2004 Peugeot Partner VU Dag light

Disarming the passenger air bag*
To ensure the safety of your child, it is essential to disarm the pas-senger air bag when you install arear-facing child seat on the frontpassenger seat. With the ignition switched off, insert the key into the passengerair bag disarming switch 1, turn it
to the "OFF" position, then
remove the key keeping the slotin this position.
The air bag warning light on theinstrument panel is lit throughoutthe disarming process.
YOUR PARTNER IN DETAIL
82
22-12-2003
FRONT AIR BAGS These are folded in the centre of the steering wheel for the driver and in
the fascia for the front passenger.
They are deployed simultaneously,except in cases where the passen-ger air bag is disarmed. Front air bag fault
If this warning light comeson on the instrument panel, accompanied by anaudible signal, contact a
PEUGEOT dealer to have
the system checked.
AIR BAGS
The air bags have been designed to maximise the safety of the occu-pants in the event of serious colli-
sions. They work in conjunction withthe pretensioning seat belts. The electronic detectors register and analyse any abrupt decelerationof the vehicle: if the triggeringthreshold is reached, the air bagsinflate instantly and protect theoccupants of the vehicle. Immediately after the impact, the air bags deflate rapidly so that they donot hinder the visibility of the occu-pants nor their exit if necessary fromthe vehicle. The air bags are not deployed in the case of collisions which are not seri-
ous, for which the seat belt is suffi-cient to ensure maximum protection.The seriousness of a collisiondepends on the nature of the obsta-cle and the speed of the vehicle atthe moment of the collision. Air bags only operate when the ignition is switched on. Note:
the gas escaping from the air
bags can be a minor irritant.
* According to destination.

YOUR PARTNER IN DETAIL83
22-12-2003
In the
"OFF" position, the passen-
ger air bag will not be triggered in the event of an impact. As soon as the child seat is removed, turn the air bag slot to the"ON" position to re-activate the air
bag and thus ensure the safety ofyour passenger in the event of animpact. Operating check This is confirmed by an indicator light, accompanied by an audiblesignal.
With the ignition on (2ndnotch), illumination of thiswarning light accompaniedby an audible signal, indi-cates that the passenger
air bag is disarmed (switch in the"OFF" position). SIDE AIR BAGS* These are incorporated into the frame of the front seat backs, on thedoor side. They are deployed independently of each other depending on which sidethe collision occurs, in collisionswhich could cause injury to thechest, the abdomen or the head. Air bag fault
If this warning light comes on, accompanied by anaudible signal, contact a
PEUGEOT dealer to havethe system checked.
* According to destination.

YOUR PARTNER IN DETAIL83
22-12-2003
In the
"OFF" position, the passen-
ger air bag will not be triggered in the event of an impact. As soon as the child seat is removed, turn the air bag slot to the"ON" position to re-activate the air
bag and thus ensure the safety ofyour passenger in the event of animpact. Operating check This is confirmed by an indicator light, accompanied by an audiblesignal.
With the ignition on (2ndnotch), illumination of thiswarning light accompaniedby an audible signal, indi-cates that the passenger
air bag is disarmed (switch in the"OFF" position). SIDE AIR BAGS* These are incorporated into the frame of the front seat backs, on thedoor side. They are deployed independently of each other depending on which sidethe collision occurs, in collisionswhich could cause injury to thechest, the abdomen or the head. Air bag fault
If this warning light comes on, accompanied by anaudible signal, contact a
PEUGEOT dealer to havethe system checked.
* According to destination.

PRACTICAL INFORMATION91
22-12-2003
Refitting the wheel
Ð After positioning the wheel, lightly pre-tighten the bolts using the wheelbrace.
Ð Compress the jack and release it.
Ð Fully tighten the bolts using the wheelbrace.
Ð Replace the trim, starting at the valve passage hole, and press it on using the
palm of the hand.
Replacing the wheel in the carrier
Ð Replace the chock 2 in the wheel.
Ð Replace the wheel in the carrier.
Ð Lift the wheel then the carrier and reposition the hook.
Ð Do not forget to fully tighten the spare wheel carrier retaining bolt.
Ð Stow the wheelbrace 1 and the jack.
For your safety, always change a wheel:
Ð on level, stable and non slippery ground,
Ð with the handbrake applied,
Ð with first or reverse gear engaged,
Ð with the vehicle chocked,
Ð never go underneath a vehicle raised using a jack (use an axle stand).
After changing the wheel
Ð Have the tightening of the bolts and the pressure of the spare tyre checked as soon as possible
by a PEUGEOT dealer.
Ð Have the punctured tyre repaired and replace it on thevehicle as soon as possible.

PRACTICAL INFORMATION
92
22-12-2003
CHANGING A BULB Front lights
1 - Dipped beam headlamps/Main beam headlamps
(H4-60/55 W)
Ð Turn and remove the protector A.
Ð Disconnect the connector.
Ð Unclip the spring.
Ð Remove and replace bulb. 2 - Side lights (W 5 W)
Ð Turn and remove the protector
A.
Ð Pull the bulb holder rearwards.
Ð Change the bulb.
3 - Direction indicators (PY 21 W amber)
Ð Turn the bulb holder B a quarter turn and remove it.
Ð Change the bulb. Note: in certain weather conditions (low temperatures,
humidity), the presence of condensation on the inside
of the headlamp glass is normal ; it disappears a few
minutes after the lights have been switched on.

Rear lights
1 - Fog lamp (P 21 W).
2 - Direction indicators (P 21 W).
3 - Reversing lights (P 21 W).
4 - Brake lights/Side lights (P 21/5 W).Ð Open the rear door.
Ð Unscrew the nut
A.
Ð Push the light unit gently towards the interior of the vehicle to unclip the two side retaining clips.
Ð Remove the light unit and disconnect it.
Ð Unclip the bulb holder by pressing the tabs B.
Ð Change the faulty bulb.
PRACTICAL INFORMATION
94
22-12-2003
Number plate lights (W 5 W) Unclip the translucent protector to gain access to the bulb.

PRACTICAL INFORMATION95
22-12-2003
Third brake light (tailgate) (W 5 W) 
With the tailgate open, unscrew the two nuts.
 Unclip the support to gain accessto the bulbs.
 Change the faulty bulb. Third brake light (rear left door) (W 5 W) 
Remove the housing cover by pressing the tab A(round
section) at the end of the light.
 Pull the housing cover rearwards. 
Squeeze the two tabs B to
remove the bulb holder.
 Pull the faulty bulb and change it.
To refit, proceed in the reverse order.

PRACTICAL INFORMATION99
22-12-2003
Fuse N¡ Rating
Functions
1 10 A Pre-heat unit (diesel) - Brake and clutch switches - Reversing lights.
2 15 A Fuel pump.
3 10 A ABS control unit.
4 10 A Engine control unit.
5Ð Not used.
6 15 A Front fog lamps.
7 20 A Headlamp wash pump.
8 20 A Fan assembly relay - Engine control unit.
9 15 A Left-hand dipped beam.
10 15 A Right-hand dipped beam.
11 10 A Left-hand main beam.
12 10 A Right-hand main beam.
13 15 A Horns.
14 10 A Front and rear windscreen wash pumps.
15 30 A Oxygen sensor - Air flow sensor.
16 30 A Air pump relay.
17 30 A Front windscreen wiper.
18 40 A Air conditioning fan.