2006 CHRYSLER PT CRUISER battery

4. As soon as you turn your key to the ON position, you
will see your MIL symbol come on as part of a normal
bulb check.
5. Approximately 15 seconds later, one of two things will
happen:
a. The MIL will flash for about 10 seconds and then
return to being fully illuminated until you turn off the
ignition key or start the engine. This means that your
vehicle’s OBD system isnot readyand you shouldnot
proceed to the I/M station.
b. The MIL will not flash at all and will remain fully
illuminated until you turn off the ignition key or start
the engine. This means that your vehicle’s OBD system
isreadyand you can proceed to the I/M station.
If your OBD system isnot ready,you should see your
authorized dealer or repair facility. If your vehicle was
recently serviced or had a battery failure or replacement,you may need to do nothing more than drive your
vehicle as you normally would in order for your OBD
system to update. A recheck with the above test routine
may then indicate that the system is now ready.
Regardless of whether your vehicle’s OBD system is
ready or not ready, if the MIL symbol is illuminated
during normal vehicle operation, you should have your
vehicle serviced before going to the I/M station. The I/M
station can fail your vehicle because the MIL symbol is on
with the engine running.
REPLACEMENT PARTS
Use of genuine Moparparts for normal/scheduled
maintenance and repairs is highly recommended to in-
sure the designed performance. Damage or failures
caused by the use of non-Moparparts for maintenance
and repairs will not be covered by the manufacturer’s
warranty.
366 MAINTAINING YOUR VEHICLE

normal. The amount will depend on driving style. The air
cleaner box should be cleaned out and a new make-up-
air filter element should be installed during the normal
air filter maintenance procedure.
WARNING!
The air cleaner can provide a measure of protection
in the case of engine backfire. Do not remove the air
cleaner unless such removal is necessary for repair or
maintenance. Make sure that no one is near the
engine compartment before starting the vehicle with
the air cleaner removed. Failure to do so can result in
serious personal injury.
Maintenance-Free Battery
You will never have to add water, nor is periodic main-
tenance required.
CAUTION!
When servicing the battery, always reinstall the
battery thermowrap. The thermowrap provides bat-
tery heat protection and will extend overall battery
life. Failure to reinstall the thermowrap can result in
evaporative loss of the battery fluid.
MAINTAINING YOUR VEHICLE 375
7

WARNING!
Battery fluid is a corrosive acid solution and can
burn or even blind you. Don’t allow battery fluid to
contact your eyes, skin or clothing. Don’t lean over a
battery when attaching clamps. If acid splashes in
eyes or on skin, flush the area immediately with
large amounts of water.
Battery gas is flammable and explosive. Keep flame
or sparks away from the battery. Don’t use a booster
battery or any other booster source with an output
greater than 12 volts. Don’t allow cable clamps to
touch each other.
Battery posts, terminals and related accessories con-
tain lead and lead compounds. Wash hands after
handling.
CAUTION!
It is essential when replacing the cables on the
battery that the positive cable is attached to the
positive post and the negative cable is attached to the
negative post. Battery posts are marked positive (+)
and negative (-) and identified on the battery case.
Cable clamps should be tight on the terminal posts
and free of corrosion. Apply grease to posts and
clamps after tightening.
If a “fast charger” is used while the battery is in the
vehicle, disconnect both vehicle battery cables be-
fore connecting the charger to battery. Do not use a
“fast charger” to provide starting voltage as battery
damage can result.
376 MAINTAINING YOUR VEHICLE

Cavity Cartridge
FuseMini Fuse Description
10 20 Amp Yellow CCN, Power
Locks
11 15 Amp Lt
BluePower Outlet
12 20 Amp Yellow Ign Run/Acc In-
verter
13 20 Amp Yellow Pwr run/Acc
Outlet RR
14 10 Amp Red IOD CCN/ Inte-
rior Lighting
15 50 Amp
RedRAD Fan Relay
Battery Feed
16 15 Amp Lt.
BlueIGN Run/Acc
Cigar Ltr/
Sunroof
17 10 Amp Red IOD Feed CVT
Mod/Mod_WcmCavity Cartridge
FuseMini Fuse Description
18 40 Amp
GreenASD Relay Con-
tact PWR Feed
19 20 Amp Yelow PWR Amp 1 &
Amp 2 Feed
20 15 Amp Lt.
BlueIOD Feed Radio
21 10 Amp Red IOD Feed Intrus
Mod/Siren
22 10 Amp Red IGN RUN Hvac/
Compass Sensor
23 15 Amp Lt.
BlueENG ASD Relay
Feed 3
24 25 Amp Natu-
ralPWR Sunroof
Feed
25 10 Amp Red Heated Mirror
404 MAINTAINING YOUR VEHICLE

CAUTION!
•When installing the Integrated Power Module
cover, it is important to ensure the cover is prop-
erly positioned and fully latched. Failure to do so
may allow water to get into the Integrated Power
Module, and possibly result in a electrical system
failure.
•When replacing a blown fuse, it is important to
use only a fuse having the correct amperage
rating. The use of a fuse with a rating other than
indicated may result in a dangerous electrical
system overload. If a properly rated fuse contin-
ues to blow, it indicates a problem in the circuit
that must be corrected.
VEHICLE STORAGE
If you will not be using your vehicle for more than 21
days you may want to take steps to preserve your battery.
You may:
•Disengage the mini fuse in the Power Distribution
Center labeled IOD (Ignition Off-Draw).
•Or, disconnect the negative cable from the battery.
406 MAINTAINING YOUR VEHICLE

At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder and transaxle and add as needed.
•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
At Each Oil Change
•Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front suspension compo-
nents.
•Check the automatic transaxle fluid level.
•Check the manual transaxle fluid level and fill plug
condition.
•Check the coolant level, hoses, and clamps.
418 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Special Additives...................... 394
Autostick............................. 289
Back-Up Lights......................... 410
BallJoints ............................. 378
Battery............................... 375
Keyless Transmitter Replacement (RKE)..... 30,35
Belts,Drive ............................ 372
Belts, Engine........................... 374
Body Mechanism Lubrication............... 379
Boot, Convertible Top..................126,130
B-Pillar Location........................ 307
Brake Fluid............................ 413
Brake, Parking.......................... 294
Brake System........................296,388
Anti-Lock (ABS)....................... 297
Hoses.............................. 388
Master Cylinder....................... 389
Parking............................. 294Warning Light........................ 225
Brakes.............................296,388
Brake/Transmission Interlock............... 285
Break-In Recommendations, New Vehicle....... 113
Bulb Replacement.....................407,408
Bulbs,Light ............................ 407
Calibration, Compass..................... 237
Capacities, Antifreeze (Engine Coolant)........ 411
Capacities, Fluid........................ 411
Caps, Filler
Fuel................................ 326
Oil (Engine)....................362,363,370
Car Washes............................ 395
Carbon Monoxide Warning................. 325
Cargo Compartment
Luggage Carrier....................... 212
Carrier, Luggage........................ 212
Catalytic Converter...................... 372
INDEX 449
10

Dimmer Switch, Headlight............... 181
Engine Temperature Warning.............. 226
Fog ..........................183,227,409
Front Replacement..................... 408
Headlight Switch...................... 182
Headlights........................... 182
High Beam Indicator.................... 228
Instrument Cluster..................... 182
Interior............................. 180
Lights On Reminder.................... 182
Low Fuel............................ 227
Malfunction Indicator (Check Engine)........ 224
Map Reading......................178,179
Oil Pressure.......................... 227
Rear Servicing........................ 410
Seat Belt Reminder..................... 226
Security Alarm (Theft Alarm).............. 36
Service.............................. 408
Theft Alarm (Security Alarm).............. 226Traction Control....................... 301
Turn Signal..................181,183,224,409
Voltage............................. 226
Warning (Instrument Cluster Description)..... 222
Loading Vehicle......................... 329
Tires ............................... 307
Locks
Child Protection........................ 23
Door................................ 18
Power Door........................... 20
Steering Wheel......................... 18
Lubrication, Body....................... 379
Luggage Rack (Roof Rack)................. 212
Lumbar Support........................ 162
Maintenance Free Battery.................. 375
Maintenance, General..................... 367
Maintenance Procedures................... 367
456 INDEX