166Checking and refilling
C
Ca
au
ut
ti
io
on
n
Do not disconnect the vehicle battery when the ignition is on or when the
engine is running, as the electrical system (electronic components) could
otherwise be damaged.
In order to protect the casing from UV radiation, do not expose vehicle
battery to direct sunlight.
K
Location
The battery is in the engine compartment.
To start with the help of another battery
⇒"Emergency starting"
chapter.
K
Checking acid level
Please refer to the warning notes in the chapter "Engine
compartment" before starting any type of work on the engine or
the engine compartment.
The acid/electrolyte level should be checked regularly in the
following cases:
– high mileage
– in countries with a warm climate
– old battery
The battery is otherwise service-free.
The acid level should always be around the
m ma
ax
x.
.mark on the
longside of the battery. It should never be filled above the
m ma
ax
x.
.
mark nor be allowed to drop below the m
mi
in
n.
.mark.
We recommend that the electrolyte level be checked and corrected
by a Technical Service Centre.
B Ba
at
tt
te
er
ry
y wwi
it
th
h aa mma
ag
gi
ic
c eey
ye
e*
*
A round viewing window is located on the upper side of the battery
⇒arrow, fig. 124. This magic eye will change its color according to
the charge condition or the acid level of the battery.
Air bubbles can distort the true color. You should, therefore, tap
carefully on the magic eye.
If the display in the viewing window has no color or is light yellow,
the acid level in the battery is too low. Distilled water must be
added. We recommend that the battery be replaced if it is older
than 5 years.
We recommend that the electrolyte level be checked and corrected
by a Technical Service Centre.
B6E-030DFig. 124
169 Checking and refilling
Safety FirstControls and equipment Tips and Maintenance Technical Data
First you must remove cover 1as follows:
•Gently pull the lateral flanges of the battery cover
⇒arrow, fig.
126. Lift the cover to about 45° and remove it by pulling in the
direction of arrow
A.
Remove cover
2as follows:
•Gently pull lateral flange of the battery cover
⇒arrow, fig. 127.
Lift the cover by pulling in the direction of arrowB.
•To replace cover proceed in reverse order.
Constant removal and fitting of the battery is not recommended.
This can result in damage to the battery and the fuse box. If this
happens proceed to a Technical Service.
K
W Wi
in
nd
ds
sc
cr
re
ee
en
n wwa
as
sh
he
er
r
Location
The fluid container is located in the engine compartment on the
right. The container holds about 2 liters. In vehicles with a
headlight washer system*, it holds about 4.5 liters.
K
Filling the container
You need to add a window cleaning solution with a wax remover to
the water. There are severala ap
pp
pr
ro
op
pr
ri
ia
at
te
e ppr
ro
od
du
uc
ct
ts
s,
, cco
on
nt
ta
ai
in
ni
in
ng
g
i is
so
op
pr
ro
op
pi
il
li
ic
c aal
lc
co
oh
ho
ol
l oor
r mme
et
th
hy
yl
la
at
te
ed
d ssp
pi
ir
ri
it
ts
s
with wax dissolving
properties (with anti-freeze additive in winter) on the market,
because plain water is not usually sufficient to clean the glass and
Fig. 127
Fig. 128
B
2
B6Y-056S
B6Y-0042K
