2005 LOTUS ELISE low

RECOMMENDED LUBRICANTS
EngineIn order to enhance the longevity and reliability of the car, it
is most important that only the specified lubricants are used. It
is an entirely false economy to try to save money by using lower quality oils, which may break down before the next change in
-
terval and provide inadequate protection before the end of the
term. High oil consumption may also result.
For topping up purposes during the running-in period prior to
the First After Sales Service, a top quality mineral or semi-syn
-
thetic 5W/40 oil should be used. At the First After Sales Service and completion of the running-in period, a fully synthetic 5W/40
oil such as Texaco Havoline Synthetic should be used. This oil
has been tested in all climatic conditions likely to be encountered,
and offers advantages in ease of cranking, smooth cold running
and fuel economy at low temperatures, in combination with good
wear protection at elevated temperatures and at high engine speeds. If Texaco/Havoline products are not available, an oil meeting the following specification should be used.
NOTICE: Note that Lotus does not recommend the use of any oil additives and use of such additives may invalidate the terms
of your car’s warranty.
Viscosity: 5W/40
Quality Standard: API SJEC; ILSAC; ACEA A3
Capacity - refill inc. filter 4.4 litre
(Cars fitted with front mounted oil coolers contain an additional
3.5 litres, but this oil is not drained during routine servicing) Difference between high & low dipstick marks
1.5 litre
Oil change interval Refer to Maintenance Schedule
‘Severe Service’ Conditions Certain operating conditions can cause rapid degradation of
the oil quality, either by the accumulation of dirt particles, or by
the absorption of water from condensation. If any of the ‘severe
service’ conditions described below apply, it is recommended
that the oil and filter be changed twice as frequently as is listed in the Maintenance Schedule.
Recommended Lubricants
153

oh_croft_InD.indd 15320/05/2004 07:59:19ProCarManuals.com

Unladen weight - total 912 kg ) inc.
(heaviest) - front 344 kg ) full fuel
- rear 568 kg ) tank
Max. weight - total 1162 kg > incl.
- front 441 kg > occupants
- rear 721 kg > & luggage
Trailer towing Not permissible
Capacities Engine oil (refill inc. filter) 4.7 U.S. qt. (4.4 litre)
(+3.7 U.S. qt (3.5) litre if front mounted oil coolers are drained) High/low dipstick mark difference 1.6 U.S. qt. (1.5 litre)
Transmission oil 2.4 U.S. qt. (2.3 litre)
Fuel tank 10.6 U.S. gall. (40 litre)
Cooling system 12.7 U.S. qt. (12 litre)
A.C. refrigerant (R134a) 1.2 lb (0.55 kg)
Front Suspension

T ype Independent. Upper and
lower wishbone co-axial
coil spring/telescopic
damper unit; anti-roll bar
Steering axis inclination 12° nominal
Geometry specification - Standard: Mid-laden ride height (reference height for geometry check)
- front 135 mm below front end
of chassis siderail
- rear 135 mm below rear end
of chassis siderail
Castor - optimum + 3.8°
- tolerance range + 3.5° to + 4.1°;
max. side/side 0.35°
Camber - optimum - 0.1°
- tolerance range + 0.1° to - 0.3°
max. side/side 0.2°
Alignment - optimum Zero - tolerance range 0.5 mm toe-out, to
0.7mm toe-in overall
Technical Data
156

oh_croft_InD.indd 15620/05/2004 07:59:19ProCarManuals.com

Geometry specification - Sport option:Mid-laden ride height (reference height for geometry check)
- front 130 mm below front end
of chassis siderail
- rear 130 mm below rear end
of chassis siderail
Castor - optimum + 3.8°
- tolerance range + 3.5° to + 4.1°;
max. side/side 0.35°
Camber - optimum - 0.3°
- tolerance range - 0.1° to - 0.5°
max. side/side 0.2°
Alignment - optimum Zero - tolerance range 0.5 mm toe-out, to
0.5 mm toe-in overall
Rear Suspension
Type Independent. Upper and
lower wishbone; co-axial
coil spring/telescopic
damper.
Geometry specification - Standard: Mid-laden ride height (reference height for geometry check)
- front 135 mm below front end
of chassis siderail
- rear 135 mm below rear end
of chassis siderail
Camber - optimum - 1.8°
- tolerance range - 1.6° to - 2.0°
max.side/side 0.2°
Alignment - optimum 1.2 mm toe-in each side - tolerance range 1.2 to 1.8mm toe-in each
side
max.side/side 0.3 mm
Geometry specification - Sport option: Mid-laden ride height (reference height for geometry check)
- front 130 mm below front end
of chassis siderail
- rear 130 mm below rear end
of chassis siderail
Technical Data
157

oh_croft_InD.indd 15720/05/2004 07:59:20ProCarManuals.com

LIMITED WARRANTYLotus Cars U.S.A. Inc.; 2236 Northmont Parkway, Duluth,
Georgia 30096.
LOTUS CARS U.S.A. Inc., (the Company) warrants each new
Lotus motor car sold by the Company or an authorised Lotus
dealer* in the U.S.A., and each Lotus replacement part supplied by the Company or an authorised Lotus dealer* in the U.S.A., to
be free from defects in material and workmanship under normal
use and service, and subject to the terms and conditions in this Limited Warranty, for the applicable Warranty Period set forth
in Paragraph 1. (*Authorised Lotus dealers are not owned by, or are agents of, the Company) The paragraphs below are the only and exclusive rem
-
edies under the terms of the warranty. The Limited Warranty excludes cer tain par ts and sets of
circumstances which are set out in section 4 below.
1. WARRANTY PERIODS
(a) LIMITED WARRANTY - Cars.
The Company warrants each new car to be free from defects
in material and workmanship for a period of thirty six (36) months or 36,000 miles, whichever first occurs, after the first
occurring of the following dates:
i) date of delivery of the car to the retail original owner;
ii) registration as a dealer demonstrator.
CONSULT YOUR SALES DOCUMENTS TO DETERMINE
THE WARR ANT Y START DATE ON YOUR CAR; SPE AK
TO YOUR DEALER OR LOTUS CARS USA IF YOU ARE IN DOUBT.
(b) LIMITED WARRANTY - Replacement Parts.
Genuine Lotus replacement parts are warranted to be free
from defects in materials and workmanship for 12 months
from the date of their installation or until the expiration of the
car’s limited warranty term, whichever occurs last.

Limited Warranty
162

oh_croft_InD.indd 16220/05/2004 07:59:20ProCarManuals.com

(c) LIMITED WARRANTY - Corrosion Perforation.
The Company’s Limited Corrosion Perforation Warranty (as
set forth in Paragraph 4 (c)) runs for a period of 8 years from
the commencement of the Car Limited Warranty as specified
in paragraph 1(a).
2. LIMITATIONS THE COMPANY DOES NOT AUTHORIZE ANY PERSON
TO CREATE ANY OTHER OBLIGATION IN CONNECTION WITH ITS CARS. ANY IMPLIED WARRANTY OF MERCHANT
-
ABILITY OR FITNESS FOR A PARTICULAR PURPOSE, AP
-
PLICABLE TO A CAR OR PART IS LIMITED IN DURATION
TO THE TIME PERIODS SET FORTH IN PARAGRAPH 1.
3. EXCLUSIVE REMEDIES THE PERFORMANCE OF REPAIRS AND NEEDED AD
-
JUSTMENTS ARE THE EXCLUSIVE REMEDIES UNDER
THIS WRITTEN WARRANTY OR ANY IMPLIED WARRANTY.
THE COMPANY SHALL NOT BE LIABLE FOR INCIDENTAL OR CONSEQUENTIAL DAMAGE RESULTING FROM THE BREACH OF ANY WARRANTY. S O M E S TAT E S D O N OT A L LO W L I M I TAT I O N S O N
HOW LONG AN IMPLIED WARR ANT Y L ASTS, OR THE
EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSE
-
QUENTIAL DAMAGES, SO THE ABOVE LIMITATIONS OR EXCLUSIONS MAY NOT APPLY TO YOU.
4. EXTENT OF COMPANY OBLIGATIONS
(a) LIMITED WARRANTY - Car. This warranty extends to
each original and subsequent owner of a Lotus motor car
within the warranty period expressed in Paragraph 1(a). The
obligations of the Company under this warranty are limited
to the repair or, at its option, the replacement with a new or remanufactured unit without charge for labour or part, of any
part or assembly or component determined to be defective
in material or workmanship during the applicable warranty period. All items which are replaced become the property of
the Company to the fullest extent allowed under applicable
law. All Service under this warranty must be performed by a
Lotus Dealer at its place of business.
Limited Warranty
163

oh_croft_InD.indd 16320/05/2004 07:59:21ProCarManuals.com

(b) LIMITED WARRANTY - Replacement Parts.
The obligations of the Company during the warranty term
are limited to the repair or, at its option, the replacement of
any genuine Lotus part determined to be defective in mate
-
rial or workmanship during the warranty period expressed in
paragraph 1(b). All replaced parts shall become the property
of the Company.
(c) LIMITED WARRANTY - Corrosion Perforation.
The Company warrants to the original owner and each subse-
quent owner during the warranty period set forth in Paragraph
1(c), that if corrosion perforation occurs on the chassis or com
-
posite body structure of a Lotus motor car, within the warranty
period expressed in Paragraph 1(c), the parts or components
affected by such perforation shall be repaired or replaced,
without charge for labour or parts. Provided, however, that:
a) the Lotus car must be brought to an authorised Lotus dealer
for inspection at least one time each year; and
b) the Lotus car has been used and maintained in a normal and reasonable manner.
c) corrosion perforation is not due to any or all of the follow
-
ing: an accident; abuse; damage; installation of an accessory;
chemical substance; an act of nature; fire; or salvaged car.
(d) OBTAINING REPAIRS.
All warranted repairs will be effected at Lotus Dealers upon
presentation of suitable evidence of eligibility. A reasonable
time must be allowed for the dealership to perform necessary
repairs, and customers are requested to allow such a reason
-
able amount of time. It is not Lotus Cars USA’s responsibility to
provide the customer with a loan car during these repairs. The
provision of a loan car should be discussed with the dealer.
5. EXCLUSIONS FROM WARRANTY COVERAGE (see also section 6)
(a) TIRES. The only provided warranty for tires is the written
warranty issued by the tire supplier and included with the owner literature supplied with your car.
(b) CAR SPECIFICATION. The obligations of the Company
under this Limited Warranty apply only to cars built by the manufacturer to USA specification for road use (i.e. not to
Limited Warranty
164

oh_croft_InD.indd 16420/05/2004 07:59:21ProCarManuals.com

cars imported into the USA which are not manufactured to a
USA specification.
(c) MAINTENANCE; SERVICE ITEMS; WEAR & TEAR.
Maintenance services are not covered , these include (al-
though this list is not exhaustive):
i) maintenance services such as tune-ups, cleaning, polishing, lubrication, wheel balancing and alignment, brake, clutch, belt
and other normal adjustments,
ii) recharging or replacement of the battery where the car is not used for prolonged periods and a battery charger is not
used,
iii) the repair or replacement of service items such as lubri
-
cants, fluids, spark plugs, wiper blades, filters, belts, hoses, brake pads and linings clutch components, light bulbs or glass,
or,
iv) after the first three months of service (unless as part of a
warranty repair), the air conditioner refrigerant, or
v) the deterioration of paintwork, upholstery (see para 5n) or any other part, assembly or component as a consequence of
normal wear and tear or exposure to the elements, including
airborne fallout (chemicals, tree sap etc.).
vi) body panel, glass and trim adjustments may intermittently be required to prevent excessive water ingress, or noise and
vibration and so should be considered as routine mainte
-
nance.
(d) INCIDENTAL AND CONSEQUENTIAL DAMAGES. UNLESS OTHERWISE EXPRESSLY PROVIDED BY LAW
THIS WARRANTY NEITHER COVERS NOR EXTENDS TO ANY INCIDENTAL OR CONSEQUENTIAL DAMAGE OR EXPENSE. SUCH DAMAGE AND EXPENSE INCLUDES
(ALTHOUGH IT IS NOT AN EXHAUSTIVE LIST) INCONVEN
-
IENCE, HOTEL OR RESTAURANT EXPENSES, TOWING
OR PARKING FEES, CAR RENTALS OR THE LOSS OF
TIME OR USE OF THE CAR.
SOME STATES DO NOT ALLOW THE EXCLUSION OR LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAM
-
AGES, SO THE ABOVE LIMITATION OR EXCLUSIONS MAY NOT APPLY.
(e) ACCIDENTS AND SIMILAR EVENTS.
Car’s malfunctions or damage resulting from accidents, col-
Limited Warranty
165

oh_croft_InD.indd 16520/05/2004 07:59:21ProCarManuals.com

extent of such noises, including brake squeal, engine and
exhaust noise, gear whine, knocks, rattles and wind noise
will differ from car to car, with the level of acceptability being
determined by the Company.
n) Lotus cars are upholstered with premium quality leather specifically tanned and dyed for automotive use. As a natural
material, leather ages in various ways and may, over time,
exhibit signs of cracking, scuffing, shrinking, etc. Such wear is the natural maturing of the leather and is not covered under
warranty.
o) Salvage title or total loss; the warranty does not cover any
car which can no longer by used on the road because it only
has salvage value or has been declared as an insurance write
off due to an accident or damage.
6. OBLIGATIONS OF OWNERS. ALL WARRANTIES ARE
VOID IF OWNERS FAIL TO PROPERLY USE AND MAIN
-
TAIN THE CAR.
The Company has no obligation under this warranty in
the following circumstances:
• If the car has not been driven in accordance with the ‘Break-in’
instructions detailed in the Owner‘s Handbook;
• if the maintenance services and maintenance instructions specified in this Handbook are not performed and followed
at the prescribed intervals. Car owners must keep up to date
and accurate records of car service and maintenance in order
for any warranty claim to be considered;
• if the motor car is used for commercial service, or for racing or reliability trials, or in a competitive manner, including timed
runs or laps;
• if the motor car is registered or used outside the Continental United States, Canada, Hawaii, Puerto Rico, Alaska, Guam
and the United States Virgin Islands;
• if failure or malfunction of the motor car or of any warranted part, component or assembly results from an accident; or,
• if failure or malfunction is caused by misuse, abuse or neg
-
ligence in use of the motor car, including, but not limited to,
where the car is not driven on road surfaces which have been
maintained to a standard to allow regular vehicle traffic, or
Limited Warranty
167

oh_croft_InD.indd 16720/05/2004 07:59:22ProCarManuals.com