2004 VOLVO XC70 headlight

2004 VOLVO XC70
8 A/C compressor, accelerator pedal position sensor, E-box fan 10A
9 Horn 15A
10 Tailgate wiper 10A
11 Ignition coils 20A
12 Brake light switch 5A
13 Windshield wipers 25A
14 ABS/STC/DSTC 30A
15 -
16 Windshield washers, headlight wiper/washers (certain
models) 15A
17 Low beam, right 10A
18 Low beam, left 10A
19 ABS/STC/DSTC 30A
20 High beam, left 15A
21 High beam, right 15A
22 Starter motor 25A
23 Engine control module 5A
24 -


pg. 120 Fuses in the passenger compartment
Fuse box in the passenger compartment
This fuse box is located at the far left side of the instrument panel. E\
xtra fuses and the fuse removal tool
are also stored here. When replacing a blown fuse, be sure to replace it\
with a new one of the same color
and amperage (written on the fuse).
file:///K|/ownersdocs/2004/2004_XC70/04xc70_08a.htm (4 of 22)12/30/200\
6 4:33:05 PM

2004 VOLVO XC70
Location Amperage
1 Low beam headlights 15A
2 High beam headlights 20A
3 Power driver's seat 30A
4 Power passenger's seat 30A
5 Speed-dependent power steering, vacuum pump 15A
6 -
7 Heated seat - front left (option) 15A
8 Heated seat - front right (option) 15A
9 ABS/STC/DSTC 5A
10 Daytime running lights 10A
11 Daytime running lights 10A
12 Headlight wipers (certain models) 15A
13 Electric socket 12 V 15A
14 Power passenger's seat 5A
15 Audio system, VNS 5A
16 Audio system 20A
17 Audio amplifier 30A
18 Front fog lights 15A
19 VNS display 10A
20 -
21 Automatic transmission, shiftlock, extended D2 feed 10A
22 Direction indicators 20A
23 Headlight switch module, climate control system, onboard diagnostic c\
onnector,
steering wheel lever modules 5A
file:///K|/ownersdocs/2004/2004_XC70/04xc70_08a.htm (5 of 22)12/30/200\
6 4:33:05 PM

2004 VOLVO XC70
Replacing high/low beam headlight bulbs
The headlight bulbs must be replaced from the engine compartment.
CAUTION:
l Do not touch the glass on halogen bulbs with your fingers. Grease, oil o\
r any other impurities can be
carbonized onto the bulb and cause damage to the reflector.
l Be sure to use bulbs of the correct type and voltage.


Removing a defective bulb
To remove a defective low beam bulb:
l Switch off all lights and turn the ignition switch to position 0.
file:///K|/ownersdocs/2004/2004_XC70/04xc70_08a.htm (8 of 22)12/30/200\
6 4:33:05 PM

2004 VOLVO XC70
l Open the hood.
l Remove the plastic cover over the bulb (1) by turning it counterclockw\
ise.
l Remove the connector (2).
l Loosen the retaining spring (3) by first moving it to the right and th\
en moving it down, out of the way.
l Pull out the defective bulb. Note the position of the guide lug on the b\
ase of the bulb (4).

Installing a new bulb
To install a new low beam bulb (H7):
l Insert the new bulb, without touching the glass, with the guide lug upwa\
rd (1). The bulb will only seat
properly in this position.
l Move the retaining spring up and push it slightly to the left until it s\
eats properly (2).
l Press the connector into place on the bulb (3).
l Reinstall the plastic cover and turn it clockwise until it is correctly \
in place (4). "TOP" must be
upward.
NOTE: If the vertical aim of your headlights needs to be adjusted for any reas\
on (e.g., towing a trailer
for extended periods), this should be done by an authorized Volvo retai\
ler.

pg. 123 Replacing bulbs

file:///K|/ownersdocs/2004/2004_XC70/04xc70_08a.htm (9 of 22)12/30/200\
6 4:33:05 PM

2004 VOLVO XC70
leave marks on the windshield or fail to wipe efficiently and cleanly.
To obtain maximum lifetime from a set of wiper blades, clean them with a\
stiff-bristle brush and warm,
soapy water as part of a normal car wash.
Replacement of tailgate wiper blade
Pull the wiper arm out away from the glass. Pull off the wiper blade out\
wards toward the tailgate. Press
the new wiper blade into place. Check that it is properly secured.
Headlight wiper blades (certain models)
Pull the wiper blade in the direction indicated by the arrow in the illu\
stration to remove it. Press the new
wiper blade into place. The long section of the blade should point towar\
d the grille. Check that the new
blade is properly attached to the wiper arm.




Contents | Top of Page
file:///K|/ownersdocs/2004/2004_XC70/04xc70_08b.htm (16 of 16)12/30/20\
06 4:33:06 PM

2004 VOLVO XC70
Battery
Voltage: 12 Volt, capacity: 600 A/115 min reserve capacity.
The battery contains corrosive and poisonous acids. It is of the utmost \
importance that old batteries are
disposed of correctly. Your Volvo retailer can assist you in this matter\
.
Generator
Rated output: max. current: 140 A
Starter motor:
Output: 1.7 kW
Bulbs
Bulb US no. Power Socket
Headlights
- High beam HB360W -
- Low beam H7 55W -
Bi-Xenon headlights*
(option) 35W
D2R
Front parking lights 5W W2.1x9.5d
Front direction indicators (yellow) 21 W BAU 15d
Front fog lights H1 55 W -
- V70R H3 55 W -
Rear direction indicators (yellow) 21W BAU 15 s
Tail lights 67 5W BA 15 s
Brake lights 115621W BA 15 s
Backup lights 115621W BA 15 s
Rear fog light/rear parking lights 21/4W BA 15 s
License plate light - 5 W W 2.1x9.5d
Door step courtesy lights
Front -5W SV 8.5
Cargo area lights - 5 W SV 8.5
Glove compartment light -2 W BA 9s
Vanity mirror light(s) - 12V
1.2W -
file:///K|/ownersdocs/2004/2004_XC70/04xc70_09.htm (10 of 12)12/30/200\
6 4:33:07 PM

2004 VOLVO XC70
Instrument lighting- 3 W W
2.1x9.5d
* Bi-Xenon headlight bulbs (option) contain trace amounts of mercury. \
These bulbs should always be
disposed of by an authorized Volvo retailer.
WARNING!
Bi-Xenon headlights (option) - due to the high voltage used by these h\
eadlights, these bulbs should
only be replaced by an authorized Volvo service technician.
All specifications are subject to change without prior notice.

pg. 151 On Call Roadside Assistance

Volvo On Call Roadside Assistance
Your new Volvo comes with a four-year On Call Roadside Assistance progra\
m. Additional information,
features, and benefits are described in a separate information package i\
n your glove compartment.
If you have misplaced your package, dial:
In the U.S.A.
1-800-63-VOLVO (1-800-638-6586)
In Canada:
1-800-263-0475
file:///K|/ownersdocs/2004/2004_XC70/04xc70_09.htm (11 of 12)12/30/200\
6 4:33:07 PM

2004 VOLVO XC70
Fuel tank cover 86
Fuel/emissions systems
132
Fuses
118-121
G
Gas cap
86
Gasoline
84
Gear indicator
27
Geartronic (automatic transmission)
92, 93
Generator
150
Generator warning light
28
H
Hand brake
39
Handgrip - XC70
55, 73
Handling
96
Hazard warning flashers
38
Head restraint (center) - 3-section rear seat
64
Head restraint - center rear
3
Headlight bulbs - replacing
122
Headlight wiper blades - replacing
142
Headlights
34
Heated front seats
38
Heated rear window
38
Heated sideview mirrors
38
Heating
48-51
Hoisting the car
135
Holder for grocery bags
67
Home Safe System
76
HomeLink®
169-171
Hood - opening
136
I
Ignition switch
35, 36
Immobilizer (start inhibitor)
76, 87
file:///K|/ownersdocs/2004/2004_XC70/04xc70_12.htm (6 of 12)12/30/2006\
4:33:10 PM