2005 FORD FREESTYLE light

To reduce the risk of personal injury, make sure the engine is
cool before unscrewing the coolant pressure relief cap. The
cooling system is under pressure; steam and hot liquid can come out
forcefully when the cap is loosened slightly.
1. Before you begin, turn the engine off and let it cool.
2. When the engine is cool, wrap a thick cloth around the coolant
pressure relief cap on the coolant reservoir (an opaque plastic bottle).
Slowly turn cap counterclockwise (left) until pressure begins to release.
3. Step back while the pressure releases.
4. When you are sure that all the pressure has been released, use the
cloth to turn it counterclockwise and remove the cap.
If coolant reservoir is empty, continue with steps 5–9, if coolant
reservoir level is only slightly low (coolant still in reservoir),
continue to steps 5 and 6 only.
5. Fill the coolant reservoir slowly with the proper coolant mixture (see
above), to within the“COLD FILL RANGE”or the“FULL COLD”level on
the reservoir.
6. Replace the cap. Turn until tightly installed. (Cap must be tightly
installed to prevent coolant loss.)
REVIEW COPY
2005 Freestyle(219), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
252

Repairs to correct the effects of using a fuel for which your vehicle was
not designed may not be covered by your warranty.
Octane recommendations
Your vehicle is designed to use
“Regular”unleaded gasoline with
pump (R+M)/2 octane rating of 87.
We do not recommend the use of
gasolines labeled as“Regular”that
are sold with octane ratings of 86 or lower in high altitude areas.
Do not be concerned if your engine sometimes knocks lightly. However, if
it knocks heavily under most driving conditions while you are using fuel
with the recommended octane rating, see your dealer or a qualified
service technician to prevent any engine damage.
Fuel quality
If you are experiencing starting, rough idle or hesitation driveability
problems, try a different brand of unleaded gasoline.“Premium”
unleaded gasoline is not recommended for vehicles designed to use
“Regular”unleaded gasoline because it may cause these problems to
become more pronounced. If the problems persist, see your dealer or a
qualified service technician.
It should not be necessary to add any aftermarket products to your fuel
tank if you continue to use high quality fuel of the recommended octane
rating. Aftermarket products could cause damage to the fuel system.
Repairs to correct the effects of using an aftermarket product in your
fuel may not be covered by your warranty.
Many of the world’s automakers approved the World-wide Fuel Charter
that recommends gasoline specifications to provide improved
performance and emission control system protection for your vehicle.
Gasolines that meet the World-wide Fuel Charter should be used when
available. Ask your fuel supplier about gasolines that meet the
World-wide Fuel Charter.
Cleaner air
Ford endorses the use of reformulated“cleaner-burning”gasolines to
improve air quality.
Running out of fuel
Avoid running out of fuel because this situation may have an adverse
affect on powertrain components.
87(R+M)/2 METHOD
REVIEW COPY
2005 Freestyle(219), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
259

•Adding certain accessories to your vehicle (for example bug
deflectors, rollbars/light bars, running boards, ski/luggage racks) may
reduce fuel economy.
•Using fuel blended with alcohol may lower fuel economy.
•Fuel economy may decrease with lower temperatures during the first
8–10 miles (12–16 km) of driving.
•Driving on flat terrain offers improved fuel economy as compared to
driving on hilly terrain.
•Transmissions give their best fuel economy when operated in the top
cruise gear and with steady pressure on the gas pedal.
•Close windows for high speed driving.
EPA window sticker
Every new vehicle should have the EPA window sticker. Contact your
dealer if the window sticker is not supplied with your vehicle. The EPA
window sticker should be your guide for the fuel economy comparisons
with other vehicles.
It is important to note the box in the lower left corner of the window
sticker. These numbers represent the Range of MPG (L/100 km)
expected on the vehicle under optimum conditions. Your fuel economy
may vary depending upon the method of operation and conditions.
EMISSION CONTROL SYSTEM
Your vehicle is equipped with various emission control components and a
catalytic converter which will enable your vehicle to comply with
applicable exhaust emission standards. To make sure that the catalytic
converter and other emission control components continue to work
properly:
•Use only the specified fuel listed.
•Avoid running out of fuel.
•Do not turn off the ignition while your vehicle is moving, especially at
high speeds.
•Have the items listed in yourScheduled Maintenance Guide
performed according to the specified schedule.
The scheduled maintenance items listed in theScheduled Maintenance
Guideare essential to the life and performance of your vehicle and to its
emissions system.
If other than Ford, Motorcraft or Ford-authorized parts are used for
maintenance replacements or for service of components affecting
REVIEW COPY
2005 Freestyle(219), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
263

emission control, such non-Ford parts should be equivalent to genuine
Ford Motor Company parts in performance and durability.
Do not park, idle, or drive your vehicle in dry grass or other dry
ground cover. The emission system heats up the engine
compartment and exhaust system, which can start a fire.
Illumination of the“Check Engine”light, charging system warning light
or the temperature warning light, fluid leaks, strange odors, smoke or
loss of engine power, could indicate that the emission control system is
not working properly.
Exhaust leaks may result in entry of harmful and potentially
lethal fumes into the passenger compartment.
Do not make any unauthorized changes to your vehicle or engine. By
law, vehicle owners and anyone who manufactures, repairs, services,
sells, leases, trades vehicles, or supervises a fleet of vehicles are not
permitted to intentionally remove an emission control device or prevent
it from working. Information about your vehicle’s emission system is on
the Vehicle Emission Control Information Decal located on or near the
engine. This decal identifies engine displacement and gives some tune up
specifications.
Please consult yourWarranty Guidefor complete emission warranty
information.
On board diagnostics (OBD-II)
Your vehicle is equipped with a computer that monitors the engine’s
emission control system. This system is commonly known as the On
Board Diagnostics System (OBD-II). This OBD-II system protects the
environment by ensuring that your vehicle continues to meet
government emission standards. The OBD-II system also assists the
service technician in properly servicing your vehicle. When theCheck
engine/Service engine soonlight illuminates, the OBD-II system has
detected a malfunction. Temporary malfunctions may cause yourCheck
engine/Service engine soonlight to illuminate. Examples are:
1. The vehicle has run out of fuel. (The engine may misfire or run
poorly.)
2. Poor fuel quality or water in the fuel.
3. The fuel cap may not have been securely tightened.
These temporary malfunctions can be corrected by filling the fuel tank
with good quality fuel and/or properly tightening the fuel cap. After three
REVIEW COPY
2005 Freestyle(219), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
264

driving cycles without these or any other temporary malfunctions
present, theCheck engine/Service engine soonlight should turn off. (A
driving cycle consists of a cold engine startup followed by mixed
city/highway driving.) No additional vehicle service is required.
If theCheck engine/Service engine soonlight remains on, have your
vehicle serviced at the first available opportunity.
Readiness for Inspection/Maintenance (I/M) testing
In some localities, it may be a legal requirement to pass an I/M test of
the on-board diagnostics system. If your
indicator is on, refer to the
description in theWarning lights and chimessection of the
Instrument Clusterchapter. Your vehicle may not pass the I/M test with
the
indicator on.
If the vehicle’s powertrain system or its battery has just been serviced,
the on-board diagnostics system is reset to a“not ready for I/M test”
condition. To ready the on-board diagnostics system for I/M testing, a
minimum of 30 minutes of city and highway driving is necessary as
described below:
•First, at least 10 minutes of driving on an expressway or highway.
•Next, at least 20 minutes driving in stop-and-go, city-type traffic with
at least four idle periods.
Allow the vehicle to sit for at least eight hours without starting the
engine. Then, start the engine and complete the above driving cycle. The
engine must warm up to its normal operating temperature. Once started,
do not turn off the engine until the above driving cycle is complete.
POWER STEERING FLUID
Refer to the scheduled maintenance guide for the service interval
schedules. If adding fluid is necessary, use only MERCONAT F.
REVIEW COPY
2005 Freestyle(219), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
265

A
Accessory delay ..........................66
Air bag supplemental restraint
system ................131–132, 139, 141
and child safety seats ............133
description ..............132, 139, 141
disposal ....................................144
driver air bag ..........134, 139, 142
indicator light .................133, 144
operation .................134, 139, 142
passenger air bag ...134, 139, 142
side air bag ..............................139
Air cleaner filter .......................267
Air conditioning ........41, 43, 45, 47
All Wheel Drive (AWD),
driving off road .........................202
Antifreeze (see
Engine coolant) ........................249
Anti-lock brake system
(see Brakes) ..............................194
Anti-theft system ......................104
arming the system ..................104
disarming a triggered
system .....................................105
Audio system (see Radio) ...17, 20
Automatic transaxle
fluid, adding ............................267
fluid, checking ........................267
fluid, refill capacities ..............268
fluid, specification ..................272
Automatic transmission
driving an automatic
overdrive .................................199
Axle
lubricant specifications ..........270
B
Battery .......................................247acid, treating emergencies .....247
jumping a disabled battery ....218
maintenance-free ....................247
replacement, specifications ...267
servicing ..................................247
BeltMinder .................................126
Brakes ........................................194
anti-lock ...................................194
anti-lock brake system
(ABS) warning light ...............194
fluid, checking and adding ....266
fluid, refill capacities ..............268
fluid, specifications .........270, 272
lubricant specifications ..270, 272
parking ....................................195
shift interlock ..........................197
Bulbs ............................................56
C
Capacities for refilling fluids ....268
Cargo cover .................................89
Cargo net .....................................89
Cassette tape player ...................17
Cell phone use ............................88
Certification Label ....................274
Changing a tire .........................163
Child safety restraints ..............145
child safety belts ....................145
Child safety seats ......................148
in front seat ............................149
in rear seat ..............................149
tether anchorage hardware ...152
Cleaning your vehicle
engine compartment ..............235
instrument panel ....................237
interior .....................................237
interior trim ............................237
REVIEW COPY
2005 Freestyle(219), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Index
Index
279

Exhaust fumes ..........................193
F
Fluid capacities .........................268
Foglamps .....................................52
Four-Wheel Drive vehicles
driving off road .......................202
Fuel ............................................256
calculating fuel
economy ............................77, 260
cap ...........................................257
capacity ...................................268
choosing the right fuel ...........258
comparisons with EPA fuel
economy estimates .................263
detergent in fuel .....................259
filling your vehicle
with fuel ..................256–257, 260
filter, specifications ........260, 267
fuel pump shut-off switch .....210
improving fuel economy ........260
octane rating ...................259, 272
quality ......................................259
running out of fuel .................259
safety information relating to
automotive fuels .....................256
Fuel pump shut-off switch .......210
Fuses ..........................................211
G
Garage Door Opener
(see Homelink wireless control
system) ........................................72
Gas cap (see Fuel cap) ............257
Gas mileage
(see Fuel economy) .................260
Gauges .........................................14
H
Hazard flashers .........................210Head restraints .................106, 110
Headlamps ...................................51
aiming ........................................54
autolamp system .......................51
bulb specifications ....................56
daytime running lights .............52
flash to pass ..............................53
high beam .................................53
replacing bulbs .........................57
turning on and off ....................51
Heating
heating and air conditioning
system ...............39, 41, 43, 45, 47
Homelink wireless control
system ..........................................72
Hood ..........................................241
I
Ignition ...............................190, 272
Infant seats
(see Safety seats) .....................148
Inspection/maintenance
(I/M) testing ..............................265
Instrument panel
cleaning ...................................237
cluster ........................................10
lighting up panel and interior .53
J
Jack ............................................163
positioning ...............................163
storage .....................................163
Jump-starting your vehicle ......218
K
Keyless entry system .................98
autolock .....................................99
REVIEW COPY
2005 Freestyle(219), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Index
281

Keys
positions of the ignition .........190
L
Lamps
autolamp system .......................51
bulb replacement
specifications chart ..................56
daytime running light ...............52
fog lamps ...................................52
headlamps ...........................51, 57
headlamps, flash to pass ..........53
instrument panel, dimming .....53
interior lamps .....................55, 57
replacing bulbs ...................56–60
Lane change indicator
(see Turn signal) ........................55
Liftgate ........................................88
Lights, warning and indicator ....10
anti-lock brakes (ABS) ..........194
Load limits .................................180
Locks
autolock .....................................99
childproof ..................................92
doors ..........................................91
Lubricant specifications ...270, 272
Lug nuts ....................................170
Luggage rack ...............................90
Lumbar support, seats .....107–108
M
Message center ...........................76
english/metric button ...............81
system check button ................81
warning messages .....................82
Mirrors ...................................63, 67automatic dimming rearview
mirror ........................................67
fold away ...................................67
side view mirrors (power) .......67
Moon roof ....................................72
Motorcraft parts ................260, 267
O
Octane rating ............................259
Oil (see Engine oil) ..................243
P
Parking brake ............................195
Parts (see Motorcraft parts) ....267
Passenger Occupant
Classification Sensor .................119
Power adjustable foot pedals .....68
Power distribution box
(see Fuses) ...............................214
Power door locks ........................91
Power mirrors .............................67
Power point .................................64
Power steering ..........................197
fluid, checking and adding ....265
fluid, refill capacity ................268
fluid, specifications .........270, 272
Power Windows ...........................65
R
Radio ......................................17, 20
Relays ........................................211
Remote entry system .................93
illuminated entry ......................97
Reverse sensing system ...........200
REVIEW COPY
2005 Freestyle(219), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Index
282