2005 Alfa Romeo 156 AUX

CORRECT USE OF THE CAR
190
WARNINGOn the 2.0 JTS version,
keep the brake pedal pressed when starting
the engine. As the brake pedal stiffens if it
is pressed repeatedly with the engine off. In
this situation, to allow the engine to be
started, it is necessary to increase the pres-
sure exerted on the pedal itself.PROCEDURE FOR JTD VERSIONS1)Make sure the handbrake is engaged.
2)Move the gearshift lever to neutral.
3)Turn the ignition key to the MARpo-
sition. The warning light
m
on the instru-
ment cluster will turn on.
4)Wait for the
m
warning light to go
off, which will depend on how warm the en-
gine is. With the engine very hot the warn-
ing light may stay on for such a short time
that it is not noticed.
5)Fully depress the clutch pedal.
6)Turn the ignition key to AV Vas soon
as the
m
warning light goes off. Waiting
too long would make the glow plug heating
work pointless.WARNINGThe electric devices that ab-
sorb much energy (air conditioner,
rearscreen heating, etc.) are disengaged au-
tomatically during engine starting.
If the engine does not start at the first at-
tempt, move the ignition key back to the
STOPposition before repeating starting.
If starting is difficult (with the Alfa Romeo
CODE system efficient), do not insist with
prolonged attempts.
Only use an auxiliary battery if it is noted
that the cause is due to low charge of the
car’s battery. Never use a battery charger to
start the engine (see “If the battery is flat”
in the chapter “In an emergency”).
WARMING THE ENGINE– Drive off slowly, at medium revs with-
out accelerating abruptly.
– Do not drive at full performance for the
initial kilometers of the journey, Wait until
the engine coolant temperature is between
50 and 60°C.SWITCHING OFF– Release the accelerator pedal and wait
until the engine reaches idle speed.
– Turn the ignition key to the STOPpo-
sition and switch off the engine.
WARNINGAfter a taxing drive it is bet-
ter to allow the engine to “catch its breath”
before turning it off by letting it idle to al-
low the temperature in the engine com-
partment to fall.

CORRECT USE OF THE CAR
198
PROTECTING EMISSION
REDUCING DEVICESCorrect operation of the antipollution de-
vices not only guarantees respect for the en-
vironment but also influences car perfor-
mance. Keeping these devices in good con-
dition is therefore the first rule for both en-
vironment-friendly and economy driving.
The first precaution is to closely follow the
“Scheduled Maintenance Programme ”. For
petrol engines only use unleaded petrol (95
RON) (specification EN228), for diesel en-
gines only use fuel oil for motor vehicles
(specification EN590).
If difficulty with starting is experienced do
not insist with extended attempts. Especially
avoid bump, tow or coast starts: these may
all damage the catalyst. Only use an auxil-
iary battery to start the car in an emergency.If the engine is “not running smoothly”
when the vehicle is travelling, reduce the re-
quest for performance to a minimum and
contact Alfa Romeo Authorized Services as
soon as possible.
When the fuel reserve warning light comes
on fill up as soon as possible. A low fuel level
may cause an irregular supply to the engine
with inevitable increase of the exhaust gas
temperature; this would result in serious
damage to the catalyst.
Never run the engine, even as a test, with
one or more spark plugs disconnected. Do
not warm the engine at idle speed before
moving off, unless the outside temperature
is very low and, in this case too, for no more
than 30 seconds.
Do not install other heat
guards and do not remove
the existing ones on the catalyst
and exhaust pipe.
WARNING
Do not spray anything on
the catalyst, lambda sen-
sor and exhaust pipe.
WARNING
The failure to follow these
rules may cause a fire
hazard.
WARNING
During normal service the
catalyst reaches high tem-
peratures. Do not therefore park
the car over inflammable materials
(grass, dry leaves, pine needles,
etc.): fire hazard.
WARNING

IN AN EMERGENCY
206
STARTING WITH AN
AUXILIARY BATTERYIf the battery is flat (for battery with op-
tical hydrometer: dark in colour with no
green area in the centre), the engine can be
started using another battery of the same
or a little higher capacity than the flat one.
This is what you should do fig. 1:
1)Remove the protecting cover on the
battery positive pole by pressing the related
side wings (front side), then connect the
positive terminals (plus sign +next to the
terminal) of the two batteries with a special
cable.
2)Connect a second cable to the negative
terminal (–) of the auxiliary battery with
an earth point
Eon the engine or the gear-
box of the car to be started.WARNINGDo not directly connect the
negative terminals of the two batteries: any
sparks may set fire to the gas that may be
released from the battery. If the auxiliary bat-
tery in installed on another car, no metal part
shall accidentally come into contact with this
car and the one with the flat battery.
3)Start the engine.
4)When the engine is running remove the
cables in reverse order.
If after a few attempts the engine does not
start, do not insist but contact Alfa Romeo
Authorized Services.
fig. 1
A0B0181m
Never use a quick battery
charger to start the engine
in an emergency as this
could damage the electronic sys-
tems of your vehicle, particularly
the control units which manage the
starting and supply functions.
The battery terminal con-
necting and disconnecting
operations generate cur-
rent that may cause problems to
the car’s electronic systems. There-
fore, this operation should be car-
ried out by skilled personnel.This starting procedure
must be carried out by
qualified personnel as incorrect op-
erations may provoke electrical
discharge of great intensity. The
liquid contained in the battery is
toxic and corrosive. Avoid contact
with skin and eyes. Keep naked
flame and lighted cigarettes away
from the battery. Do not cause
sparks.
WARNING

IN AN EMERGENCY
242
IN THE EVENT OF A FLAT BATTERYFirst of all, you are advised to refer to the
“Car maintenance” chapter for precautions
to be adopted in order to prevent the bat-
tery from getting flat and to ensure its long
durability.CHARGING THE BATTERYWARNINGThe description of the bat-
tery charging procedure is described only for
informative purposes. This operation should
be carried out by Alfa Romeo Authorized Ser-
vices.
Charging should be slow at a low amp rat-
ing for about 24 hours. Charging for a longer
time may damage the battery.Charge the battery as follows:
– Disconnect the terminal from the bat-
tery negative (–) pole.
– Connect the charger cables to the bat-
tery, respecting polarity.
– Turn on the charger.
– After charging turn off the charger be-
fore disconnecting it from the battery.
– Reconnect the terminal to the battery
negative (–) pole.
STARTING WITH AN AUXILIARY
BATTERYSee “Starting with an auxiliary battery” in
this chapter.
The fluid contained in the
battery is poisonous and
corrosive. Avoid contact with the
skin or eyes. The battery should be
charged in a well ventilated place
and kept away from naked flames
or sources of sparks: danger of ex-
plosion and fire.
WARNING
Never attempt to charge a
frozen battery before
thawing it, the danger of explosion
exists. If it has frozen, always
check that the inside elements are
not broken (risk of short circuit)
and that the body is not cracked,
with the risk of acid coming out
which is poisonous and corrosive.
WARNING

CAR MAINTENANCE
270
– Do not check for current in the cables by
short-circuiting the ends.
– If electrical welding is to be carried out
on the body of the car, the electronic con-
trol units must be disconnected or removed
if the work involves the production of high
temperatures.
You are also reminded that services with
high current absorption activated by the user,
such as bottle warmers, vacuum cleaners,
cellular telephone, mini refrigerator, etc. ac-
celerate the battery drainage process if they
are powered with the engine not run-
ningor running at idle speed.
WARNINGIt should also be noted that
improper branches on connectors of the elec-
tric wiring for installing additional equipment
is dangerous, particularly if safety devices
are involved.
ELECTRONIC CONTROL
UNITSWith normal use of the car, no particular
precautions need to be taken.
In the event of work on the electric system
or emergency starting, the instructions giv-
en below must absolutely be adhered to:
– Always switch off the engine before dis-
connecting the battery from the electric sys-
tem.
– If it is necessary to charge the battery,
always disconnect it from the electric sys-
tem.
– When starting in an emergency, only
use an auxiliary battery and not a battery
charger.
– Check that the bias is correct and that
the connections between the battery and
the electric system are in efficient conditions.
– Do not connect or disconnect the ter-
minals of the electronic units while the ig-
nition key is at MAR.
Battery50 Ah60 Ah70 AhMaximum permissible
loadless absorption
30 mA
36 mA
42 mAThe total absorption of these accessories
(standard and installed later) must be less
than 0.6 mA x Ah (of the battery), as
shown in the table below:
Alterations or repairs to
the electric system carried
out incorrectly and without taking
into account the specifications of
the system, may cause operating
faults with the risk of fire.
WARNING

ALPHABETICAL INDEX
326
A A
L L
P P
H H
A A
B B
E E
T T
I I
C C
A A
L L

I I
N N
D D
E E
X X
A
BS (wheel anti-lock system)
– operation and warnings........... 177
Accessories purchased by
the owner ................................ 166
Additional heater ......................... 135
Additional operations
(car maintenance) ..................... 251
Additional stop light (3rd stop) 230-297
Air bags, front and side ................ 42
– deactivating passenger’s
air bag ................................ 44
– front air bags ........................ 42
– general cautions ................... 46
– passenger side front air bag .... 43
– side air bags
(side bag - window bag) ........ 44
Air cleaner................................... 265
Air recirculation ........................... 129
Air vents .............................. 108-109
Alfa 156 Sportwagon........... 278
Alfa Romeo CODE system .............. 6
– operation .............................. 9
Annual inspection programme
(car maintenance) ..................... 251Armrests
– centre ............................ 23-280
– front .............................. 22
– rear ............................... 23-280
Ashtray
– front .................................... 164
– rear .................................... 164
ASR system ................................. 181
Battery
– advice for prolonging life ........ 269
– charging ........................ 242-268
– checking the charge ............... 267
– maintenance ......................... 266
– replacement ......................... 269
– starting with an auxiliary
battery ................................ 242
Body
– cleaning ............................... 274
– marking................................ 299
– versions ................................ 301
Bodywork paint identification label . 300
Bonnet ....................................... 172
Boot
– capacity ......................... 317-309– current socket ....................... 285
– extension ............................. 289
– lighting ......................... 171-284
– luggage cover ....................... 287
– object retainer net .................. 285
– oddment compartments .......... 285
– opening from inside .. 131-170-282
– opening lever ....................... 135
– opening with remote
control ........................ 8-170-282
– passenger compartment
separation net (lower) ............ 288
– passenger compartment
separation net (upper)............ 288
– securing the load ............ 171-283
– tailgate closing ............... 171-283
– warnings for carrying
luggage.......................... 172-284
Brake and clutch fluid
– checking level and topping up .. 263
Brakes
– checking fluid level
and topping up ..................... 263
– handbrake ........................... 138
– specifications ......................... 305

ALPHABETICAL INDEX
328
Diesel filter ................................. 265
Dimensions ........................... 315-316
Dipped beam headlights
– aiming for left-hand/
right-hand driving ................... 178
– changing bulbs ..................... 224
– switching on ......................... 48
Direction indicators
– changing front bulbs ............... 223
– changing rear bulbs ................ 228
– changing side bulbs ................ 227
– switching on ......................... 49
Door mirrors.......................... 25-26
Doors
– centralized locking ................. 19
– child safety lock............... 20-279
– opening/closing
from inside ..................... 19-278
– opening/closing
from outside ................... 18-278
– remote control ....................... 7
– remote locking/unlocking ...... 16
Economy and environment-friendly
driving ..................................... 197
Electronic alarm system................. 11
– automatic engagement ........... 14
– cutting out the siren .............. 15
– description ............................ 11
– interrupting the alarm ............. 14
– ministerial homologation ........ 16
– request for additional
emote controls....................... 12
– switching off ........................ 13
– switching on ......................... 12
– volumetric protection ............. 15
– when the alarm is triggered ..... 14
Electronic control units ................. 270
Emergency starting ................ 191-205
– starting by inertia .................. 207
– starting with an auxiliary
battery ................................. 242
Engine
– identification codes................. 301
– marking ............................... 299
– specifications ......................... 302
Engine compartment
– bonnet ................................. 172
– cleaning................................ 276Engine coolant
– checking level and topping up .. 261
– temperature gauge
and warning light ................... 62
Engine lock system
(Alfa Romeo CODE) ................... 6
Engine oil
– checking level and topping up .. 257
– consumption ......................... 258
Environment
– economy and environment-
friendly driving....................... 197
– emission reducing devices . 187-188
– protecting emission
reducing devices .................... 198
– reducing running costs
and environment pollution ....... 195
– use of non-toxic materials........ 187
EOBD system............................... 182
First-aid kit ................................ 247
Fix&Go (quick tyre repair kit) ........ 212
Flashing main beam headlights ..... 49
Fluids and lubricants .................... 320
Front foglights
– adjustment............................ 177
– changing bulbs ..................... 225
– switching on.......................... 136

ALPHABETICAL INDEX
332
Roof bars/ski racks ...................... 292
Roof rack provision ....................... 174
Rubber hoses .............................. 272Safe driving ............................... 192
– before driving off ................... 192
– driving in the fog ................... 194
– driving in the rain ................... 194
– driving on snow and ice .......... 195
– driving with ABS .................... 195
– mountain driving .................... 194
– night driving .......................... 193
– when travelling ...................... 192
Safeguarding the environment ...... 187
Scheduled maintenance
programme .............................. 249
Seat belts ................................... 28
– carrying children safely ........... 35
– front and rear side belt
height adjustment .................. 31
– general instructions ................ 33
– maintenance ......................... 34
– pretensioners......................... 32
– rear central abdominal belt ..... 30
– use ...................................... 28
Seats (front and rear) ............ 21-23
Selespeed gearbox ....................... 141– automatic operation (CITY) ..... 150
– checking the oil level .............. 259
– failure signalling .................... 150
– moving off ............................ 146
– operation with the engine off ... 143
– parking the vehicle ................. 151
– semiautomatic operation
(MANUAL) ............................ 148
– signalling with the buzzer........ 151
– starting the engine ................. 145
– stopping the car ..................... 148
– system activation ................... 142
– towing the vehicle .................. 151
– turning the engine off ............. 145
– warnings .............................. 146
Side lights
– changing front bulbs ............... 226
– changing rear bulbs ............... 228
– switching on.......................... 48
Ski compartment ......................... 24
Snow chains................................ 202
Sound system ...................... 183-293
Sound system presetting
system ............................. 183
Spark plugs (technical data) .......... 305
Speedometer............................... 63
Spray jets – windscreen/rearscreen/
headlight .............................. 274
Starting the engine....................... 189
– emergency starting .......... 191-205
– ignition switch ....................... 17
– procedure for JTD versions ....... 190
– procedure for petrol versions .... 189
– switching off the engine .......... 190
– warming the engine ............... 190
Starting with an auxiliary battery ... 242
Steering system
– specifications ......................... 305
– steering wheel adjustments .... 25
Steering lock .............................. 18
Steering wheel
– adjustment............................ 25
Steering wheel levers ................... 48
Stop lights
– changing bulbs ...................... 228
Sunroof ...................................... 167
– emergency operation ............. 169
– sliding forwards/backwards..... 168
– raising to the quarterlight
position ............................... 168
Sun visors .................................. 166
Symbols .................................... 5-6