2005 CHRYSLER 300 radiator cap

NOTE:There are steps that you can take to slow down
an impending overheat condition. If your air conditioner
is on, turn it off. The air conditioning system adds heat to
the engine cooling system and turning off the A/C
removes this heat. You can also turn the Temperature
control to maximum heat, the Mode control to floor, and
the fan control to High. This allows the heater core to act
as a supplement to the radiator and aids in removing heat
from the engine cooling system.
CAUTION!
Driving with a hot cooling system could damage
your vehicle. If temperature gauge reads ªHº, pull
over and stop the vehicle. Idle the vehicle with the
air conditioner turned off until the pointer drops
back into the normal range. If the pointer remains on
the ªHº, turn the engine off immediately, and call for
service.
WARNING!
A hot engine cooling system is dangerous. You or
others could be badly burned by steam or boiling
coolant. You may want to call a service center if your
vehicle overheats. If you decide to look under the
hood yourself, see Section 7, Maintenance, of this
manual. Follow the warnings under the Cooling
System Pressure Cap paragraph.
JACKING AND TIRE CHANGING
WARNING!
Do not attempt to change a tire on the side of the
vehicle close to moving traffic. Pull far enough off
the road to avoid the danger of being hit when
operating the jack or changing the wheel.
WHAT TO DO IN EMERGENCIES 265
6

Whenever a change is noticed in the sound of the exhaust
system, when exhaust fumes can be detected inside the
vehicle, or when the underside or rear of the vehicle is
damaged, have a competent mechanic inspect the com-
plete exhaust system and adjacent body areas for broken,
damaged, deteriorated, or mispositioned parts. Open
seams or loose connections could permit exhaust fumes
to seep into the passenger compartment. In addition,
inspect the exhaust system each time the vehicle is raised
for lubrication or oil change. Replace as required.
WARNING!
Exhaust gases can injure or kill. They contain carbon
monoxide (CO) which is colorless and odorless.
Breathing it can make you unconscious and can
eventually poison you. To avoid breathing CO, fol-
low the preceding safety tips.
Cooling System
Inspection
WARNING!
²When working near the radiator cooling fan, turn
the ignition key to the OFF position. The fan is
temperature controlled and can start at any time
when the ignition key is in the ON position.
²You or others can be badly burned by hot coolant
or steam from your radiator. If you see or hear
steam coming from under the hood, don't open
the hood until the radiator has had time to cool.
Never try to open a cooling system pressure cap
when the radiator is hot.
MAINTAINING YOUR VEHICLE 303
7

Ball Joints............................ 301
Battery............................... 297
Jump Starting........................ 273
Keyless Transmitter Replacement.......... 23
Location.........................274,298
Bearings.............................. 311
Belts, Drive........................... 295
Body Mechanism Lubrication.............. 301
B-Pillar Location....................... 232
Brake Assist System..................... 112
Brake, Parking......................... 222
Brake System.......................224,307
Anti-Lock........................... 225
Fluid Check......................309,334
Hoses.............................. 308
Warning Light....................... 142
Brake/Transmission Interlock.............. 221
Break-In Recommendations, New Vehicle...... 57
Bulb Replacement...................... 323
Bulbs, Light........................... 322
Calibration, Compass.................... 151
Capacities, Fluid....................... 332Caps, Filler
Fuel............................... 254
Radiator............................ 305
Car Washes........................... 312
Carbon Monoxide Warning............... 253
Cargo Tie-Downs....................... 131
Cassette Tape and Player Maintenance....... 192
Catalytic Converter..................... 296
CD Player......................159,164,175
Cellular Phone.......................... 68
Chains, Tire........................... 248
Changing A Flat Tire.................... 265
Chart, Tire Sizing....................... 229
Child Restraint...................50,52,54,55
Child Restraint Tether Anchors............. 54
Child Safety Locks....................... 19
Clean Air Gasoline...................... 251
Climate Control........................ 194
Clock................................ 158
Compact Disc Maintenance............... 193
Compact Spare Tire..................... 239
Compass............................. 150
Compass Calibration.................... 151
INDEX 363
10

Compass Variance...................... 151
Computer, Trip/Travel................... 149
Console.............................. 130
Console, Floor......................... 130
Console, Overhead...................... 118
Contract, Service....................... 354
Coolant Pressure Cap.................... 305
Cooling System........................ 303
Adding Coolant (Antifreeze)............. 305
Coolant Capacity..................... 332
Coolant Level........................ 306
Disposal of Used Coolant............... 306
Drain, Flush, and Refill................. 304
Inspection........................... 303
Points to Remember................... 306
Pressure Cap........................ 305
Radiator Cap........................ 305
Selection of Coolant.............304,332,333
Cruise Control......................... 115
Cup Holder........................129,315
Customer Assistance.................... 352
Data Recorder, Event..................... 48Dealer Service......................... 289
Defroster, Rear Window.................. 195
Defroster, Windshield...............59,196,201
Delay Wipers.......................... 108
Diagnostic System, Onboard............... 287
Dimmer Switch, Headlight................ 106
Disposal
Antifreeze........................... 306
Door Locks............................ 15
Door Locks, Automatic................... 17
Door Opener, Garage.................... 119
Drive Belts............................ 295
Drive Shaft Universal Joints............... 301
Driver's Seat Glide Feature................ 95
Driving
On Slippery Surfaces.................. 276
Electric Remote Mirrors................... 67
Electrical Power Outlets.................. 127
Electronic Speed Control................. 115
Electronic Stability Program............... 113
Electronic Vehicle Information Center........ 147
364 INDEX

Power
Brakes............................. 224
Distribution Center.................... 315
Door Locks.......................... 16
Mirrors............................. 67
Outlet.............................. 127
Seats............................... 89
Steering............................ 227
Steering, Checking.................... 300
Sunroof............................ 124
Tilt/Telescoping Steering Column......... 109
Windows............................ 25
Pregnant Women and Seat Belts............. 36
Preparation for Jacking................... 266
Programmable Electronic Features..... 119,123,154
Programming Transmitters............. 119,123
Radial Ply Tires........................ 239
Radiator Cap.......................... 305
Radio..........................159,164,175
Radio Broadcast Signals.................. 191
Radio Operation...............159,164,175,194
Radio Remote Controls.................. 190Radio, Satellite......................... 187
Rain Sensitive Wiper System.............. 107
Rear Seat, Folding....................... 97
Rear Window Defroster.................. 195
Rearview Mirrors........................ 65
Reclining Front Seats..................... 90
Recommended Fluids, Lubricants and Genuine
Parts............................... 333
Recorder, Event Data..................... 48
Recreational Towing..................... 261
Refrigerant............................ 299
Reminder, Seat Belt...................... 35
Remote Keyless Entry.................... 20
Remote Sound System Controls............ 190
Remote Trunk Release.................... 28
Replacement Tires...................... 241
Reporting Safety Defects................. 356
Restraint, Head......................... 96
Restraints, Occupant..................... 29
Rocking Vehicle When Stuck.............. 277
Rotation, Tires......................... 249
Safety Checks Inside Vehicle............... 58
370 INDEX