2006 CHRYSLER TOWN AND COUNTRY manual transmission

8
5/100 POWERTRAIN WARRANTY
The following powertrain components are covered for 5 years or
100,000 kilometres, whichever occurs first, measured from the
vehicle’s original warranty start date.
Vehicles placed in police, taxi, limousine, postal or ambulance
service and all SRT vehicles are excluded from the 5-year or
100,000-kilometrePowertrain Warranty and are covered only under
the 3-year or 60,000-kilometreBasic Warranty.
• Engine– Cylinder block and all internal parts; cylinder head
assemblies; timing case, timing chain, timing belt, gears and
sprockets; vibration damper; oil pump; water pump and housing;
intake and exhaust manifolds; flywheel with starter ring gear; core
plugs; valve covers; oil pan; turbocharger housing and internal
parts; turbocharger wastegate actuator; supercharger; serpentine
belt tensioner; seals and gaskets for listed components only. • Transmission– Transmission case and all internal parts; torque
converter; drive/flex plate; transmission range switch;
transmission control module; bell housing; oil pan; seals and
gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time.
• Front-Wheel Drive– Transaxle case and all internal parts; axle
shaft assemblies; constant velocity joints and boots; differential
cover; oil pan; transaxle speed sensors; transaxle solenoid
assembly; PRNDL position switch; transaxle electronic controller;
torque converter; seals and gaskets for listed components only.
Note: Manual transmission clutch parts are not covered at any time.
5/100 POWERTRAIN WARRANTY
2006 Passenger Car • Minivan • Pacifica

MAINTENANCE Scheduled maintenance must be completed to provide the best vehicle
performance and reliability. The limited warranties in the warranty booklet DO NOT COVER repairs
required due to improper maintenance. We strongly suggest you keep track of scheduled maintenance and
keep receipts or other documents. Use only recommended Mopar Lubricants and genuine Mopar
®Parts. In
the event that a condition arises between maintenance intervals, please contact your retailer. AV O I D
PROLONGED PERIODS OF IDLING.
NOTE: WHERE TIME (MONTHS) AND METRAGE ARE INDICATED, FOLLOW THE INTERVAL
THAT OCCURS FIRST.
AT EACH STOP FOR FUEL
• Check the engine oil level about 5 minutes after
a fully warmed engine is shut off. Checking the
oil level while the vehicle is on level ground will
improve the accuracy of the oil-level reading.
Add oil only when the level is at or below the
ADD or MIN mark.
• Check the windshield-washer solvent and add
if required.
ONCE A MONTH
• Check the tire pressure and look for unusual
wear or damage.
• Inspect the battery and clean and tighten the
terminals as required.
• Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transmission
and add as needed.
• Check all the lights and all other electrical items
for correct operation.
• Check rubber seals on each side of the radiator
for proper fit.
• Check and clean wiper blades. Replace if required.
VISUAL INSPECTIONS –
INSPECT FOR SIGNS OF COMPONENT
DETERIORATION AND PHYSICAL DAMAGE.
There are two maintenance schedules
contained in your Owner’s Manual. Schedule
“B” best describes operating conditions in
Canada and is the recommended service
schedule. For your convenience, the scheduled
maintenance intervals outlined in this booklet
follow the Severe Service Schedule as described
in your Owner’s Manual. Schedule “B” is for
vehicles that are operated under one or more of
the following conditions: day or night tempera-
tures are below 0°C (90°F); stop-and-go driving;
extensive engine idling; driving in dusty
conditions; short trips of less than 16.2 km (10mi.); more than 50% of your driving is at
sustained high speeds during hot weather,
above 32°C (90°F); trailer towing; taxi, police, or
delivery service (commercial service); off-road
or desert driving; if equipped for and operating
with E-85 (ethanol) fuel. Schedule “A” is for
vehicles that are not operated under any of the
conditions listed under Schedule “B.”
The performance of all scheduled service
work is required to maintain your vehicle in
good operating condition. DaimlerChrysler
Canada Inc. reserves the right to deny
warranty coverage if the vehicle has not been
properly maintained. While we do not insist
that such work be performed by factory-
authorized retailers, we strongly recommend
that an authorized Chrysler, Jeep
®or Dodge
Retailer perform this work. INTRODUCTION

Maintenance Service
Schedule “B”
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.
Maintenance Service Schedule “B”
5,000 km

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and suspension components.

Inspect the engine air cleaner filter and replace if necessary (Sebring, Pacifica
and Minivan only).
INSPECT THE FOLLOWING:

Inspect the brake linings, hoses and calipers (Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica and Minivan only).

Check the brake master cylinder fluid level (Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug condition (if equipped)
(PT Cruiser only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.
2006 Passenger Car • Minivan • Pacifica
5,000 km

DAIMLERCHRYSLER
RETAILERSTA M P
Signature of authorized DaimlerChrysler Canada Retailer

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and
suspension components.

Inspect the engine air cleaner filter and replace if
necessary (Sebring, Pacifica and Minivan only).
INSPECT THE FOLLOWING:

Inspect the brake linings, hoses and calipers
(Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica
and Minivan only).

Check the brake master cylinder fluid level
(Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug
condition (if equipped) (PT Cruiser only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.
Odometer Reading
Date
Repair Order No.
Maintenance Service Schedule “B”
5,000 km
2006 Passenger Car • Minivan • Pacifica

Retailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.
Maintenance Service
Schedule “B”
Odometer Reading
Date
Maintenance Service Schedule “B”
10,000 km

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and suspension components.

Inspect the engine air cleaner filter and replace if necessary (Sebring, Pacifica
and Minivan only).

Rotate tires and check tire pressure.
INSPECT THE FOLLOWING:

Inspect the brake linings, hoses and calipers (Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica and Minivan only).

Check the brake master cylinder fluid level (Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug condition (if equipped)
(PT Cruiser only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.
2006 Passenger Car • Minivan • Pacifica
10,000 km

DAIMLERCHRYSLER
RETAILERSTA M P
Signature of authorized DaimlerChrysler Canada Retailer
2006 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
Repair Order No.

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and
suspension components.

Inspect the engine air cleaner filter and replace
if necessary (Sebring, Pacifica and Minivan only).

Rotate tires and check tire pressure.
INSPECT THE FOLLOWING:

Inspect the brake linings, hoses and calipers
(Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica
and Minivan only).

Check the brake master cylinder fluid level
(Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug
condition (if equipped) (PT Cruiser only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.
Maintenance Service Schedule “B”
10,000 km

Maintenance Service
Schedule “B”
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
26-92-02-01 3N.
2006 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
15,000 km Maintenance Service Schedule “B”
15,000 km

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and suspension components.

Inspect the engine air cleaner filter and replace if necessary (Sebring, Pacifica
and Minivan only).
INSPECT THE FOLLOWING:

Inspect the brake linings (Pacifica and Minivan only).

Inspect the brake linings, hoses and calipers (Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica and Minivan only).

Check the brake master cylinder fluid level (Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug condition (if equipped)
(PT Cruiser only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.

DAIMLERCHRYSLER
RETAILERSTA M P
Signature of authorized DaimlerChrysler Canada Retailer
2006 Passenger Car • Minivan • Pacifica
Odometer Reading
Date
Repair Order No.

Change engine oil and engine oil filter (or every 3 months).

Inspect and lubricate, as required, all steering and
suspension components.

Inspect the engine air cleaner filter and replace if
necessary (Sebring, Pacifica and Minivan only).
INSPECT THE FOLLOWING:

Inspect the brake linings (Pacifica and Minivan only).

Inspect the brake linings, hoses and calipers
(Sebring only).

Inspect the brake hoses (PT Cruiser, Pacifica
and Minivan only).

Check the brake master cylinder fluid level (Sebring only).

Check the automatic transmission fluid level.

Check the manual transaxle fluid level and fill-plug
condition (if equipped) (PT Cruiser only).

Check the coolant level, hoses and clamps.

Inspect the exhaust system.Maintenance Service Schedule “B”
15,000 km