2005 HONDA S2000 maintenance schedule

If Honda MTF is not available, you
may use an SAE 10W-30 or 10W-40
viscosity motor oil with the API
Certif ication seal that says ‘‘FOR
GASOLINE ENGINES’’ as a
temporary replacement. However,
motor oil does not contain the proper
additives, and continued use can
cause stiffer shifting. Replace as
soon as it is convenient.
The transmission should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
If you are not sure how to check and
add f luid, contact your dealer.
Check the f luid level with the
transmission at normal operating
temperature and the vehicle sitting
on level ground. Remove the
transmission f iller bolt, and caref ully
f eel inside the bolt hole with your
f inger. The f luid level should be up
to the edge of the bolt hole. If it is
not, add Honda Manual
Transmission Fluid (MTF) until it
starts to run out of the hole. Install
the f iller bolt, and tighten it securely.
Manual T ransmission Fluid
Maint enance
137
CORRECT LEVEL
FILLER BOLT

Use an SAE 90 viscosity hypoid gear
oil, API service classif ied GL5 or
GL6 only.
Put a new washer on the f iller bolt,
then reinstall the f iller bolt. Tighten
it securely. Tightening torque:
The dif f erential should be drained
and ref illed with new f luid according
to the time and distance recommen-
dations in the maintenance schedule.
If you are not sure how to check and
add f luid, contact your dealer.
Check the f luid level with the
dif f erential at normal operating
temperature and the vehicle sitting
on level ground. Remove the
dif f erential f luid f iller bolt and
washer, and caref ully f eel inside the
bolt hole with your f inger. The f luid
level should be up to the edge of the
bolt hole. If it is not, slowly add f luid
until it starts to run out of the hole.
Dif f erential Fluid
138
CORRECT LEVEL
FILLER BOLT
33 lbf·ft (45 N·m , 4.6 kgf·m)

Check the brake f luid level in the
reservoirs monthly.
Always use Honda Heavy Duty
Brake Fluid DOT 3. If it is not
available, you should use only DOT 3
or DOT 4 f luid, f rom a sealed
container, as a temporary
replacement.The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If the level is at or
below the MIN mark, your brake
system needs attention. Have the
brake system inspected f or leaks or
worn brake pads.The f luid level should be between
theMINandMAXmarksontheside
of the reservoir. If it is not, add
brake f luid to bring it up to that level.
Use the same fluid specified for the
brake system.
Replace the brake f luid according to
the time recommendation in the
maintenance schedule.
Brake f luid marked DOT 5 is not
compatible with your vehicle’s
braking system and can cause
extensive damage. Using any non-Honda brake f luid can
cause corrosion and decrease the lif e
of the system. Have the brake
system f lushed and ref illed with
Honda Heavy Duty Brake Fluid
DOT 3 as soon as possible.
A low f luid level can indicate a leak
in the clutch system. Have this
system inspected as soon as possible.
Brake System
Clutch System
Brake and Clutch Fluid
Maint enance
139
MAX
MIN MAX
MIN

If you need to park your vehicle f or
an extended period (more than one
month), there are several things you
should do to prepare it f or storage.
Proper preparation helps prevent
deterioration and makes it easier to
get your vehicle back on the road. If
possible, store your vehicle indoors.Fill the f uel tank.
Change the engine oil and f ilter.
Wash and dry the exterior
completely.
Cleantheinterior.Makesurethe
carpeting, floor mats, etc., are
completely dry.
Raise the convertible top cover.
Leave the parking brake off. Put
the transmission in Reverse. Block the rear wheels.
If the vehicle is to be stored f or a
longer period, it should be
supported on jackstands so the
tires are of f the ground.
Leave one window open slightly (if
the vehicle is being stored
indoors).
Disconnect the battery.
Cover the vehicle with a
‘‘breathable’’ cover, one made
f rom a porous material such as
cotton. Non-porous materials, such
as plastic sheeting, trap moisture,
which can damage the paint.
If you store your vehicle f or 1 year or
longer, have your dealer perf orm the
inspections called f or in the 2 years/
30,000 miles (48,000 km)
maintenance schedule (Normal
Conditions) as soon as you take it
out of storage (see page ). The
replacements called f or in the
maintenance schedule are not
needed unless the vehicle has
actually reached that time or mileage.
Support the f ront wiper blade
arms with a f olded towel or rag so
they do not touch the windshield.
To minimize sticking, apply a
silicone spray lubricant to all door
and trunk seals. Also, apply a
vehiclebodywaxtothepainted
surfaces that mate with the door
and trunk seals. If possible, periodically run the
engine until it reaches f ull
operating temperature (the
cooling f an cycles on and of f
twice). Pref erably, do this once a
month.
125
Vehicle Storage
Maint enance
155

ÎÎ
The burning of gasoline in your
vehicle’s engine produces several by-
products. Some of these are carbon
monoxide (CO), oxides of nitrogen
(NOx), and hydrocarbons (HC).
Gasoline evaporating f rom the tank
also produces hydrocarbons.
Controlling the production of NOx,
CO, and HC is important to the
environment. Under certain
conditions of sunlight and climate,
NOx and HC react to f orm
photochemical ‘‘smog.’’ Carbon
monoxide does not contribute to
smog creation, but it is a poisonous
gas.
In Canada, Honda vehicles comply
with the Canadian emission
requirements, as specif ied in an
agreement with Environment
Canada, at the time they are
manuf actured.
Your vehicle has a positive
crankcase ventilation system. This
keeps gasses that build up in the
engine’s crankcase f rom going into
the atmosphere. The positive crankcase ventilation valve routes
them from the crankcase back to the
intake manif old. They are then
drawn into the engine and burned.
As gasoline evaporates in the f uel
tank, an evaporative emissions
control canister f illed with charcoal
adsorbs the vapor. It is stored in this
canister while the engine is of f . Af ter
the engine is started and warmed up,
the vapor is drawn into the engine
and burned during driving.
The United States Clean Air Act
sets standards f or automobile
emissions. It also requires that
automobile manufacturers explain to
owners how their emissions controls
workandwhattodotomaintain
them. This section summarizes how
the emissions controls work.
Scheduled maintenance is on page
.
The onboard ref ueling vapor
recovery (ORVR) system captures
the f uel vapors during ref ueling. The
vapors are adsorbed in a canister
f illed with activated carbon. While
driving, the f uel vapors are drawn
into the engine and burned of f .
125
Emissions Cont rols
Crankcase Emissions Control
System Evaporative Emissions Control
System
The Clean Air Act
Onboard Ref ueling Vapor
Recovery
T echnical Inf ormation
189

CONT INUED
Lights....................
Bulb Replacement .140
.......................................
Indicator .40
..................................
Turn Signal .48
....................................
Load Limits .108
......
LOCK (Ignition Key Position) . 53
Locks .......
Anti-thef t Steering Column . 53
............................
Fuel Fill Door .101
.................................
Power Door .54
...........................................
Trunk .54
........................
Low Coolant Level .104
.........................
Low Fuel Indicator .42
...
Low Oil Pressure Indicator . 40,170
...
Lubricant Specif ications Chart . 184
...........
Luggage, Storing (Cargo) . 107..................
New Vehicle Break-in . 100
.....................
Normal Shif t Speeds .116
...................
NOTICE, Explanation of . i
...............
Numbers, Identif ication . 182
..................................
Maintenance .121
Owner’s Maintenance ...................................
Checks .124
........................................
Record .127
......................
Required Indicator .43
..........................................
Saf ety .122
....................................
Schedule .123 .
Malf unction Indicator Lamp . 41,171
...................
Manual Transmission . 115
........
Manual Transmission Fluid . 137
...............................
Meters, Gauges .44
...................
Methanol in Gasoline . 100
..........................
Mirrors, Adjusting .66
...............
Modif ying Your Vehicle . 106
..............
Panel Brightness Control . 49
...........................................
Parking .117
.................................
Parking Brake .67
Parking Brake and Brake System .....................................
Indicator .172
.................................
Parking Lights .48
.............................
PGM-FI System .190
...................................
Pollen Filter .146
..........................
Power Door Locks .54
..................
Power Socket Location . 68
..............................
Power Windows .59
...
Octane Requirement, Gasoline . 100
.........................................
Odometer .44
...............................
Odometer, Trip .44
Oil ........................
Change, How to .132
......................
Change, When to .125
......................
Checking Engine .103
..............
Pressure Indicator . 40,170 Selecting Proper Viscosity
......................................
Chart .132
...........
ON (Ignition Key Position) . 53
Onboard Ref ueling Vapor ....................................
Recovery .189
.........................
Opening the Trunk .54
..............................
Outside Mirrors .66
....................
Overheating, Engine .167
....
Owner’s Maintenance Checks . 124
.........................
Oxygenated Fuels .100
Index
M N
O
P
INDEX
V

ÎÎ Î
.........
Pregnancy, Using Seat Belts . 14
........................
Preparing to Drive .113
.........
Protecting Adults and Teens . 10
...
Additional Safety Precautions . 15
.....
Advice f or Pregnant Women . 14
........................
Protecting Children .23
.....................
General Guidelines .23
.......
Protecting Larger Children . 31
.........
Protecting Small Children . 27
...................
Radiator Overheating . 167
...............
Radio/CD Sound System . 78
...................
Radio Thef t Protection . 94
...................
Readiness Codes . 171,192
..
Rear Lights, Bulb Replacement . 144
............................
Rear View Mirror .66
.................
Rear Window Def ogger . 50
................
Reclining the Seat-backs . 58
.......
Recommended Shif t Speeds . 116
Recovery Vehicle, Emergency .......................................
Towing .179
........................................
Ref ueling .101
.................
Reminder Indicators . 39,40
.......................
Remote Transmitter .56 Replacement Inf ormation
..............
Dust and Pollen Filter . 146
................
Engine Oil and Filter . 132
..........................................
Fuses .174
................................
Light Bulbs .140
....................................
Schedule .123
...........................................
Tires .152
.............................
Wiper Blades .147
Replacing Seat Belts Af ter a ............................................
Crash .17
..........
Reporting Saf ety Def ects . 196
Reserve Tank, Engine ...............................
Coolant .104, 134
...............................
Restraint, Child .23
...........................
Reverse Lockout .116
................................
Rotation, Tire .151
..................................
Saf ety Belts .8, 16
.........
Safety Defects, Reporting . 196
.................................
Saf ety Features .7
...........................................
Airbags .9
.......................................
Seat Belts .8
.............
Saf ety Labels, Location of . 36
...............................
Saf ety Messages .ii ..................................
Satellite Radio .83
.....................................
Seat Belts .8, 16
...............
Additional Information . 16
.....
Advice f or Pregnant Women . 14
Automatic Seat Belt ...............................
Tensioners .17
.....................................
Cleaning .145
......................
Lap/Shoulder Belt .16
................................
Maintenance .17
Reminder Indicator and ................................
Beeper .16, 40
...................
System Components . 16
...............
Use During Pregnancy . 14
........................
Seats, Adjusting the .58
...............................
Serial Number .182
...........................
Service Intervals .125
...........................
Service Manual .197
.........
Service Station Procedures . 101
............................
Setting the Clock .45
Shif ting .............
Manual Transmission . 115
Side Turn Signal, Bulb .............................
Replacement .143
...............................
Signaling Turns .48
.....................................
Snow Tires .153
..................................
Sound System .78
Index
S
R
VI