2005 HONDA PILOT headlights

µµ µ
µ
µ
µ µ
Youshouldcheckthefollowing
items at the specif ied intervals. If
you are unsure of how to perf orm
any check, turn to the appropriate
page listed.
Engine oil level Check every
time you fill the fuel tank. See
page .
Engine coolant level Check the
radiator reserve tank every time
you f ill the f uel tank. See page . Brakes Check the f luid level
monthly. See page .
Tires Check the tire pressure
monthly. Examine the tread f or
wear and foreign objects. See page
.
Automatic transmission Check
the f luid level monthly. See pages . Lights Check the operation of
the headlights, parking lights,
taillights, high-mount brake light,
and license plate lights monthly.
See page .
149
149
204 205 210
216
208
Maintenance Schedule
Owner’s Maintenance Checks
Maint enance
191

Theheadlightswereproperlyaimed
when your vehicle was new. If you
regularly carry heavy items in the
trunk, readjustment may be required.
Adjustments should be perf ormed by
your dealer or other qualif ied
mechanic.
Your vehicle has halogen headlight
bulbs. Handle a bulb by its steel base,
and protect the glass from contact
with your skin or hard objects. If you
touch the glass, clean it with
denaturedalcoholandacleancloth.Remove the electrical connector
f rom the bulb by pulling the
connector straight back.
Remove the rubber weather seal
by pulling on the tab.Unclip the end of the hold-down
wire f rom its slot. Pivot it out of
the way, and remove the bulb.
Insert the new bulb and make sure
it is right side up. The tabs on the
base f it into the indentations in the
headlight assembly. Pivot the hold-
down wire back in place, and clip
the end into the slot.
Reinstall the rubber seal and make
sure one of its arrow is pointing up.
Push the electrical connector onto
the new bulb.
1.
2. 3.
4.
5.
6.
Headlight A iming
Replacing a Headlight Bulb
Lights
208
NOTE:
CONNECTOR
BULB
Halogen headlight bulbs get
very hot when lit. Oil, perspiration, or a
scratch on the glass can cause the bulb
to overheat and shatter.

Diagnosing why the engine won’t
start f alls into two areas, depending
on what you hear when you turn the
key to START (III):You hear nothing, or almost
nothing. The engine’s starter
motor does not operate at all, or
operates very slowly.
You can hear the starter motor
operating normally, or the starter
motor sounds like it is spinning
f aster than normal, but the engine
does not start up and run.
When you turn the ignition switch to
START (III), you do not hear the
normal noise of the engine trying to
start. You may hear a clicking sound
or series of clicks, or nothing at all.
Check these things: Check the transmission interlock.
The transmission must be in Park
orNeutralorthestarterwillnot
operate.
Turn the ignition switch to ON (II).
Turn on the headlights, and check
their brightness. If the headlights
areverydimordonotcomeonat
all, the battery is discharged. See
on page .
Turn the ignition switch to START
(III). If the headlights do not dim,
check the condition of the f uses. If
thefusesareOK,thereis
probably something wrong with
the electrical circuit f or the
ignition switch or starter motor.
You will need a qualif ied
technician to determine the
problem (see
on page ). If the headlights dim noticeably or
go out when you try to start the
engine, either the battery is dis-
charged or the connections are
corroded. Check the condition of
the battery and terminal connec-
tions (see page ). You can
then try jump starting the vehicle
f rom a booster battery (see page
).
Are you using the proper starting
procedure? Ref er to on page .
In this case, the starter motor’s
speed sounds normal, or even f aster
than normal, when you turn the
ignition switch to START (III), but
the engine does not run.
230
237 221
230
159
Nothing Happens or the Starter
Motor Operates Very Slowly Jump Starting
Emergency T owing Starting the
Engine
T he Starter Operates Normally
If theEngineWon’tStart
T aking Care of t he Unexpect ed
229

If something electrical in your
vehicle stops working, the first thing
youshouldcheckforisablownfuse.
Determine f rom the chart on pagesand , or the diagram on the
fuse box lid, which fuse or fuses
control that device. The diagram f or
theinteriordriver’ssidefuseboxis
on the kick panel below the f use box.
Check those f uses f irst, but check all
the f uses bef ore deciding that a
blown f use is the cause. Replace any
blown f uses, and check if the device
works.
Turn the ignition switch to LOCK
(0). Make sure the headlights and
all other accessories are off.
Remove the cover f rom the f use
box. Check each of the large f uses in
the primary under-hood f use box
by looking through the top at the
wire inside. Remove the screws
with a Phillips-head screwdriver.
Check the smaller f uses in the
under-hood f use box and all the
fuses in the interior fuse boxes by
pulling out each f use with the f use
puller provided in the primary
under-hood f use box.
Look f or a burned wire inside the
f use. If it is burned, replace it with
one of the spare f uses of the same
rating or lower.
1.
2. 3.
4.
5.
241 242
CONT INUED
Checking and Replacing Fuses
Fuses
T aking Care of t he Unexpect ed
239
BLOWN
BLOWN

µ µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
Specif ications
T echnical Inf ormation
247
Battery
Fuses
Engine
Alignment
Tires
Lights
60 W/55 W
12 V
60 psi (420 kPa , 4.2 kgf/cm
)
32 psi (220 kPa , 2.2 kgf/cm)
T155/90D16 110M P235/70R16 104S 1°88’
0°50’ 0°50’
0.00 in (0.0 mm)
0.00 in (0.0 mm) 10.0 : 1
211.8 cu-in (3,471 cm
)
3.50 x 3.66 in (89.0 x 93.0 mm)
12 V
12 V
12 V
12 V
12 V
12 V
12 V
12 V
12 V 12 V
12 V
12 V
5W
27 W/8 W
5W
21 W/5 W
21 W/5 W
21 CP (18 W)
5W
18 W
6.2 W
5W
1.1 W
3.8 W
12 V 65 AH/20 HR 14 V 12 V 12.4 W 1.4 W
Capacity Interior
Under-hood
Type
BorexStroke
Displacement
Compression ratio
Spark plugs
Water cooled 4-stroke SOHC,
V6 gasoline engine
Toe-in
Camber
Caster
Size
Pressure IZFR5K-11
SKJ16DR-M11
Headlights
Front side marker lights
Front turn signal lights/
Parking lights
Rear side marker lights
Rear turn signal/hazard lights
Stop/Taillights
Backup lights
License plate lights
High-mount brake light
Individual map lights
Tailgate light
Vanity mirror light
Door (Courtesy) light
Grab rail lights
Console lights See page
242or the fuse label
attached to the dashboard.
See page 242or the fuse label
attached to the inside of the fuse
box door under the dashboard.
See page 241or the fuse box
cover.
Front/Rear
Spare
Front/Rear
Spare Front
Rear
Front
Rear
Front
Driver’s side
Passenger’s side
(1157 NA)
(168)
(7443)
(7443) (921)
(168)
(921)
(204)
(HB2)
(168)
Front
Rear
Front
Rear
Front NGK:
DENSO:

CONT INUED
............................
Capacities Chart .246
.............
Carbon Monoxide Hazard . 53
.............................
Carrying Cargo .153
..............
CAUTION, Explanation of . ii
..........................
CD Changer .113, 114
.......................................
CD Player .111
........................
Certif ication Label .244
............................................
Chains .220
....................
Changing a Flat Tire .225
...
Accessories and Modif ications . 151
ACCESSORY (Ignition Key .......................................
Position) .77
..............
Accessory Power Sockets . 95
....................
Additives, Engine Oil . 199
.............................
Airbag (SRS) .11, 23
..........
Airbag System Components . 23
..............
Air Conditioning System . 100
.....................
Rear A/C Control .105
.......................
Air Pressure, Tires .217
......................................
Antif reeze .202
Anti-lock Brakes (ABS) ...............................
Indicator .59, 169
...................................
Operation .169
..............
Anti-thef t, Audio System . 123
.
Anti-thef t Steering Column Lock . 77
................
Audio System . 106,109,119
...
Automatic Seat Belt Tensioners . 21
.............
Automatic Speed Control . 138
..............
Automatic Transmission . 160
..........................
Capacity, Fluid .204
...............
Checking Fluid Level . 204
.......................................
Shif ting .160
.
Shif t Lever Position Indicator . 160................
Shif t Lever Positions . 161
....................
Shif t Lock Release . 163
Battery Charging System ...........................
Indicator .58, 234
............................
Jump Starting .230
..............................
Maintenance .221
............................
Specif ications .247
..............................
Bef ore Driving .145
..................................
Belts, Seat .10, 20
...........................
Beverage Holders .95
..................................
Booster Seats .50
Brakes ...........
Anti-lock System (ABS) . 169
.............
Break-in, New Linings . 146
...........................................
Fluid .206
....................
Bulb Replacement .210
.........................................
Parking .93
.................
System Indicator . 59,236
........................
Wear Indicators .168
.............................
Braking System .168
.................
Break-in, New Vehicle . 146
..
Brightness Control, Instruments . 72........................
Brights, Headlights .71
Bulb Replacement .....................
Brake Lights .210, 211
..........................
Back-up Lights .210
................
Front Parking Lights . 209
........
Front Side Marker Lights . 212
.................................
Headlights .208
........
High-mount Brake Lights . 211
.................................
Rear Bulbs .210
............................
Specif ications .247
.............
Turn Signal Light . 209,210
..............................
Bulbs, Halogen .208
Index
A
B
C
INDEX
I

..............................
Economy, Fuel .150
............
Emergencies on the Road . 223
.............
Battery, Jump Starting . 230
...........
Brake System Indicator . 236
................
Changing a Flat Tire . 225
.....
Charging System Indicator . 234
..................
Checking the Fuses . 239
.....
Low Oil Pressure Indicator . 234
...
Malf unction Indicator Lamp . 235
..................
Overheated Engine . 232
...........................
Emergency Brake .93
......................
Emergency Flashers .73
......................
Emergency Towing .237
.......................
Emissions Controls .251
.............
Emissions Testing, State . 254
Engine ....
Coolant Temperature Gauge . 67
Malf unction Indicator ................................
Lamp .58, 235
................
DANGER, Explanation of . ii
...................................
Dashboard .2, 56
................
Daytime Running Lights . 72
Daytime Running Lights .......................................
Indicator .63
.................................
Dead Battery .230
............
Def ects, Reporting Saf ety . 260
................
Def ogger, Rear Window . 73
......
Def rosting the Windows . 101,103
....................................
Dimensions .246
...............
Dimming the Headlights . 71
Dipstick ..........
Automatic Transmission . 204
..................................
Engine Oil .149
....................
Directional Signals . 62,71
........
Disc Brake Wear Indicators . 169
.....................
Disposal of Used Oil .201
Doors ..............
Locking and Unlocking . 78
..........
DOT Tire Quality Grading . 248
...........
Driver and Passenger Safety . 7...........................................
Driving .157
....................................
Economy .150
...................................
DVD Player .125
........
DVD Player Error Message . 134
Change Oil
........................................
How to .200
.............................
When to .192, 193
...
Charging System Indicator . 58,234
............
Checklist, Bef ore Driving . 158
..................
Childproof Door Locks . 79
Child Seats .........................................
LATCH .43
..........
Tether Anchorage Points . 47
...............
Climate Control System . 104
.........................
Clock, Setting the .124
.....................
Code, Audio System .123
........................
CO in the Exhaust .251
............
Cold Weather, Starting in . 159
......................
Compact Spare Tire .224
...................
Console Compartment . 95
.................
Consumer Inf ormation . 258
.............
Controls, Instruments and . 55
Coolant ........................................
Adding .202
....................................
Checking .149
.........................
Proper Solution .202
...................
Temperature Gauge . 66
Crankcase Emissions Control ........................................
System .251
............
Cruise Control Operation . 138 ....
Customer Service Inf ormation . 258
Index
D
E
II

CONT INUED
.............
Halogen Headlight Bulbs . 212
.................
Hazard Warning Button . 73
........................................
Headlights .71
........................................
Aiming .208
..............
Automatic Lighting Off . 72
............
Daytime Running Lights . 72
..................
High Beam Indicator . 63
...........
High Beams, Turning on . 71
............
Low Beams, Turning on . 71
.........................
Reminder Chime .72
........
Replacing Halogen Bulbs . 208
...................................
Turning on .71
...................................
Headphones .135
..............................
Head Restraints .87
.................................
Heated Mirror .89
...................................
Fan, Interior .100
...........................................
Features .99
....................
Filling the Fuel Tank . 147
Filters ...............................................
Oil .200
.............
Flashers, Hazard Warning . 73
...................
Flat Tire, Changing a . 225
Fluids ..........
Automatic Transmission . 204
..........................................
Brake .206
..........................
Power Steering .207 ................
Windshield Washers . 203
...................
Folding the Third Seat . 85
..........................
Four-way Flashers .73
.................................................
Fuel .146
...............................
Cap Message .68
......................
Fill Door and Cap .147
...........................................
Gauge .66
................
Octane Requirement . 146
........................
Reserve Indicator .63
........................
Tank, Filling the .147
.....................
Fuses, Checking the .239
...............
Gas Mileage, Improving . 150
.........................................
Gasoline .146
...............
Fuel Reserve Indicator . 63
...........................................
Gauge .66
................
Octane Requirement . 146
........................
Tank, Filling the .147
................
Gas Station Procedures . 147
Gauges ...
Engine Coolant Temperature . 67
...............................................
Fuel .66
GAWR (Gross Axle Weight .......................................
Rating) .174 GCWR (Gross Combined Weight
.......................................
Rating) .174
............
Gearshif t Lever Positions . 160
........................................
Glove Box .96
GVWR (Gross Vehicle Weight .......................................
Rating) .174
........
Oil Pressure Indicator . 58,234
..............
Oil, What Kind to Use . 199
...............................
Overheating .232
............................
Specif ications .247
............................
Speed Limiter .162
.......................................
Starting .159
.
Evaporative Emissions Controls . 251
...............................
Exhaust Fumes .53
Exhaust Gas Recirculation ........................................
System .252
Expectant Mothers, Use of Seat ........................................
Belts by .18
Index
F GH
INDEX
III