2004 Peugeot Partner VP fuel pump

14YOUR PARTNER AT A GLANCE
OPENING THE BONNET Inside the vehicle:Pull the
control on the left-hand side, under the fascia panel. Outside the vehicle: Lift
the control, raise the bonnet and secure thestrut to keep the bonnetopen.
FILLING WITH FUEL This operation must be carried out with
the engine switched off.
 Insert the key then turn it to the left.
 Remove the cap.
An indication shows which type of fuel to use.
When you fill your tank, do not continue after the third cut-off of the pump. This could cause a malfunction. The capacity of the tank is approximately 55 litres for petrol engines and 60 litres for Diesel engines. Note: the right-hand sliding side door cannot be opened while the fuel tank
cap is removed.
Low fuel level warning light From the time this light comes on, you have enough fuel left to cover approximately 30 miles (50 km) .
7271
22-12-2003

22-12-2003
YOUR PARTNER IN DETAIL
72
FILLING WITH FUEL Low fuel level
When the minimum fuel level in the tank is reached, this warninglight comes on.
You have enough fuel remainingto drive for approximately 30 miles (50 km). The engine must be switched off when filling with fuel.  Insert the key then turn it to the left.
 Remove the cap.
An indication reminds you which type of fuel to use. When you fill your tank, do not
continue after the third cut-off of the
pump. This could cause your vehicleto malfunction. The capacity of the tank is approximately 55 litres for petrolengines and 60 litres for Dieselengines. After filling the tank, lock the cap.
When the cap is removed, the right-hand sliding sidedoor cannot be opened. The key cannot be remo-
ved from the lock until the cap has been replaced on the fueltank.

22-12-2003
PRACTICAL INFORMATION
98
CHECKS Battery
At the start of winter, have your battery checked by a PEUGEOT
dealer. Air filter and passenger compartment filter Have the filter elements replaced
regularly.
If you drive in dusty
conditions, change them twice asoften. Brake pads Brake pad wear depends on the style of driving, in particular forvehicles which are used in town,over short distances. It may be necessary to check the thickness of the pads, even betweenservices. Handbrake Where the handbrake travel is too great or there is a reduction in theperformance of the system, thehandbrake should be adjusted, evenbetween services. Have the system checked by a
PEUGEOT dealer. Oil filter
Change the filter regularly, in accor- dance with the servicing schedule. Manual gearbox This does not require an oil change. Check the level in accordance withthe manufacturer's servicing sche-dule.
Only use products recom-
mended by PEUGEOT.
To ensure best performan-
ce from components as important as the power steering and the bra-king system, PEUGEOT selectsand offers quite specific products.
To prevent damage to the electri- cal units, avoid washing the engine.
RUNNING OUT OF FUEL (DIESEL) If you should run out of fuel, it is necessary to re-prime the circuit:
- fill the fuel tank with at least five litres of diesel,
- operate the manual re-priming pump, under the bonnet under the
protective cover, until fuel appearsin the transparent pipe,
- operate the starter until the engine starts.
FUEL SUPPLY CUT-OFF (PETROL) In a serious collision, a mechanism prevents fuel from reaching the engine.
To re-establish the fuel supply, press the switch on the corner of the front
right-hand suspension assembly,under the bonnet.

PRACTICAL INFORMATION109
22-12-2003
Fuse N¡ Rating
Functions
1 10A Pre-heat unit (diesel) - Brake and clutch switches - Reversing light.
2 15A Fuel pump.
3 10A ABS control unit or ESP control unit.
4 10A Engine control unit.
5- Not used.
6 15A Front fog lamps.
7 20A Headlamp wash pump.
8 20A Fan assembly relay - Engine control unit.
9 15A Left-hand dipped beam.
10 15A Right-hand dipped beam.
11 10A Left-hand main beam.
12 10A Right-hand main beam.
13 15A Horns.
14 10A Front and rear windscreen wash pumps.
15 30A Oxygen sensor - Air flow sensor.
16 30A Air pump relay.
17 30A Front windscreen wiper.
18 40A Air conditioning fan.