2005 DODGE POWER WAGON transmission oil

a minimum of two (2) minutes for the oil to fully drain
into the transmission before rechecking the fluid level.
NOTE:If it is necessary to check the transmissionbelow
the operating temperature, the fluid level should be
between the two“COLD”(lower) holes on the dipstick
with the fluid at approximately 70°F (21°C) (room tem-
perature). If the fluid level is correctly established at
room temperature, it should be between the“HOT”
(upper) reference holes when the transmission reaches
180°F (82°C). Remember it is best to check the level at the
normal operating temperature.CAUTION!
Be aware that if the fluid temperature is below 50°F
(10°C) it may not register on the dipstick. Do not add
fluid until the temperature is elevated enough to
produce an accurate reading.
7. Check for leaks. Release parking brake.
To prevent dirt and water from entering the transmission
after checking or replenishing fluid, make certain that the
dipstick cap is properly reseated. It is normal for the
dipstick cap to spring back slightly from its fully seated
position, as long as its seal remains engaged in the
dipstick tube.
MAINTAINING YOUR VEHICLE 381
7

At Each Stop for Fuel
•Check the engine oil level about 5 minutes after a fully
warmed engine is shut off. Checking the oil level while
the vehicle is on level ground will improve the accu-
racy of the oil level reading. Add oil only when the
level is at or below the ADD or MIN mark.
•Check the windshield washer solvent and add if
required.
Once a Month
•Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant bottle, brake master
cylinder, and transmission and add as needed.
•Check all lights and all other electrical items for correct
operation.
At Each Oil Change
•Change the engine oil filter.
•Lubricate the driveshaft grease fitting and tie rod end
links.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints (if equipped) and front suspen-
sion components.
•Check the automatic transmission fluid level.
•Check the manual transmission fluid level.
•Check the coolant level, hoses, and clamps.
412 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 48,000 51,000 54,000 57,000 60,000
(Kilometers) (77 000) (82 000) (86 000) (91 000) (96 000)
Change engine oil and engine oil filter, or at 3
months, whichever comes first.X X XXX
Lubricate Drive Shaft Fitting. X X X X X
Rotate tires. X X X
Lubricate tie rod end links. X X X X X
Drain and refill transfer case fluid.X
Change rear axle fluid.X
Change front axle fluid.X
Change 6-spd manual transmission (G-56) fluid. X
Inspect brake linings. X X
Inspect engine air cleaner filter, replace if neces-
sary.X
Replace spark plugs.X
Replace ignition cables.X
Inspect PCV valve, replace as necessary.**X
SCHEDULE“B”417
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 105,000 108,000 111,000 114,000 117,000 120,000
(Kilometers) (168 000) (173 000) (178 000) (182 000) (187 000) (192 000)
Change engine oil and engine oil filter, or at 3
months, whichever comes first.X X XXXX
Lubricate Drive Shaft Fitting. X XXXXX
Rotate tires. X X X
Lubricate tie rod end links. X XXXXX
Drain and refill transfer case fluid.X
Change rear axle fluid. X X
Change front axle fluid. X X
Change 6-spd manual transmission (G-56)
fluid.X
Inspect brake linings. X X
Inspect engine air cleaner filter, replace if
necessary.XX
Replace spark plugs.X
Replace ignition cables.X
422 SCHEDULE“B”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Ethylene Glycol Antifreeze................. 374
Exhaust Gas Caution..............72,150,313,371
Exhaust System....................72,370,371
Exterior Lighting........................ 111
Filters
Air Cleaner........................361,385
Engine Fuel.......................... 362
Engine Oil........................360,407
Engine Oil Disposal.................... 360
Flashers
Turn Signal.......................... 113
Flat Tire Stowage.....................337,343
Flooded Engine Starting................... 268
Fluid, Brake........................... 408
Fluid Capacities......................... 406
Fluid Level Checks
Automatic Transmission................. 380
Power Steering........................ 367Fog Lights.......................... 113,405
Fold Flat Load Floor..................... 144
Four Wheel Drive....................... 277
Four-Way Hazard Flasher.................. 334
Freeing A Stuck Vehicle................... 347
Front Axle............................. 378
Front Wheel Bearings..................... 383
Fuel................................. 307
Adding............................. 309
Filter............................... 362
Gauge.............................. 164
Octane Rating......................307,407
Requirements......................307,406
Tank Capacity........................ 406
Fueling............................... 309
Fuses................................ 393
Garage Door Opener..................... 130
GasCap .............................. 310
444 INDEX

ScheduleB.......................... 413
Malfunction Indicator Light................ 354
Manual, Service......................... 436
Manual Transmission..................275,379
Fluid Level Check...................... 379
Lubricant Selection..................379,408
Mirrors................................ 84
Automatic Dimming..................... 85
Electric Powered....................... 87
Outside.............................. 86
Rearview............................. 84
Trailer Towing......................88,326
Modifications/Alterations, Vehicle............. 7
Mopar Parts.........................356,435
Multi-Function Control Lever............... 113
Noise Control
Maintenance.......................... 384
Tampering Prohibited................384,385Noise Emission Warranty.................. 386
Occupant Restraints....................... 35
Octane Rating, Gasoline................... 307
Odometer..........................163,164
Trip .............................163,164
Off-Pavement Driving.................... 224
Off-Road Driving........................ 224
Oil, Engine.........................356,407
Capacity............................ 406
Change Interval....................... 357
Dipstick............................. 356
Disposal............................ 360
Filter............................360,407
Filter Disposal........................ 360
Identification Logo..................... 359
Materials Added to..................... 360
Pressure Gauge....................... 159
Recommendation...................358,406
448 INDEX

Speed Control.......................... 118
Speedometer........................... 159
Springs................................ 82
Stabilizer Bars, Electronic Disconnecting........ 81
Starting............................... 267
Automatic Transmission................. 268
Engine Fails to Start.................... 268
Manual Transmission................... 267
Steering
Column Controls...................... 113
Column Lock.......................... 15
Linkage............................. 368
Power...........................286,367
Wheel, Tilt........................... 117
Storage, Behind the Seat................... 142
Storage Compartment, Center Seat........... 142
Storage, Vehicle......................... 393
Storing Your Vehicle...................... 393
Sun Roof.............................. 136Supplemental Tire Pressure Information........ 304
Synthetic Engine Oil...................... 359
Tachometer............................ 158
Tailgate............................... 148
Tether Anchor, Child Restraint.............63,66
Tilt Steering Column..................... 117
Tire and Loading Information Placard....291,292,304
Tire Identification Number (TIN)............. 289
Tire Markings.......................... 286
Tire Safety Information.................... 286
Tires .............................74,82,295
Air Pressure.......................... 295
Alignment........................... 303
Chains.............................. 304
Changing............................ 337
Compact Spare........................ 299
General Information.................... 295
High Speed.......................... 298
452 INDEX