2005 CHRYSLER PT CRUISER towing

CAUTION!
Do not overfill. Dirt and water in the transaxle can
cause serious damage. To prevent dirt and water
from entering the transaxle after checking or replen-
ishing fluid, make certain that the dipstick cap is
seated properly.
Fluid And Filter Changes
Automatic transmission fluid and filter should be
changed as follows:
Maintenance schedule“A”—Turbo Charged Engines–
No change necessary.
Maintenance schedule“B”–Every 60,000 miles (96 000
km) change fluid and filter under the following condi-
tions:
•Police, taxi, limousine, commercial type operation, or
trailer towing where the vehicle is drivenregularlyfor
more than 45 minutes of continuous operation.
NOTE:Refer to Section 8 of this manual for mainte-
nance schedules.
If the transaxle is disassembled for any reason, the fluid
and filter should be changed.
Special Additives
The manufacturer recommends against the addition of
any fluid additives to the transaxle. The only exception to
this policy is the use of special dyes to aid in detecting
fluid leaks. The use of transmission sealers should be
avoided as they may adversely affect seals.
MAINTAINING YOUR VEHICLE 283
7

EMISSION CONTROL SYSTEM MAINTENANCE
The“Scheduled”maintenance services, listed inbold
typemust be done at the times or mileages specified to
assure the continued proper functioning of the emission
control system. These, and all other maintenance services
included in this manual, should be done to provide best
vehicle performance and reliability. More frequent main-
tenance may be needed for vehicles in severe operating
conditions such as dusty areas and very short trip
driving.
Inspection and service also should be done any time a
malfunction is suspected.
NOTE:Maintenance, replacement, or repair of the emis-
sion control devices and systems on your vehicle may be
performed by any automotive repair establishment or
individual using any automotive part which has been
certified pursuant to U.S. EPA or, in the State of Califor-
nia, California Air Resources Board regulations.
MAINTENANCE SCHEDULE
There are three maintenance schedules that showre-
quiredservice for your vehicle.
First is Schedule“B”—ALL ENGINES. It is for vehicles
that are operated under the conditions that are listed
below and at the beginning of the schedule.
•Day and night temperatures are below 32°F(0°C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90°F (32°C).
•Trailer towing.†
306 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

SCHEDULE“B”—ALL ENGINES
Follow schedule“B”—All Engines if you usually operate
your vehicle under one or more of the following condi-
tions.
Change the automatic transmission fluid and filter every
60,000 miles (96 000 km) if the vehicle is usually operated
under one or more of the conditions marked with an.
Change the manual transaxle fluid every 48,000 miles (77
000 km) if the vehicle is usually operated under one or
more of the conditions marked with an†.
•Day and night temperatures are below32°F(0°C).
•Stop and go driving.
•Extensive engine idling.
•Driving in dusty conditions.
•Short trips of less than 10 miles (16.2 km).
•More than 50% of your driving is at sustained high
speeds during hot weather, above 90°F (32°C).
•Trailer towing.†
•Taxi, police, or delivery service (commercial ser-
vice).†
•Off-road or desert operation.
•If equipped for and operating with E-85 (ethanol)
fuel.
NOTE:IfANYof these apply to you then change your
engine oil every 3,000 miles (5 000 km) or 3 months,
whichever comes first, and follow schedule“B—All
Engines”of theMaintenance Schedulessection of this
manual.
SCHEDULE“B”—ALL ENGINES 309
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 39,000 42,000 45,000 48,000 51,000 54,000
( Kilometers) (62 000) (67 000) (72 000) (77 000) (82 000) (86 000)
Change engine oil and engine oil filter, if not
replaced at 3 months.XXXXX X
Rotate tires. X X X
Inspect the brake linings. X
Change the brake fluid. If vehicle is used for
trailer towing.X
Inspect theengine air cleaner filter,replace as
necessary.*X
Change the manual transaxle fluid.†X
Inspect theMake-up air filter.Replace as nec-
essary.X
SCHEDULE“B”—ALL ENGINES 313
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 93,000 96,000 99,000 102,000 105,000
(Kilometers) (150 000) (154 000) (159 000) (164 000) (168 000)
Change engine oil and engine oil filter, if not re-
placed at 3 months.XXXXX
Rotate tires. X X
Inspect the brake linings. X
Change the brake fluid. If vehicle is used for trailer
towing.X
Inspect theengine air cleaner filterand replace as
necessary.*X
Change the manual transaxle fluid.†X
Flush and replace the engine coolant, if not replaced
at 60 months.X
Inspect theMake-up air filter,replace as necessary. X
316 SCHEDULE“B”—ALL ENGINES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

* This maintenance is recommended by the manufacturer
to the owner but is not required to maintain the emis-
sions warranty.
‡This maintenance is not required if previously replaced.
†This maintenance is required only for police, taxi,
limousine type operation, or trailer towing.This maintenance is required only for police, taxi,
limousine type operation, or trailer towing.
Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
318 SCHEDULE“B”—ALL ENGINES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Radiator Cap......................... 275
Selection of Coolant.................... 273
Corrosion Protection..................... 284
Crankcase Emission Control System.......... 264
Cruise Light........................... 132
Cup Holder............................ 115
Customer Assistance..................... 331
Dealer Service.......................... 256
Deck Lid.............................. 26
Deck Lid, Emergency Release................ 28
Deck Lid, Power Release................... 27
Defroster, Rear Window................... 176
Defroster, Windshield...................58,171
Delay (Intermittent) Wipers................. 99
Diagnostic System, Onboard................ 254
Dimmer Switch, Headlight.................. 97
Disposal
Engine Oil........................... 261Door Ajar............................. 131
Door Locks............................. 18
Door Locks, Automatic.................... 20
Door Opener, Garage..................... 106
Downshifting.......................... 194
Drive Belts............................ 261
Driving
On Slippery Surfaces.................... 243
Electric Rear Window Defrost............... 176
Electric Remote Mirrors.................... 79
Electrical Power Outlets................... 112
Electronic Power Distribution Center.......... 292
Electronic Speed Control................... 103
Emergency Deck Lid Release................ 28
Emergency, In Case of
Jacking............................. 235
Jump Starting......................... 240
Towing............................. 245
INDEX 343
10

Quality Grading....................... 337
Radial.............................. 214
Replacement......................... 217
Rotation............................. 220
Safety...........................201,210
Sizes............................... 203
Snow Tires........................... 219
Spare Tire........................... 236
Spinning............................ 216
Tread Wear Indicators................... 216
Top Cover.............................. 68
Towing
Disabled Vehicle....................... 245
Traction.............................. 243
Traction Control................102,131,132,200
Traction Control Switch.................102,200
Trailer Towing.......................... 227
Minimum Requirements................. 228
Trailer and Tongue Weight................ 228Warnings............................ 227
Transaxle............................. 185
Automatic....................12,182,185,280
Autostick............................ 190
Manual........................13,182,191
Operation........................... 185
Overdrive........................... 189
Selection of Lubricant................... 280
Transmitter Battery Service.................. 24
Transmitter, Garage Door Opener............ 106
Transmitter Programming................... 23
Transmitter, Remote Keyless Entry............ 21
Transporting Pets........................ 56
Tread Wear Indicators.................... 216
Trip Odometer Reset Button.............131,134
Trunk Lid (Deck Lid)...................... 26
Turbo Cool Down....................... 184
Turn Signals.........................97,128
INDEX 353
10