2005 TOYOTA LAND CRUISER steering

292
If you perform maintenance by yourself,
be sure to follow the correct procedure
given in this section.
You should be aware that improper or in-
complete servicing may result in operating
problems.
Performing do−it−yourself maintenance
during the warranty period may affect your
warranty coverage. Read the separate
Toyota Warranty statement for details and
suggestions.
This part gives instructions only for those
items that are relatively easy for an owner
to perform. As explained in Section 6,
there are still a number of items that must
be done by a qualified technician with
special tools.
For information on tools and parts for do −
it −yourself maintenance, see “Parts and
tools” on page 293.
Utmost care should be taken when work-
ing on your vehicle to prevent accidental
injury. Here are a few precautions that
you should be especially careful to ob-
serve:CAUTION
When the engine is running, keep
hands, clothing, and tools away
from the moving fan and engine
drive belts. (Removing rings,
watches, and ties is advisable.)
Right after driving, the engine
compartment—the engine, radiator,
exhaust manifold, power steering
fluid reservoir and spark plug
boots, etc.—will be hot. So be care-
ful not to touch them. Oil, fluids
and spark plugs may also be hot.
If the engine is hot, do not remove
the radiator cap or loosen the drain
plugs to prevent burning yourself.
Do not leave anything that may
burn easily, such as paper or rags,
in the engine compartment.
Do not smoke, cause sparks or al-
low open flames around fuel or the
battery. Their fumes are flammable.
Be extremely cautious when work-
ing on the battery. It contains poi-
sonous and corrosive sulfuric acid.
Do not get under your vehicle with
just the body jack supporting it. Al-
ways use automotive jack stands or
other solid supports.
Be sure that the ignition is off if
you work near the electric cooling
fan or radiator grille. With the igni-
tion on, the electric cooling fan will
automatically start to run if the air
conditioning is on.
Use eye protection whenever you
work on or under your vehicle
where you may be exposed to flying
or falling material, fluid spray, etc.
Used engine oil contains potentially
harmful contaminants which may
cause skin disorders such as in-
flammation or skin cancer, so care
should be taken to avoid prolonged
and repeated contact with it. To re-
move used engine oil from your
skin, wash thoroughly with soap
and water.
Do not leave used oil within the
reach of children.
Doityourself service
precautions

293
Dispose of used oil and filter only
in a safe and acceptable manner.
Do not dispose of used oil and fil-
ter in household trash, in sewers or
onto the ground. Call your dealer or
a service station for information
concerning recycling or disposal.
NOTICE
Remember that battery and ignition
cables carry high currents or volt-
ages. Be careful of accidentally
causing a short circuit.
 Add only “Toyota Super Long Life
Coolant” or similar high quality eth-
ylene glycol based nonsilicate,
nonamine, nonnitrite and nonbo-
rate coolant with longlife hybrid
organic acid technology to fill the
radiator. “Toyota Super Long Life
Coolant” is a mixture of 50% cool-
ant and 50% deionized water.
 If you spill some of the coolant, be
sure to wash it off with water to
prevent it from damaging the parts
or paint.
 Do not allow dirt or anything else
to fall through the plug holes.
Do not pry the outer electrode of a
spark plug against the center elec-
trode.
 Use only spark plugs of the speci-
fied type. Using other types will
cause engine damage, loss of per-
formance or radio noise.
 Do not reuse iridiumtipped spark
plugs by cleaning or regapping.
 Do not overfill automatic transmis-
sion fluid, transfer oil and power
steering fluid, or the transmission,
transfer and power steering could
be damaged.
 Do not drive with the air cleaner
filter removed, or excessive engine
wear could result. Also backfiring
could cause a fire in the engine
compartment.
 Be careful not to scratch the glass
surface with the wiper frame.
 When closing the engine hood,
check to see that you have not for-
gotten any tools, rags, etc.
Parts and tools
Here is a list of parts and tools you will
need to perform do −it−yourself mainte-
nance. Remember all Toyota parts are de-
signed in metric sizes, so your tools must
be metric.
CHECKING THE ENGINE OIL LEVEL
Parts (if level is low):
“Toyota Genuine Motor Oil” or equiva-
lent. See “Checking the engine oil lev-
el” on page 296 for instructions.
Tools:
Rag or paper towel
Funnel (only for adding oil)
CHECKING THE ENGINE COOLANT LEV-
EL
Parts (if level is low):
“Toyota Super Long Life Coolant” or
similar high quality ethylene glycol
based non −silicate, non −amine, non− ni-
trite, and non −borate coolant with long −
life hybrid organic acid technology.
“Toyota Super Long Life Coolant” is a
mixture of 50% coolant and 50% deion-
ized water.

294
Tools:
Funnel (only for adding coolant)
CHECKING BRAKE FLUID
Parts (if level is low):
SAE J1703 or FMVSS No.116 DOT 3
brake fluid
Tools:
Rag or paper towel
Funnel (only for adding fluid)
CHECKING POWER STEERING FLUID
Parts (if level is low):
Automatic transmission fluid DEXRON
\b II
or III
Tools:
Rag or paper towel
Funnel (only for adding fluid)
CHECKING BATTERY CONDITION
Tools:
Warm water
Baking soda
Grease
Conventional wrench (for terminal
clamp bolts) CHECKING AND REPLACING FUSES
Parts (if replacement is necessary):
Fuse with same amperage rating as
original
ADDING WASHER FLUID
Parts:
Water
Washer fluid containing antifreeze (for
winter use)
Tools:
Funnel
REPLACING LIGHT BULBS
Parts:
Bulb with same number and wattage
rating as original (See charts in “Re-
placing light bulbs” on page 315.)
Tools:
Screwdriver

295
DOITYOURSELF MAINTENANCE
Engine and Chassis
Checking the engine oil level296
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the engine coolant level 298
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the radiator and condenser 299
. . . . . . . . . . . . . . . . . . . . . . . . .
Checking brake fluid 300
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . .
Checking power steering fluid 301
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking tire inflation pressure 301
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking and replacing tires 304
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rotating tires 306
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . .
Installing snow tires and chains 306
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing wheels 308
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . .
Aluminum wheel precautions 309
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SECTION 7 2

301
Checking power steering fluid
Open
Close If cold
O.K.
If cold
add
If hot
O.K.
If hot
add
Check the fluid level on the dipstick. If
necessary, add automatic transmission
fluid DEXRON II or III.
If the vehicle has been driven around 80
km/h (50 mph) for 20 minutes (a little
more in frigid temperatures), the fluid is
hot (60 C–80 C or 140 F–175 F). You
may also check the level when the fluid
is cold (about room temperature,
10 C–30 C or 50 F–85 F) if the engine
has not been run for about five hours. Clean all dirt from outside of the reservoir
tank and look at the fluid level. If the fluid
is cold, the level should be in the “COLD”
range. Similarly, if it is hot, the fluid level
should be in the “HOT” range. If the level
is at the low side of either range, add
automatic transmission fluid DEXRON
II
or III to bring the level within the range.
To remove the reservoir cap, turn it coun-
terclockwise and lift up. To reinstall it,
turn it clockwise. After replacing the filler
cap, visually check the steering box case,
vane pump and hose connections for
leaks or damage.
CAUTION
The reservoir tank may be hot so be
careful not to burn yourself.
NOTICE
Avoid overfilling, or the power steer-
ing could be damaged.
72c502
Checking tire inflation pres-
sure

327
BRAKES
Minimum pedal clearance when depressed
with the force of 490 N (50 kgf, 110 lbf)
with the engine running, mm (in.): 116 (4.6)
Pedal free play, mm (in.): 1 – 6 (0.04 – 0.24)
Pad wear limit, mm (in.): 1.0 (0.04)
Lining wear limit, mm (in.): 1.0 (0.04)
Parking brake adjustment when pulled with
the force of 196 N (20 kgf, 44 lbf): 4 – 6 clicks
Fluid type: SAE J1703 or FMVSS No.116 DOT 3
STEERING
Wheel free play: Less than 40 mm (1.6 in.)
Power steering fluid type: Automatic transmission fluid DEXRON
\bII
or III

330
26. HEAD (LHLWR) 10 A: Left−hand head-
light (low beam)
27. HEAD (RHUPR) 20 A: Right −hand
headlight (high beam)
28. HEAD (LHUPR) 20 A: Left −hand head-
light (high beam)
29. PWR OUTLET 15 A: Power outlets
30. CIG 15 A: Cigarette lighter
31. ACC 7.5 A: Instrument panel light
32. AM1 7.5 A: Multiport fuel injection sys-
tem/Sequential multiport fuel injection
system
33. DEFOG 20 A:
Rear window defogger
34. AHCB 15 A: Active height control sus-
pension (AHC)
35. FUEL HTR 20 A: Fuel heater
36. POWER HTR 7.5 A: Power heater
37. AHCIG 20 A: Active height control sus-
pension (AHC)
38. EFI or ECD No.2 10 A: Emission con-
trol system
39. GAUGE1 10 A: Gauges and meters
40. ECUIG1 10 A: Multiport fuel injection
system/S equential multiport fuel injec-
tion system
41. ECUB1 10 A:
Navigation system
42. DBL LOCK 15 A: Double lock system
43. A/C 15 A: Air conditioning system
44. STOP 15 A: Stop lights
45. OBD2 7.5 A: On −board diagnosis sys-
tem
46. IDEL UP 7.5 A: Idle −up system
47. LH SEAT 30 A: Power seat system
48. DOOR 25 A: Power door lock system,
Power windows
49. SUN ROOF 25 A: Electronic moon roof
50. RR WIPER 15 A: Rear wiper system
51.ECUB2 10 A: Power door lock system,
Power window
52. DIFF 20 A: Four−wheel drive system
53. WASHER 15 A: Windshield washer
54. RADIO 10 A: Audio system
55. DOME 10 A: Interior lights
56. VGRS 40 A: Variable gear ratio steer-
ing system
57. P/W (FL) 20 A: Power window
58. P/W (RL) 20 A: Power window
59. WIPER 25 A: Windshield wiper
60. ECUIG2 10 A: Rear air conditioning
system
61. SEAT HTR 15 A: Seat heater 62. GAUGE2 10 A:
Back−up lights
63. MET 7.5 A: Gauges and meters
64. IGN 7.5 A: Multiport fuel injection sys-
tem/Sequential multiport fuel injection
system
65. SECURITY 7.5 A: Theft deterrent sys-
tem
66. P/W (RR) 20 A: Power window
67. P/W (FR) 20 A: Power window
68. BATT CHARGE 30 A: Trailer charging
system
69. TIL&TEL 20 A: Tilt and telescopic
steering
70. RR A/C 30 A: Rear air conditioning
system
71. RH SEAT 30 A: Power seat system

334 A
Adding washer fluid315
. . . . . . . . . . . . . . . . . .
Adjustment
Front seats 36
. . . . . . . . . . . . . . . . . . . . . . . . .
Seat belt 48
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Second seat 37
38
. . . . . . . . . . . . . . . . . . . .
Third seat 42 . . . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 176 . . . . . . . . . . . . . . .
Airbags 58 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Aluminum wheel precautions 309 . . . . . . . . . .
Anti −theft steering column lock 134 . . . . . . . .
Appearance care
Cleaning the interior 279 . . . . . . . . . . . . . . . .
Protecting your Toyota from corrosion 276 . . . . . . . . . . . . . . . . . . .
Washing and waxing 277 . . . . . . . . . . . . . . . .
Armrest 37 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Automatic transmission
Driving with an automatic transmission 135 . . . . . . . . . . . . . . . . . . . . .
Shift lock override button 272 . . . . . . . . . . . .
Shift pattern 135 . . . . . . . . . . . . . . . . . . . . . . .
Shifting speed 135 . . . . . . . . . . . . . . . . . . . . .
Auxiliary box 198 . . . . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 27 . . . . . . . . . . .
B
Back door 25
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Back door lock 25
. . . . . . . . . . . . . . . . . . . . . . . . Battery
Checking battery condition 312
. . . . . . . . . .
Gas caution 312
. . . . . . . . . . . . . . . . . . . . . . .
Handling safety 312
. . . . . . . . . . . . . . . . . . . .
Recharging precautions 313
. . . . . . . . . . . . .
Winter driving tips 240
. . . . . . . . . . . . . . . . . .
Before starting the engine 236
. . . . . . . . . . . . .
Brake pad wear limit indicators 219 . . . . . . . .
Brake system 215
. . . . . . . . . . . . . . . . . . . . . . . .
Brakes
Fluid level 300
. . . . . . . . . . . . . . . . . . . . . . . . .
Pad wear limit indicators 219
. . . . . . . . . . . .
Parking 142
. . . . . . . . . . . . . . . . . . . . . . . . . . .
Break −in tips 209
. . . . . . . . . . . . . . . . . . . . . . . .
Brightness control 110
. . . . . . . . . . . . . . . . . . . .
C
Car audio system 152
. . . . . . . . . . . . . . . . . . . .
Carbon monoxide caution 213
. . . . . . . . . . . . .
Cargo and luggage
Capacity 230
. . . . . . . . . . . . . . . . . . . . . . . . . .
Distribution 231
. . . . . . . . . . . . . . . . . . . . . . . .
Stowage precautions 230
. . . . . . . . . . . . . . .
Cassette player 152
. . . . . . . . . . . . . . . . . . . . . .
Checking and replacing fuses 314
. . . . . . . . .
Checking and replacing tires 304
. . . . . . . . . .
Checking brake fluid 300
. . . . . . . . . . . . . . . . . .
Checking the engine oil level 296
. . . . . . . . . .
Checking the radiator and condenser 299
. . . . . . . . . . . . . . . . . . . . .
Child restraint
Child restraint system 77
. . . . . . . . . . . . . . .
Installation 78, 83
. . . . . . . . . . . . . . . . . . . . . . Precautions
76
. . . . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 77 . . . . . . . .
Using a top strap 92
. . . . . . . . . . . . . . . . . . . .
Cigarette lighter and ashtray 192
. . . . . . . . . .
Cleaning the interior 279
. . . . . . . . . . . . . . . . . .
Clock 188
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Coat hooks 205
. . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather
Operation 240
. . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc auto changer
controller 152
. . . . . . . . . . . . . . . . . . . . . . . . . .
Compact disc player 152
. . . . . . . . . . . . . . . . . .
Controls, Instrument panel 2, 6
. . . . . . . . . . . .
Cooling system
Coolant level 298
. . . . . . . . . . . . . . . . . . . . . .
Radiator and reservoir 298
. . . . . . . . . . . . . .
Winter driving tips 240
. . . . . . . . . . . . . . . . . .
Corrosion prevention 276
. . . . . . . . . . . . . . . . .
Cruise control 142
. . . . . . . . . . . . . . . . . . . . . . .
Cup holder 199
. . . . . . . . . . . . . . . . . . . . . . . . . .
D
Defogger, Rear window 115
. . . . . . . . . . . . . . .
Differential, Limited slip 220
. . . . . . . . . . . . . . .
Dimmer switch, Headlight 108
. . . . . . . . . . . . .
Directional signals 108
. . . . . . . . . . . . . . . . . . .