2005 BMW Z4 ROADSTER Service and warranty information

5
Engine Oil Service
Engine CompartmentZ4 2.5i, 3.0i
Change oil and oil filter while engine is at normal operating temperature. •
We recommend BMW 5W-30 High Performance Synthetic Oil,
p/n 07 51 0 017 866.
Reset service interval indicator. •
Replace microfilter. •
Check overall thickness of front and rear disc brake pads using special tool. •
If replacement is necessary: Examine brake disc surfaces. Clean brake pad
contact points in calipers. Grease wheel centering hubs.
Check thickness of parking brake linings only when replacing rear pads.
Check parking brake actuation. Adjust if necessary. •

Inspection I
Only those items of inspection work which apply to your vehicle will be performed. This list is
subject to amendment.
Undercarriage
6Z4 2.5i, 3.0i
Change oil and oil filter while engine is at normal operating temperature. •
We recommend BMW 5W-30 High Performance Synthetic Oil,
p/n 07 51 0 017 866.
Check transmission for leaks. •
Check rear axle for leaks. •
Half-shafts: Check for leaks at flexible boots. •
Visually check fuel tank, lines and connections for leaks. •
Check condition, position, and mounting of exhaust system. Examine for leaks. •
Check steering for absence of play, condition of suspension track rods, •
front axle joints, steering linkage and joint disc.
Check overall thickness of front and rear disc brake pads using special tool. •
If replacement is necessary: Examine brake disc surfaces. Clean brake pad
contact points in calipers. Grease wheel centering hubs. Check thickness
of parking brake linings only when replacing rear brake pads.
Check brake system connections and lines for leaks, damage •
and incorrect positioning.
Check parking brake actuation. Adjust if necessary. •
Check all tire pressures. Correct if necessary. Check condition of tires •
(outer surface [left/right]), tread wear and pattern; in case of uneven tread
wear, readjust wheel alignment if requested (invoice separately).
Inspect entire body according to terms of rust performation limited warranty. •
(Must be performed at least every two years).
Engine Compartment
Read out diagnostic system. •
Check engine cooling system/heater hose connections for leaks. •
Check coolant level and antifreeze protection level. Add coolant if required.
Check windshield washer fluid level and antifreeze protection. •
Fill up and/or correct if required.
Check air conditioner for operation. •
Replace microfilter (Note: reduce replacement interval in dusty •
operating conditions).
Reset service interval indicator.•
Check brake fluid level. Add fluid if needed. •

7
Body/ElectricalZ4 2.5i, 3.0i
Check battery state-of-charge indicator and charge if required. •
Check lighting system, i.e.: headlights, foglights, parking, back-up, license •
plate, interior (including map reading lights), glove box, flashlight,
illuminated makeup mirrors, luggage compartment lights.
Check instrument panel and dashboard illumination. •
Check all warning/indicator lights, check control. •
Check turn signals, hazard warning flashers, brake lights, horns, headlight •
dimmer and flasher switch.
Check wipers and washer system; wiper blades, washer jet positions. •
Check condition and function of safety belts. •
Visually examine all SRS airbag units for torn covers, obvious damage •
or attachment of decals, decorations or accessories.
Check central locking/double lock. •
Check operation of all latches. •
Check heater/air conditioner blower, rear window defogger. •
Check rear view mirrors. •
Final Inspection
Road test with check of brakes, suspension, steering, clutch/manual •
transmission or automatic transmission.
Inspection I

8Z4 2.5i, 3.0i
Replace air cleaner element. (Note: Reduce replacement interval in •
dusty operating conditions).
Inspection II
Includes all items listed under Inspection I, and the following checks
and maintenance operations.
Engine Compartment
Brake Fluid Service
Replace brake fluid every 2 years (time interval begins from the •
vehicle’s production date).
Oxygen Sensor Service
Replace Oxygen Sensor every 100,000 miles. •
Spark Plug Service
Replace spark plugs every 100,000 miles. •
Automatic Transmission Service
Replace ATF every 100,000 miles. •

9
Speedometer
(Odometer Memory)
changed:
Mileage
DateSpeedometer
(Odometer Memory)
changed:
Mileage
Date
Record of Spark Plug Record of Oxygen Record of brake/ Record of
Replacement Sensor replacement clutch fluid changes ATF change
(Every 100,000 Mi. ) (Every 100,000 Miles) (Every 2 years) (Every 100,000 Mi.)
Date Mileage Date Mileage Date Date

10
BMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/SignatureBMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection I BMW Inspection IBMW Inspection I BMW Inspection I
BMW Inspection I
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection I BMW Inspection IBMW Inspection I BMW Inspection I
BMW Inspection I
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection I BMW Inspection IBMW Inspection I BMW Inspection I
BMW Inspection I
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/SignatureBMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/SignatureBMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection II BMW Inspection IIBMW Inspection II BMW Inspection II
BMW Inspection II
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection II BMW Inspection IIBMW Inspection II BMW Inspection II
BMW Inspection II
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection II BMW Inspection IIBMW Inspection II BMW Inspection II
BMW Inspection II
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature

11
BMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/SignatureBMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection I BMW Inspection IBMW Inspection I BMW Inspection I
BMW Inspection I
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection I BMW Inspection IBMW Inspection I BMW Inspection I
BMW Inspection I
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection I BMW Inspection IBMW Inspection I BMW Inspection I
BMW Inspection I
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/SignatureBMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/SignatureBMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection II BMW Inspection IIBMW Inspection II BMW Inspection II
BMW Inspection II
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection II BMW Inspection IIBMW Inspection II BMW Inspection II
BMW Inspection II
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection II BMW Inspection IIBMW Inspection II BMW Inspection II
BMW Inspection II
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature

12
BMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/SignatureBMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection I BMW Inspection IBMW Inspection I BMW Inspection I
BMW Inspection I
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection I BMW Inspection IBMW Inspection I BMW Inspection I
BMW Inspection I
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection I BMW Inspection IBMW Inspection I BMW Inspection I
BMW Inspection I
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/SignatureBMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/SignatureBMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection II BMW Inspection IIBMW Inspection II BMW Inspection II
BMW Inspection II
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection II BMW Inspection IIBMW Inspection II BMW Inspection II
BMW Inspection II
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Inspection II BMW Inspection IIBMW Inspection II BMW Inspection II
BMW Inspection II
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature
BMW Engine Oil Service BMW Engine Oil ServiceBMW Engine Oil Service BMW Engine Oil Service
BMW Engine Oil Service
Performed at:
(Actual Vehicle Mileage)
(Mileage on Service Indicator)
Date/Stamp/Signature