2005 FORD F150 oil dipstick

IDENTIFYING COMPONENTS IN THE ENGINE COMPARTMENT
4.2L V6 engine
1. Battery
2. Clutch fluid reservoir (manual transmission)
3. Power steering fluid reservoir
4. Brake fluid reservoir
5. Engine coolant reservoir
6. Air filter assembly
7. Engine oil filler cap
8. Engine oil dipstick
9. Transmission fluid dipstick (automatic transmission)
10. Windshield washer fluid reservoir
54321
791068
REVIEW COPY
2005 F150(f12), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
256

4.6L V8
1. Battery
2. Transmission fluid dipstick (automatic transmission)
3. Engine oil filler cap
4. Power steering fluid reservoir
5. Engine oil dipstick
6. Brake fluid reservoir
7. Engine coolant reservoir
8. Air filter assembly
9. Windshield washer fluid reservoir
REVIEW COPY
2005 F150(f12), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
257

5.4L V8
1. Battery
2. Transmission fluid dipstick (automatic transmission)
3. Air filter assembly
4. Power steering fluid reservoir
5. Engine oil dipstick
6. Brake fluid reservoir
7. Engine coolant reservoir
8. Engine oil filler cap
9. Windshield washer fluid reservoir
REVIEW COPY
2005 F150(f12), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
258

•4.2L V6 engine
•4.6L/5.4L V8 engine
5. Locate and carefully remove the engine oil level indicator (dipstick).
6. Wipe the indicator clean. Insert the indicator fully, then remove it
again.
MAX MIN
REVIEW COPY
2005 F150(f12), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
260

•If the oil level isbetween the MIN and MAX marks,the oil level is
acceptable.DO NOT ADD OIL.
•4.2L V6 engine
•4.6L/5.4L V8 engine
•If the oil level is below the MIN
mark, add enough oil to raise the
level within the MIN-MAX range.
•Oil levels above the MAX mark may cause engine damage. Some oil
must be removed from the engine by a service technician.
7. Put the indicator back in and ensure it is fully seated.
Adding engine oil
1. Check the engine oil. For instructions, refer toChecking the engine
oilin this chapter.
2. If the engine oil level is not within the normal range, add only certified
engine oil of the recommended viscosity. Remove the engine oil filler cap
and use a funnel to pour the engine oil into the opening.
3. Recheck the engine oil level. Make sure the oil level is not above the
MAX mark on the engine oil level indicator (dipstick).
4. Install the indicator and ensure it is fully seated.
REVIEW COPY
2005 F150(f12), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
261

MERCONand MERCONV type fluids are not interchangeable.
DO NOT mix MERCONand MERCONV. Use of a transmission
fluid that indicates dual usage (MERCONand MERCONV) in
an automatic transmission application requiring MERCONmay
cause transmission damage. Use of any fluid other than the
recommended fluid may cause transmission damage.
4Approximate dry fill capacity including transmission fluid cooling
system, actual refill capacities will vary based on vehicle application and
transmission fluid cooling system (i.e. coolers size, cooling lines. auxiliary
cooler capacities). The amount of transmission fluid and fluid level
should be set by the indication on the dipstick’s normal operating range.
5Your vehicle’s rear axle is filled with a synthetic rear axle lubricant and
is considered lubricated for life. These lubricants do not need to be
checked or changed unless a leak is suspected, service is required or the
axle assembly has been submerged in water. The axle lubricant should
be changed any time the rear axle has been submerged in water.
6Service refill capacity is determined by filling the axle to 1/4-9/16 inch
(6-14 mm) below the bottom of the filler hole with the vehicle on a level
surface.
Add 118 ml (4 oz.) of Additive Friction Modifier or equivalent meeting
Ford specification EST-M2C118–A, for complete fill of 8.8 inch and 9.75
inch Traction-Lok axles.
7Service refill capacity is determined by filling the axle to the bottom of
the filler hole with the vehicle on a level surface.
For 10.25 inch Traction-Lok axles, use 3.1L (6.5 pints) of Motorcraft SAE
75W-140 Synthetic Rear Axle Lubricant and 236 ml (8 oz.) of Additive
Friction Modifier XL-3 or equivalent meeting Ford Specification
EST-M2C118-A.
8Use of synthetic or synthetic blend motor oil is not mandatory. Engine
oil need only meet the requirements of Ford specification
WSS-M2C930-A and the API Certification mark.
REVIEW COPY
2005 F150(f12), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Maintenance and Specifications
294

Climate control
(see Air conditioning or
Heating) ...........................36, 39, 42
Clock adjust
6-CD in dash .......................27, 31
AM/FM Stereo .....................19–20
AM/FM/CD .................................21
AM/FM/Tape/CD .......................24
Clutch
fluid ..........................................282
operation while driving ..........205
recommended shift speeds ....206
Compass, electronic ..............84, 86
calibration .................................86
set zone adjustment ...........77, 86
Console ........................................62
overhead ..............................58–59
Controls
power seat ...............................106
steering column ........................70
Coolant
checking and adding ..............265
refill capacities ................269, 291
specifications ..................295, 297
Cruise control
(see Speed control) ....................68
Customer Assistance ................223
Ford accessories for your
vehicle .....................................252
Ford Extended Service
Plan ..........................................244
Getting assistance outside the
U.S. and Canada .....................245
Getting roadside assistance ...223
Getting the service you
need .........................................238
Ordering additional owner’s
literature .................................245
The Dispute Settlement
Board .......................................241Utilizing the
Mediation/Arbitration
Program ...................................243
D
Daytime running lamps
(see Lamps) ................................47
Dipstick
automatic transmission
fluid ..........................................283
engine oil .................................259
Doors
lubricant specifications ..........295
Driveline universal joint and
slip yoke ....................................287
Driving under special
conditions ..................205, 214, 217
sand .........................................216
snow and ice ...........................218
through water .................217, 219
DVD system .................................33
E
Electronic message center .........76
Emergencies, roadside
jump-starting ..........................232
Emergency Flashers .................224
Emission control system ..........279
Engine ................................297–298
cleaning ...................................248
coolant .....................................265
fail-safe coolant ......................269
idle speed control ...................263
lubrication
specifications ..................295, 297
refill capacities ........................291
service points ..................256–258
REVIEW COPY
2005 F150(f12), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Index
308

starting after a collision .........224
Engine block heater .................195
Engine oil ..................................259
checking and adding ..............259
dipstick ....................................259
filter, specifications ........262, 290
recommendations ...................262
refill capacities ........................291
specifications ..................295, 297
Exhaust fumes ..........................195
F
Fail safe cooling ........................269
Fluid capacities .........................291
Foglamps .....................................47
Four-Wheel Drive vehicles .......210
driving off road .......................213
electronic shift ........................212
indicator light .........................210
lever operated shift ................210
preparing to drive your
vehicle .....................................198
Fuel ............................................271
calculating fuel
economy ............................79, 275
cap ...........................................273
capacity ...................................291
choosing the right fuel ...........274
comparisons with EPA fuel
economy estimates .................278
detergent in fuel .....................275
filling your vehicle
with fuel ..................271, 273, 276
filter, specifications ........275, 290
fuel pump shut-off switch .....224
improving fuel economy ........275
octane rating ...........274, 297–298
quality ......................................274
running out of fuel .................275safety information relating to
automotive fuels .....................271
Fuel pump shut-off switch .......224
Fuses ..................................225–226
G
Garage Door Opener
(see Homelink wireless control
system) ........................................72
Gas cap (see Fuel cap) ............273
Gas mileage
(see Fuel economy) .................275
Gauges .........................................15
H
Hazard flashers .........................224
Head restraints .................104, 108
Headlamps ...................................46
aiming ........................................48
autolamp system .......................46
bulb specifications ....................52
daytime running lights .............47
flash to pass ..............................48
high beam .................................47
replacing bulbs .........................52
turning on and off ....................46
Heating
heater only system ...................36
heating and air conditioning
system ...........................37, 39, 42
Homelink wireless control
system ..........................................72
Hood ..........................................255
I
Ignition .......................190, 297–298
REVIEW COPY
2005 F150(f12), Owners Guide (post-2002-fmt)(own2002),
Market:USA_English(fus)
Index
309