14
Drive Belts............................ 176
Driving
On Slippery Surfaces.................... 162
Electric Remote Mirrors.................... 70
Emergency Brake........................ 124
Emergency, In Case of
Freeing Vehicle When Stuck............... 163
Hazard Warning Flasher................. 156Jump Starting......................... 158
Overheating.......................... 156
Towing............................. 163
Emission Control System Maintenance......170,226
Engine............................... 168
Break-In Recommendations................ 52
Checking Oil Level..................... 172
Compartment......................... 168
Coolant (Antifreeze).................190,221
Cooling...........................94,190
Exhaust Gas Caution................26,53,151
Fails to Start.......................... 120
Fuel Requirements..................148,220
Oil ...........................172,220,221
Oil Change Interval.................... 173
Oil Disposal.......................... 175
Oil Filter............................ 175
Oil Selection.......................174,220
Overheating........................94,156
INDEX 253
10

Engine Oil Viscosity...................174,220
Engine Oil Viscosity Chart................. 174
Exhaust Gas Caution..............26,53,151,189
Exhaust System......................... 189
Exterior Lights....................... 211,212
Fan .................................. 112
Filters
Air Cleaner.......................... 179
Engine Oil........................... 221
Flashers
Hazard Warning.....................91,156
Turn Signal........................... 91
Flash-To-Pass........................... 80
Floor Console........................... 68
Fluid Capacities......................... 220
Fluid Leaks............................. 54
Fluid Level Checks
Brake............................197,222Capacities........................... 220
Cooling System....................... 190
Engine Oil........................... 172
Manual Transmission................... 199
Power Steering.....................185,222
Fluids................................ 221
Fluids, Lubricants and Genuine Parts.......... 221
Fog Lights.........................78,79,94
Four-Way Hazard Flasher.................. 156
Freeing A Stuck Vehicle................... 163
Fuel................................. 148
Adding............................. 152
Additives............................ 150
Clean Air............................ 149
Gasoline............................ 148
Gauge............................... 97
Octane Rating........................ 221
Requirements......................148,220
Tank Capacity........................ 220
254 INDEX