2006 DODGE POWER WAGON brakes

WARNING!
The warning words “DO NOT OPEN HOT” on the
radiator pressure cap are a safety precaution. Heat
causes pressure to build up in the cooling system. To
prevent scalding or injury, do not remove the pres-
sure cap.
Hoses And Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, tears, cuts, abrasions, and exces-
sive swelling indicate deterioration of the rubber.
Pay particular attention to those hoses nearest to high
heat sources such as the exhaust manifold. Inspect hose
routing to be sure hoses do not come in contact with any
heat source or moving component which may cause heat
damage or mechanical wear.Insure nylon tubing in these areas has not melted or
collapsed.
Inspect all hose connections such as clamps and cou-
plings to make sure they are secure and no leaks are
present.
Components should be replaced immediately if there is
any evidence of wear or damage that could cause failure.
Brake System
Power Disc Brakes (front and rear)
Disc brakes do not require adjustment; however, several
hard stops during the break-in period are recommended
to seat the linings and wear off any foreign material.
Brake Master Cylinder
The fluid level of the master cylinder should be checked
when performing under the hood service, or immedi-
ately if the brake system warning lamp indicates system
failure.
MAINTAINING YOUR VEHICLE 389
7

The brake master cylinder has a translucent plastic
reservoir. On the outboard side of the reservoir, there is a
“MAX” dot and an “MIN” dot. The fluid level must be
kept within these two dots. Do not add fluid above the
MAX mark, because leakage may occur at the cap.
With disc brakes the fluid level can be expected to fall as
the brake linings wear. However, an unexpected drop in
fluid level may be caused by a leak and a system check
should be conducted.
Refer to Fluids, Lubricants and Genuine Parts for the
correct Fluid type.
WARNING!
Use of a brake fluid that may have a lower initial
boiling point, or is unidentified as to specification,
may result in sudden brake failure during hard
prolonged braking. You could have an accident.
WARNING!
Overfilling the brake fluid reservoir can result in
spilling brake fluid on hot engine parts and the
brake fluid catching fire.
Use only brake fluid that has been in a tightly closed
container to avoid contamination from foreign matter or
moisture.
CAUTION!
Do not allow a petroleum-base fluid to contaminate
the brake fluid. Seal damage may result.
390 MAINTAINING YOUR VEHICLE

B-Pillar Location........................ 301
Brake Fluid............................ 419
Brake System........................293,389
Anti-Lock........................... 294
Disc Brakes.......................... 389
Hoses.............................. 391
Master Cylinder....................... 389
Parking............................. 292
Warning Light........................ 173
Break-In Recommendations, New Vehicle........ 69
Bulb Replacement....................... 407
Bulbs,Light ............................ 406
Cab Top Clearance Lights.................. 414
Calibration, Compass..................... 139
Camper............................... 160
Capacities, Fluid........................ 417
Caps, Filler
Oil (Engine).......................... 373Power Steering........................ 380
Car Washes............................ 401
Carbon Monoxide Warning............ 71,162,322
CargoLight ............................ 125
Cassette Tape and Player Maintenance......... 211
Catalytic Converter....................323,376
CD Player.......................177,182,195
Cellular Phone.......................... 90
Center High Mounted Stop Light............ 412
Center Lap Belts......................... 42
Center Seat Storage Compartment............ 154
Certification Label....................... 324
Chart, Tire Sizing........................ 298
Check Engine Light (Malfunction Indicator Light) . 172
Child Restraint........................ 57,58
Child Restraint Tether Anchors............. 62,65
Child Seat............................ 58,64
Cigar Lighter........................... 152
Climate Control......................... 213
INDEX 453
10

Clock .............................176,196
Clutch............................... 391
Clutch Linkage Maintenance................ 391
Compact Disc Maintenance................. 212
Compact Spare Tire...................... 309
Compass...........................138,139
Compass Calibration..................... 139
Compass Variance....................... 140
Computer, Trip/Travel.................... 135
Console, Overhead....................... 134
Contract, Service........................ 446
Converter, Catalytic...................... 323
Cooling System......................... 385
Coolant Capacity...................... 417
Coolant Level......................... 385
Disposal of Used Coolant................ 388
Drain, Flush, and Refill.................. 386
Inspection........................... 385
Radiator Cap......................385,388Selection of Coolant (Antifreeze)......387,417,418
Temperature Gauge..................... 170
Cruise Control (Speed Control).............. 130
CupHolder ............................ 153
Customer Assistance..................... 444
Data Recorder, Event...................... 56
Daytime Running Lights................... 124
Dealer Service.......................... 369
Defroster, Rear Window.............. 88,219,223
Defroster, Windshield..................215,217
Delay (Intermittent) Wipers................. 128
Differential............................. 80
Differential, Limited-Slip.................. 291
Digital Video Disc Player................... 80
Dipsticks
Automatic Transmission................. 393
Power Steering........................ 380
Disc Brakes............................ 389
454 INDEX