WARNING!
A hot exhaust system can start a fire if you park over
materials that can burn. Such materials might be
grass or leaves coming into contact with your ex-
haust system. Do not park or operate your vehicle in
areas where your exhaust system can contact any-
thing that can burn.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe
and abnormal catalyst overheating. If this occurs, stop
the vehicle, turn off the engine and allow it to cool.
Service, to the manufacturer’s specifications, should be
obtained immediately.To minimize the possibility of catalyst damage:
•Do not shut off the engine or interrupt the ignition
when the transaxle is in gear and the vehicle is in
motion.
•Do not try to start the engine by pushing or towing the
vehicle.
•Do not idle the engine with any spark plug wires
disconnected for prolonged period.
Engine Timing Belt
Replace the engine timing belt (2.4L Only) at the intervals
described in the appropriate maintenance schedule.
Crankcase Emission Control System
Proper operation of this system depends on freedom from
sticking or plugging due to deposits. As vehicle mileage
builds up, the Positive Crankshaft Ventilation (PCV) valve
and passages may accumulate deposits. If a valve is not
working properly, replace it with a new valve. DO NOT
ATTEMPT TO CLEAN THE OLD PCV VALVE!
Check ventilation hose for indication of damage or
plugging deposits. Replace if necessary.
224 MAINTAINING YOUR VEHICLE
•Police, taxi, limousine, commercial type operation, or
trailer towing where the vehicle is drivenregularlyfor
more than 45 minutes of continuous operation.
NOTE:Refer to Section 8 of this manual for mainte-
nance schedules.
If the transaxle is disassembled for any reason, the fluid
and filter should be changed.
Special Additives
TThe manufacture strongly recommends against the ad-
dition of any additives to the transaxle. The only excep-
tion to this policy is the use of special dyes to aid in
detecting fluid leaks. The use of transmission sealers
should be avoided as they may adversely affect seals.
Fluid Level Check
Check the fluid level by removing the fill plug. The fluid
level should be between the bottom of the fill hole and a
point not more than 4.0 mm below the bottom of the hole.
Add fluid, if necessary, to maintain the proper level.
Frequency of Fluid Change
Under normal operating conditions, the fluid installed at
the factory will give satisfactory lubrication for the life ofthe vehicle. Fluid changes are not necessary unless the
lubricant has become contaminated with water. If con-
taminated with water, the fluid should be changed im-
mediately.
Appearance Care And Protection From Corrosion
Protection of Body and Paint from Corrosion
Vehicle body care requirements vary according to geo-
graphic locations and usage. Chemicals that make roads
passable in snow and ice, and those that are sprayed on
trees and road surfaces during other seasons, are highly
corrosive to the metal in your vehicle. Outside parking,
which exposes your vehicle to airborne contaminants,
road surfaces on which the vehicle is operated, extreme
hot or cold weather and other extreme conditions will
have an adverse effect on paint, metal trim, and under-
body protection.
The following maintenance recommendations will enable
you to obtain maximum benefit from the corrosion
resistance built into your vehicle.
MAINTAINING YOUR VEHICLE 241
7
EMISSION CONTROL SYSTEM MAINTENANCE
The “Scheduled” maintenance services, listed inbold
typemust be done at the times or mileages specified to
assure the continued proper functioning of the emission
control system. These, and all other maintenance services
included in this manual, should be done to provide best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions such as dusty areas and very short trip
driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the
emission control devices and systems on your vehicle
may be performed by any automotive repair establish-
ment or individual using any automotive part which has
been certified pursuant to U.S. EPA or, in the State of
California, California Air Resources Board regulations.
MAINTENANCE SCHEDULES
There are two maintenance schedules that show the
requiredservice for your vehicle.
First is Schedule“B”. It is for vehicles that are operated
under the conditions that are listed below and at the
beginning of the schedule.
•Day or night temperatures are below 32° F (0° C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90° F (32° C).
•Trailer towing.
•Taxi, police, or delivery service (commercial service).
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
262 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
SCHEDULE “B”
Follow schedule “B” if you usually operate your vehicle
under one or more of the following conditions. Change
the automatic transmission fluid and filter every 60,000
miles (96 000 km) if the vehicle is usually operated under
one or more of the conditions marked with an.
•Day or night temperatures are below 32° F (0° C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16.2 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90° F (32° C).
•Trailer towing.
•Taxi, police or delivery service (commercial ser-
vices).
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first and follow schedule “B” of the
Maintenance Schedulessection of this manual.
NOTE:IFANYof these apply to you then flush and
replace the engine coolant every 100,000 miles (160,000
km) or 60 months, whichever comes first, and follow
schedule B of theMaintenance Schedulessection of this
manual.
SCHEDULE “B” 265
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S
Crankcase Emission Control System......... 224
Cruise Control (Speed Control)............. 72
Cruise Light........................... 89
Customer Assistance.................... 280
Daytime Running Lights.................. 68
Dealer Service......................... 217
Defroster, Rear Window.................. 139
Defroster, Windshield...............44,132,138
Diagnostic System, Onboard............... 215
Dimmer Control........................ 66
Dimmer Switch, Headlight................. 69
Dipsticks
Automatic Transaxle................... 240
Disposal
Antifreeze (Engine Coolant)............. 234
Engine Oil.......................... 221
Door Ajar Warning...................... 14
Door Locks............................ 12
Door Locks, Automatic................... 14
Door Opener, Garage..................... 75
Drive Belts............................ 222Driving
On Slippery Surfaces.................. 207
E-85 Fuel............................. 181
Electrical Outlet, Auxiliary (Power Outlet)..... 79
Electrical Power Outlets................... 79
Electronic Speed Control (Cruise Control)...... 72
Emergency Brake....................... 153
Emergency, In Case of
Freeing Vehicle When Stuck............. 208
Jacking............................. 199
Jump Starting........................ 204
Overheating......................... 198
Towing............................. 208
Emergency Trunk Release...............20,21
Emission Control System Maintenance....216,262
Engine............................213,214
Air Cleaner Filter..................... 222
Block Heater......................... 148
Break-In Recommendations............... 42
Checking Oil Level.................... 218
Compartment.....................213,214
Coolant (Antifreeze)................232,258
INDEX 291
10
Cleaning............................ 244
High Beam.........................69,90
High Beam/Low Beam Select Switch....... 69
Passing............................. 69
Switch.............................. 67
Time Delay........................68,69
Heater............................129,136
Heater, Engine Block.................... 148
High Beam Indicator..................... 90
Hitches
Trailer Towing....................... 187
HomeLink(Garage Door Opener) Transmitter . 75
Hood Prop............................ 64
Hood Release.......................... 63
Hoses............................236,239
Ignition
Key ................................. 9
Lock................................ 9
Illuminated Entry....................... 12
Immobilizer (Sentry Key).................. 10
Infant Restraint......................... 35
Inside Rearview Mirror................... 56Instrument Cluster..................86,87,88
Instrument Panel and Controls.............. 85
Instrument Panel Cover.................. 245
Instrument Panel Lens Cleaning............ 245
Interior Fuses.......................... 248
Interior Lighting........................ 65
Interior Lights........................65,66
Introduction............................ 4
Jack Location.......................... 200
Jack Operation......................... 200
Jump Starting......................... 204
Key, Programming....................... 11
Key, Replacement........................ 11
Key, Sentry (Immobilizer).................. 10
Key-In Reminder......................... 9
Keyless Entry System..................... 15
Keys.................................. 9
Lap/Shoulder Belts...................... 23
LATCH (Lower Anchors and
Tether for CHildren)...................37,39
294 INDEX
General Information................... 167
High Speed......................... 169
Inflation Pressures.................... 168
Jacking............................. 200
Life of Tires......................... 173
Load Capacity....................163,164
Quality Grading...................... 284
Radial............................. 170
Replacement......................... 173
Rotation............................ 175
Safety...........................158,167
Sizes............................... 160
Snow Tires.......................... 175
Spinning............................ 171
Tread Wear Indicators.................. 172
Tongue Weight/Trailer Weight............. 189
Top Cover............................. 50
Towing.........................185,208,209
Disabled Vehicle...................... 208
Guide.............................. 188
Weight............................. 188
Traction Control....................71,89,157
Traction Control Switch................71,157Trailer Towing......................... 185
Cooling System Tips................... 195
Hitches............................. 187
Minimum Requirements................ 190
Trailer and Tongue Weight.............. 189
Wiring............................. 193
Trailer Towing Guide.................... 188
Trailer Weight......................... 188
Transaxle............................. 239
Additives........................... 241
Automatic.....................149,151,239
Autostick........................... 176
Filter.............................. 240
Overdrive........................... 152
Selection of Lubricant.................. 239
Transmission
Range Indicator....................... 92
Transmission....................See Transaxle
Transmitter Battery Service
(Remote Keyless Entry)................... 18
Transmitter, Garage Door Opener (HomeLink).75
Transmitter, Remote Keyless Entry (RKE)...... 15
Transporting Pets........................ 42
300 INDEX