2005 HONDA INSIGHT brake

µµ
µ
If your vehicle needs to be towed,
call a prof essional towing service or
organization. Never tow your vehicle
with just a rope or chain. It is very
dangerous.
There are three popular types of
prof essional towing equipment.
The operator
loads your vehicle on the back of a
truck.
The tow
truck uses two pivoting arms that go
under the tires (f ront or rear) and lif t
them of f the ground. The other two
tires remain on the ground.
The tow
truck uses metal cables with hooks
on the ends. These hooks go around
parts of the f rame or suspension and the cables lif t that end of the vehicle
of f the ground. Your vehicle’s sus-
pension and body can be seriously
damaged.
If your vehicle cannot be transported
by f lat-bed, it should be towed by
wheel-lif t equipment with the f ront
wheels of f the ground. If , due to
damage, your vehicle must be towed
with the f ront wheels on the ground,
do the f ollowing:
Release the parking brake.
Shif t the transmission to Neutral.
Release the parking brake.
Start the engine.
ShifttoD,thentoN.
Turn of f the engine. With the f ront wheels on the ground,
it is best to tow the vehicle no farther
than 50 miles (80 km), and keep the
speedbelow35mph(55km/h).
If your vehicle is equipped with a
f ront spoiler, remove it bef ore
towing so it is not damaged.
5-speed Manual Transmission:
Automatic Transmission (CVT):
Emergency T owing
Flat -bed Equipment
Wheel-lif t Equipment
Sling-t ype Equipment
This is the best way to trans-
port your vehicle.
T his is
an acceptable way to tow your
vehicle. T his method of towing
is unacceptable.
T aking Care of t he Unexpect ed
183
Trying to lif t or tow your vehicle by the
bumpers will cause serious damage.
The bumpers are not designed to
support the vehicle’s weight. Improper towing preparation will
damage the transmission. Follow the
above procedure exactly. If you cannot
shif t the transmission or start the
engine (CVT), your vehicle must be
transported with the f ront wheels of f
the ground.

µµµ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
µ
Î
Î
Specif ications
T echnical Inf ormation
195
Air Conditioning
Lights
12 Volt Battery Alignment
Tires
Fuses
HFC-134a (R-134a)
17.6 19.4 oz (500 550 g) SP-10
12 V 60/55 W (HB2) 0.00 in (0.0 mm)
0.12 in (3.0 mm)
0°1°
2°
P165/65R14 78S
T115/70D14 88M
12 V 21 W
12 V 5 W
12 V 12 V
21/5 W
21 W
12 V 18 W
12 V
12 V 5W
5W
12 V
12 V
5W
3.4 W
12V 27Ah/5HR 30 Ah/5 HR
12 V
Refrigerant type
Charge quantity
Lubricant type
Headlights (HI/LO)
Front turn signal lights
Front parking lights
Side marker lights
Rear turn signal lights
Brake/Taillights
Back-up lights
Trunk light
License plate light
Interior light
Capacity
Toe-in
Camber
Caster
Size
Pressure
Interior
Under-hood
See page
188or the fuse label
attached to the inside of the fuse
box door under the dashboard.
See page 189or the fuse box
cover. 38 psi (260 kPa , 2.6 kgf/cm
)
35 psi (240 kPa , 2.4 kgf/cm)
60 psi (420 kPa , 4.2 kgf/cm)
Front
Rear
Front
Rear
Front
Front/Rear
Spare
Front
Rear
Spare
U.S. model M/T
CVT

If you take your vehicle f or a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.
If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle retested within the
next two or three days, you can
condition the vehicle f or retesting by
doing the f ollowing.Select a nearby highway where
you can maintain a speed of 50 to
60 mph (80 to 97 km/h) f or at
least 20 minutes in D (CVT) or 5th
gear (M/T). When traffic allows,
drive f or 90 seconds without
moving the accelerator pedal.
(Vehicle speed may vary slightly;
this is okay.) If you cannot do this
f or a continuous 90 seconds, drive
f or at least 30 seconds, then repeat
it two more times (f or a total of 90
seconds).
Then drive in city/suburban
traffic for at least 10 minutes.
When traf f ic conditions allow, let
the vehicle coast f or several
seconds without using the
accelerator pedal or the brake
pedal.
If the testing facility determines the
readiness codes are still not set, see
your dealer.
Keep the vehicle in Park
(automatic transmission) or
Neutral (manual transmission).
Increase the engine speed to 2,000
rpm,andholditthereuntilthe
temperature gauge rises to at least
1/4of thescale(about3minutes). Without touching the accelerator
pedal, start the engine, and let it
idle f or 20 seconds. Make sure the ambient
temperature is between 20° and
95°F. Make sure the vehicle has been
parked with the engine of f f or 8
hours or more. Make sure the gas tank is nearly,
but not completely f ull (around
3/4).
St at e Emissions T est ing
T esting of Readiness Codes
202

CONT INUED
BatteryCharging System ...........................
Indicator .44, 180
............................
Jump Starting .175
..............................
Maintenance .162
............................
Specif ications .195
................................
Bef ore Driving .93
..................................
Belts, Seat .10, 18
.............................
Beverage Holder .71
..................................
Booster Seats .35 Brakes
...........
Anti-lock System (ABS) . 122
................
Break-in, New Linings . 94
....................
Bulb Replacement .149
...........................................
Fluid .144
.........................................
Parking .69
.................
System Indicator . 45,182
........................
Wear Indicators .121
.............................
Braking System .121
...................
Break-in, New Vehicle . 94
..
Brightness Control, Instruments . 57
........................
Brights, Headlights .56
Bulb Replacement ..........................
Back-up Lights .149
..............................
Brake Lights .149
................
Front Parking Lights . 147
........
Front Side Marker Lights . 148
.................................
Headlights .146
............................
Specif ications .195
....................
Turn Signal Lights . 148
..............................
Bulbs, Halogen .146
....................................
Accessories .101
ACCESSORY (Ignition Key .......................................
Position) .61
...............
Accessory Power Socket . 71
....................
Additives, Engine Oil . 136
.............................
Airbag (SRS) .11, 21
...
Airbags, Additional Information . 21
...
Additional Safety Precautions . 24
.............................
Airbag Service .23
..
How the SRS Indicator Works . 23
How Your Front Airbags .........................................
Work .21
........................
SRS Components .21
................
Air Conditioning System . 74
.....................................
Usage .75, 78
.......................
Air Pressure, Tires .156
.........................
Normal Driving .157
.........................
Alcohol in Gasoline .94
......................................
Antif reeze .139
Anti-lock Brakes (ABS) ...............................
Indicator .45, 122
....................................
Operation .122
................
Anti-theft, Audio System . 90Anti-thef t Steering Column
..............................................
Lock .61
..................................
Audio System .80
........................
Auto Idle Stop .111, 118
...
Automatic Seat Belt Tensioners . 19
..............
Automatic Transmission . 113
..........................
Capacity,Fluid .194
...............
Checking Fluid Level . 142
.......................................
Shif ting .114
Shif t Lever Position ...............................
Indicators .113
................
Shif t Lever Positions . 114
....................
Shif t Lock Release . 117
Index
A
B
INDEX
I

Î
............................
Capacities Chart .194
.............
Carbon Monoxide Hazard . 38
.............................
Carrying Cargo .103
..............
CAUTION, Explanation of . ii
...........................................
CD Care .87
.............
CD Player Error Message . 88
.........
CD Changer Error Message . 89
.........................................
CD Player .85
....................................
Ceiling Light .72
........................
Certif ication Label .192
.................................
Chains, Tires .161
....................
Charge/Assist Gauge .53 ................
DANGER, Explanation of . ii
...................................
Dashboard .4, 42
................
Daytime Running Lights . 56
Daytime Running Lights .......................................
Indicator .46
.................................
Dead Battery .175
............
Def ects, Reporting Saf ety . 206
..........................
Def og and Def rost .77
................
Def ogger, Rear Window . 58
................
Def rosting the Windows . 77
....................................
Dimensions .194
...............
Dimming the Headlights . 56
Dipstick Automatic Transmission .....................................
(CVT) .142
....................................
Engine Oil .97
..........................
Directional Signals .56
........
Disc Brake Wear Indicators . 121
.....................
Disposal of Used Oil .138
..................
Display Change Button . 49
Doors ..............
Locking and Unlocking . 62
......................
Power Door Locks .62
..........
DOT Tire Quality Grading . 196
....................
Changing a Flat Tire .167
Changing Oil ........................................
How to .136
......................................
When to .129
...
Charging System Indicator . 44,180
............
Checklist, Bef ore Driving . 108
.....................................
Child Saf ety .25
..............................
Booster Seats .35
...................................
Child Seats .30
.....
Important Saf ety Reminders . 28
..........................................
Inf ants .26
............................
Large Children .34 ......................
Risks with Airbags .26
.............................
Small Children .29
.........................................
Tethers .33
.........
Where Should a Child Sit? . 25
Child Seats ................
Installing a Child Seat . 30
....................
Selecting Child Seat . 30
..........
Tether Anchorage Points . 33
.................................................
Clock .91
...................................
Clutch Fluid .145
........................
CO in the Exhaust .199
............
Cold Weather, Starting in . 109
......................
Compact Spare Tire .166
...............
Consumer Inf ormation . 204
.............
Controls, Instruments and . 41
Coolant ........................................
Adding .139
......................................
Checking .98
.........................
Proper Solution .139
...................
Temperature Gauge . 49
Crankcase Emissions Control ........................................
System .199
.....................................
Cup Holders .71
.....................
Current Fuel Mileage .50
.............
Customer Service Of f ice . 204
Index
D
C
II

CONT INUED
Downshif ting, Manual.............................
Transmission .110
...........
Driver and Passenger Safety . 7
...........................................
Driving .107
......................................
Economy .99
..................
Dust and Pollen Filter . 152
...
Malf unction Indicator Lamp . 180
..................
Overheated Engine . 177
.......................................
Towing .183
...........................
Emergency Brake .69
......................
Emergency Flashers .57
......................
Emergency Towing .183
.......................
Emissions Controls .199 .............
Emissions Testing, State . 202
Engine ....
Coolant Temperature Gauge . 49
......
Engine Speed Limiter . 111,116
.........................
If It Won’t Start .173
Malf unction Indicator ................................
Lamp .45, 180
........
Oil Pressure Indicator . 44,179
..............
Oil, What Kind to Use . 135
...............................
Overheating .177
............................
Specif ications .194
.......................................
Starting .109
........................
Ethanol in Gasoline .94
.
Evaporative Emissions Controls . 199
...............................
Exhaust Fumes .38
Expectant Mothers, Use of Seat ........................................
Belts by .16
.....................................
Fan, Interior .75
...........................................
Features .73
......................
Filling the Fuel Tank .95
Filter .........................
Dust and Pollen .152
...............................................
Oil .136 .............
Flashers, Hazard Warning . 57
...................
Flat Tire, Changing a . 167
Fluids Automatic Transmission .....................................
(CVT) .142
..........................................
Brake .144
.........................................
Clutch .145
..............
Manual Transmission . 143
..................
Windshield Washer . 141
FM Stereo Radio .....................................
Reception .83
..........................
Four-way Flashers .57
............................
Front Airbags .11, 21
...................................................
Fuel .94
........................
Fill Door and Cap .95
...........................................
Gauge .49
..................
Octane Requirement . 94
.................................
Oxygenated .94
........................
Reserve Indicator .46
..........................
Tank, Filling the .95
.....................
Fuses, Checking the .185
................................
Economy, Fuel .99
............
Emergencies on the Road . 165
.............
Battery, Jump Starting . 175
...........
Brake System Indicator . 182
................
Changing a Flat Tire . 167
.....
Charging System Indicator . 180
..................
Checking the Fuses . 185
.............
Hazard Warning Button . 57
............................
Jump Starting .175
.....
Low Oil Pressure Indicator . 179
Index
INDEX
E
F
III

.................
Gas Mileage, Improving . 99
...........................................
Gasoline .94
...............
Fuel Reserve Indicator . 46
...........................................
Gauge .49
..................
Octane Requirement . 94
..........................
Tank, Filling the .95
..................
Gas Station Procedures . 95
Gauges ...
Engine Coolant Temperature . 49
...............................................
Fuel .49
Gearshif t Lever Positions Automatic Transmission .....................................
(CVT) .113
..............
Manual Transmission . 110
........................................
Glove Box .71 ...
Identif ication Number, Vehicle . 192
Ignition ..............................................
Keys .59
...........................................
Switch .61
............
Timing Control System . 200
....................
IMA System Indicator . 44
.........
Important Safety Precautions . 8
.........................................
Indicators .44
.......
ABS (Anti-lock Brake) . 45,122 Brake (Parking and Brake
............................
System) .45, 182
................
Charging System . 44,180
DRL (Daytime Running ......................................
Lights) .46
...................................
High Beam .46
...............................................
IMA .44
........
Key (Immobilizer System) . 46
......................................
Low Fuel .46
................
Low Oil Pressure . 44,179
.........................................
SRS .23, 44
Turn Signal and Hazard ...................................
Warning .45
......................................
Inf ant Seats .26
...................
Inf lation, Proper Tire . 156
.........................
Normal Driving .157
...................................
Inside Mirror .68
.............................
Inspection, Tire .158
............................
Instrument Panel .43
........
Instrument Panel Brightness . 57
.................................
Interior Lights .72
........................................
Introduction . i
.............
Halogen Headlight Bulbs . 146
Hatch .................................
Opening the .63
.............
Open Monitor Indicator . 46
.................
Hazard Warning Button . 57Headlights
........................................
Aiming .146
.....
Daytime Running Lights . 46,56
..................
High Beam Indicator . 46
...........................
Reminder Tone .56
........
Replacing Halogen Bulbs . 146
...................................
Turning on .56
.............................................
Heating .76
.............
High Altitude, Starting at . 109
.................
High-Low Beam Switch . 56
.........................
Hood, Opening the .96
..................................................
Horn .54
...........................
Hydraulic Clutch .145
Index
H I
G
IV

Î
....................
Overheating, Engine .177
....
Owner’s Maintenance Checks . 128
...........................
Oxygenated Fuels .94
...................
Radiator Overheating . 177
...............
Radio/CD Sound System . 80
...........................
Readiness Codes .202
..
Rear Lights, Bulb Replacement . 149
............................
Rear View Mirror .68
.................
Rear Window Def ogger . 58
....................
Rear Window Washer .55
.......................
Rear Window Wiper .55
...............
Reclining the Seat Backs . 66
.............................
Reminder Lights .44
.......................
Remote Transmitter .64
Replacement Inf ormation ..............
Dust and Pollen Filter . 152
................
Engine Oil and Filter . 136
.................................
Floor Mats .151
..........................................
Fuses .185
................................
Light Bulbs .146
....................................
Schedule .129
...................................
Seat Belts .151 ...........................................
Tires .159
.............................
Wiper Blades .153
Replacing Seat Belts Af ter a ............................................
Crash .19
Reserve Tank, Engine .................................
Coolant .98, 139
...............................
Restraint, Child .25
..................
Reverse Gear Position . 114
................................
Roof Antenna .152
................................
Rotation, Tire .159
................................
Saf ety Belts .10, 18
.........
Safety Defects, Reporting . 206
.................................
Saf ety Features .9
.........................................
Airbags .11
.....................................
Seat Belts .10
.............
Saf ety Labels, Location of . 39
...............................
Saf ety Messages .ii
..............
Panel Brightness Control . 57
........................
Park Gear Position .114
...........................................
Parking .120
.................................
Parking Brake .69
Parking Brake and Brake .................
System Indicator . 45,182
.................................
Parking Lights .56
..
Parking Over Things that Burn . 120
............................
Playing the Radio .80
....................................
Playing a CD .85
.............................
PGM-FI System .200
..................
Power Socket Location . 70
..............................
Power Windows .67
.........
Pregnancy, Using Seat Belts . 16
.........
Protecting Adults and Teens . 12
...
Additional Safety Precautions . 17
.....
Advice f or Pregnant Women . 16
........................
Protecting Children .25
.....................
General Guidelines .25 Using Child Seats with
.....................................
Tethers .33
...........
Protecting Larger Children . 34
.............
Protecting Small Children . 29
Index
P
R
S
VI