2005 DODGE RAM 2500 DIESEL differential

▫Operating Precautions..................235
▫Cooling System Tips — Automatic
Transmission........................236

Transmission Shifting....................237
▫Automatic Transmission With Overdrive— If
Equipped...........................237
▫Manual Transmission — 6-Speed — If
Equipped...........................241

Four-Wheel- Drive Operation — If Equipped . . . 243
▫Manually Shifted Transfer Case Operating
Information/Precautions................243
▫Shifting Procedure - Manually Shifted Transfer
Case..............................246
▫Transfer Case Reminder Light............247
▫Electronically Shifted Transfer Case Operating
Information/Precautions................247▫Shifting Procedure - Electronically Shifted
Transfer Case........................251

Limited-Slip Differential — If Equipped.......254

Parking Brake.........................255

Brake System..........................256
▫Brake Noise.........................257
▫Four-Wheel Anti-Lock Brake System........257

Power Steering........................259

Tire Safety Information...................260
▫Tire Markings........................260
▫Tire Identification Number (TIN)..........263
▫Tire Loading And Tire Pressure...........264

Tires—General Information................268
▫Tire Pressure.........................268
220 STARTING AND OPERATING

3. Rotate the transfer case control switch to the desired
position.
4. After the desired position indicator light is ON (not
flashing), shift transmission back into gear (release clutch
on manual transmissions).
NOTE:If steps 1 or 2 of either the Preferred or Alternate
Procedure are not satisfied prior to attempting the shift or
if they no longer are being met while the shift attempt is
in process then the desired position indicator light will
flash continuously while the original position indicator
light is ON, until all requirements have been met.
NOTE:The ignition key must be ON for a shift to take
place and for the position indicator lights to be operable.
If the key is not ON then the shift will not take place and
no position indicator lights will be on or flashing.
NOTE:If your are leaving your vehicle stored for longer
than 21 days, refer to the section on “Vehicle Storage.”LIMITED-SLIP DIFFERENTIAL — IF EQUIPPED
The limited-slip differential provides additional traction
on snow, ice, mud, sand and gravel, particularly when
there is a difference between the traction characteristics
of the surface under the right and left rear wheels. During
normal driving and cornering, the limited-slip unit per-
forms similarly to a conventional differential. On slip-
pery surfaces, however, the differential delivers more of
the driving effort to the rear wheel having the better
traction.
The limited-slip differential is especially helpful during
slippery driving conditions. With both rear wheels on a
slippery surface, a slight application of the accelerator
will supply maximum traction. When starting with only
one rear wheel on an excessively slippery surface, slight
momentary application of the parking brake may be
necessary to gain maximum traction.
254 STARTING AND OPERATING

Attach the wheel wrench to the extension tube. Rotate the
winch mechanism until the wheel is drawn into place
against the underside of the vehicle. Continue to rotate
until you feel the winch mechanism slip or click 3 or 4
times. It cannot be overtightened. Push against the tire
several times to be sure it is firmly in place.
HOISTING
A conventional floor jack may be used at the jacking
locations, refer to the graphics that show jacking loca-
tions. However, a floor jack or frame hoist must never be
used on any other parts or the underbody.
CAUTION!
Never use a floor jack directly under the differential
housing of a loaded truck or damage to your vehicle
may result.
JUMP-STARTING
WARNING!
To prevent personal injury or damage to clothing, do
not allow battery fluid to contact eyes, skin or
fabrics. Do not lean over a battery when connecting
jumper cables or allow cable clamps to touch each
other. Keep open flames or sparks away from battery
vent holes. Always wear eye protection when work-
ing with batteries.
Do not use a booster battery or any other booster
source that has a greater than 12 volt system, i.e. do
not use a 24 volt power source.
NOTE:Replacement batteries should both be of equal
size to prevent damage to the vehicles charging system.
WHAT TO DO IN EMERGENCIES 327
6

Clutch Hydraulic System
The clutch hydraulic system is a sealed maintenance-free
system. In the event of leakage or other malfunction, the
system must be replaced.
Rear Axle And 4x4 Front Driving Axle Fluid Level
For Model 9.25 Front Axles and 10.5”/11.5” Rear Axles
refer to Recommended Fluids, Lubricants and Genuine
Parts for the correct lubricant type. For normal service,
periodic fluid level checks are not required. When the
vehicle is serviced for other reasons, the exterior surfaces
of the axle assembly should be inspected.
When checking the fluid level, the vehicle should be in a
level position. The fluid level should be 1/4” ± 1/4” (6.4
mm ± 6.4 mm) below the fill hole on the 9.25” Front Axle.
The fluid level should be 3/4” ± 1/4” (19 mm ± 6.4 mm)
below the fill hole on all 10.5” and 1/4” ± 1/4” (6.4 mm
± 6.4 mm) on 11.5” Rear Axles.
Drain And Refill
Vehicles operated in normal service do not have regularly
scheduled oil changes. If fluid has become contaminated
with water or subjected to severe service, follow the
recommended change intervals in Maintenance Schedule
“B” in Section 8 of this manual.
Lubricant Selection
Refer to Recommended Fluids, Lubricants and Genuine
Parts for the correct lubricant type.
NOTE:The presence of water in the gear lubricant will
result in corrosion and possible failure of differential
components. Operation of the vehicle in water, as may be
encountered in some off-highway types of service, will
require draining and refilling the axle to avoid damage.
Limited-Slip Differentialsin vehicles equipped with
10.5”/11.5” AxlesDO NOT REQUIREany limited slip
oil additive (friction modifiers).
MAINTAINING YOUR VEHICLE 369
7

Child Seat............................56,62
Cigar Lighter........................... 144
Climate Control......................... 204
Clock................................ 170
Clutch Linkage Maintenance................ 368
Compact Disc Maintenance................. 203
Compact Disc Player..................177,183
Compact Spare Tire...................... 272
Compass...........................131,132
Compass Calibration..................... 132
Compass Variance....................... 133
Computer, Trip/Travel.................... 128
Console, Overhead....................... 127
Contract, Service........................ 426
Cooling System......................... 361
Coolant Capacity...................... 397
Coolant Level......................... 361
Disposal of Used Coolant................ 364
Drain, Flush, and Refill.................. 362Inspection........................... 361
Radiator Cap......................... 364
Selection of Coolant..................363,398
Temperature Gauge..................... 165
Cruise Control (Speed Control).............. 124
Cup Holder............................ 145
Customer Assistance..................... 424
Daytime Running Lights................... 117
Dealer Service.......................... 340
Defroster, Rear Window..............81,210,214
Defroster, Windshield..................206,209
Delay (Intermittent) Wipers................. 120
Differential, Limited-Slip.................. 254
Dipsticks.............................. 343
Power Steering........................ 356
Disc Brakes............................ 366
Disposal.............................. 348
Engine Oil........................... 348
434 INDEX

Low Washer Fluid..................... 168
Passing............................. 119
Seat Belt Reminder..................... 163
Service...........................384,385
Side Marker.......................... 396
Transfer Case......................... 247
Transmission Warning................169,298
Turn Signal.................. 118,163,385,389
Warning (Instrument Cluster Description)..... 162
Limited-Slip Differential................254,369
Loading Vehicle......................... 286
Tires ............................... 264
Locks................................. 16
Child Protection........................ 21
Door................................ 16
Ignition.............................. 14
Keys................................ 11
Power Door........................... 17
Steering Wheel......................... 14Lower Anchors and Tether for CHildren (LATCH) . 60
Lubricants............................. 373
Lubrication, Body....................... 358
Lug Nuts............................. 322
Lumbar Support........................ 109
Maintenance........................... 340
Maintenance Procedures................... 343
Maintenance Schedule.................... 402
ScheduleA......................... 416
Manual, Service......................... 429
Manual Transmission..................241,370
Fluid Level Check...................... 370
Lubricant Selection..................... 399
Mirrors................................ 78
Automatic Dimming..................... 79
Electric Powered....................... 80
Outside.............................. 79
Rearview............................. 78
INDEX 439
10