2006 DODGE SPRINTER cooling

MAINTAINING YOUR VEHICLE 263
7
A regular check is included in the maintenance service.
Checking Coolant Level
Pressure cap on coolant reservoir (1)
The cooling system is pressurized. Only check the
coolant level with the vehicle parking on a level surface
and with the engine switched off.
– Wait until the coolant temperature has dropped
below 194 °F (+90 °C).
WARNING!
In order to avoid any possibly serious burns:
 If you see flames or smoke coming from the
engine compartment, or if the coolant
temperature gauge indicates that the engine is
overheated, do not open the hood. Move away
from the vehicle and do not open the hood until
the engine has cooled. If necessary, call the fire
department.
 Do not remove pressure cap on coolant reservoir
if engine temperature is above 194 °F (+90 ×C).
Allow engine to cool down before removing cap.
The coolant reservoir contains hot fluid and is
under pressure.
 Using a rag, slowly open cap approximately 1/2
turn to relieve excess pressure. If opened
immediately, scalding hot fluid and steam will
be blown out under pressure.

264 MAINTAINING YOUR VEHICLE
 Open the hood.
 At first, only turn the pressure cap on coolant
reservoir to the first detent to release the pressure
from the cooling system. Only then should the
pressure cap be removed completely.
 To add coolant:
If the engine is cold:
Add coolant until the coolant level reaches the base
area which is visible through the filler opening (area
moistened).If the engine is already at its regular operating
temperature:
Add coolant until the coolant level is about 0.6 inch
(1.5 cm) above the base area which is visible
through the filler opening.
 Replace and tighten the pressure cap on coolant
reservoir.
If a large quantity of coolant has been lost, or if smaller
amounts are lost at regular intervals, have the engine
cooling system examined by an authorized Sprinter
Dealer.
For coolant composition and water quality, contact
your Sprinter Dealer.
WARNING!
Do not spill antifreeze on hot engine parts. Anti-
freeze contains ethylene glycol which may burn
if it comes into contact with hot engine parts.
 Check coolant level only with the engine
switched off and the key in position 0 in the
ignition lock.

296 MAINTAINING YOUR VEHICLE
CAPACITIES
Engine with oil filter
Engine oilFuel tank Cooling system Windshield washer
system
Including
reserve fuel
All vehicles about
9.5 US qt
(9.0 l)about
26.4 US gal
(100 l)about
2.8 US gal
(10.5 l)about
2.7 US gal
(10.0 l)about
7.4 US qt
(7.0 l)

MAINTENANCE SCHEDULES 309
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
Check fluid levels for the following systems, correct
as necessary.
Should there be a loss of fluid which cannot be
explained by regular use, trace and eliminate
the cause.
Engine cooling system
Check corrosion inhibitor/antifreeze,
refill as necessary.
Hydraulic brake system
Battery
Windscreen washer system
Engine
Fuel filter renewal
Air cleaner with maintenance indicator:
Check degree of contamination.
Air cleaner filter element renewed as
necessary.Chassis and body
Trailer coupling:
Check operation, play and retaining fixtures
Secondary rubber springs:
Visual check
Tire pressures:
Correct as necessary, including spare tyre
Check thickness of brake pads
Brake test
Check condition of brake disks. Brake disks renewal as
necessary
– as a separate order
Check condition of steering mechanism
Heating/ventilation dust filter renewal

320 INDEX
Climate Control . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 98
Comfortseat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61
Comfortseat (Optional) . . . . . . . . . . . . . . . . . . . . . . . . . 61
Compartments in Front Doors. . . . . . . . . . . . . . . . . . . 87
Constant RPMs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Consumer Assistance
Be Reasonable with Request . . . . . . . . . . . . . . . . . 312
If You Need Assistance . . . . . . . . . . . . . . . . . . . . . 312
Prepare a List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 312
Prepare for the Appointment . . . . . . . . . . . . . . . . 312
Coolant Level Indicator Lamp . . . . . . . . . . . . . . . . . . 108
Coolant Temperature Gauge . . . . . . . . . . . . . . . . . . . 103
Coolant, Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 262
Cooling System, Engine . . . . . . . . . . . . . . . . . . . . . . . 261
Corrosion Protection . . . . . . . . . . . . . . . . . . . . . . . . . . 269
Cup Holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
DDe-Fogging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 121
Dehumidification . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 126
De-Icing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 121
Diesel Fuels for Use at Very Low Temperatures . . 211Direction of Rotation . . . . . . . . . . . . . . . . . . . . . . . . . . 182
Displaying Engine Oil Level . . . . . . . . . . . . . . . . . . . 115
Doors
Front Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Rear Cargo Doors . . . . . . . . . . . . . . . . . . . . . . . . . . . 33
Sliding Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Draining Fuel Filter with Water Separator . . . . . . . 214
Driver’s Airbag. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Driving Safety Systems . . . . . . . . . . . . . . . . . . . . . . . . 163
EElectric Sun Roof . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Electrical Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 276
Fuse and Relay Optional Equipment . . . . . . . . . . 281
Fuse, Relay, and Diode Assignments - Optional
Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 282
Relay Assignment, Standard Equipment . . . . . . 281
Standard Fuse and Relay Equipment. . . . . . . . . . 277
Electrical Outlet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 84
Electronic Brake Force Distribution . . . . . . . . . . . . . 167
Electronic Brake Force Distribution Lamp . . . . . . . . 160
Electronic Stability Program . . . . . . . . . . . . . . . . . . . 169
Emission Label, Vehicle/Engine . . . . . . . . . . . . . . . . . . 8

INDEX 321
10
Emission Related Component . . . . . . . . . . . . . . . . . . 256
Emissions Control System . . . . . . . . . . . . . . . . . . . . . 228
Engine Break-in Recommendations . . . . . . . . . . . . . . 52
Engine Cleaning. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 272
Engine Control Unit Indicator Lamp . . . . . . . . . . . . 109
Engine Coolant. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 262
Engine Cooling System . . . . . . . . . . . . . . . . . . . . . . . . 261
Engine Oil Consumption . . . . . . . . . . . . . . . . . . . . . . . 53
Engine Oil Level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 259
Indicator in Instrument Cluster . . . . . . . . . . . . . . 117
Engine Oil Level - Display in Instrument Cluster . 114
Engine Oil Level Indicator Lamp . . . . . . . . . . . . . . . 107
Engine Oils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 258
Engine oils . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 259
Engine Speed, Maximum . . . . . . . . . . . . . . . . . . . . . . 145
Engine, Stopping . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 147
Exhaust Gas . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 228
Exhaust Gas, Inhalation of . . . . . . . . . . . . . . . . . . 54, 228
FFax Machines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
Fire Extinguisher . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 233
Fog Lamp Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68Folding Seat at Partition . . . . . . . . . . . . . . . . . . . . . . . . 63
Fording . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 228
Front Seat Passenger Airbag . . . . . . . . . . . . . . . . . . . . 48
Fuel Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 214
Fuel Filter with Water Separator . . . . . . . . . . . . . . . . 210
Fuel Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 105
Fuel Tank Capacity . . . . . . . . . . . . . . . . . . . . . . . . . . . 213
Fuels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 209
Bleeding the Diesel Fuel System . . . . . . . . . . . . . . 216
Diesel Fuels for Use at Very Low Temperatures 211
Draining Fuel Filter with Water Separator . . . . . 214
Fuel Filter with Water Separator . . . . . . . . . . . . . 210
Fuel Tank Capacity . . . . . . . . . . . . . . . . . . . . . . . . . 213
Refueling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 212
Fuse and Relay Optional Equipment . . . . . . . . . . . . 281
Fuse, Relay, and Diode Assignments - Optional
Equipment. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 281
Fuses, Electrical . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 276
GGear Selector Lever Position . . . . . . . . . . . . . . . . . . . 150
Glove Compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Lockable Glove Compartment . . . . . . . . . . . . . . . . 87